STR-DE315/DE415 SERVICE MANUAL
A E P Model U K Model
P hoto : S T R -D E 415 model
Manufactured under license from Dolby Laboratories Licensing C orporation. “D O LB Y ”, “P R O LO G IC ” and the double-D symbol are trademarks of D olby Laboratories Licensing C orporation.
SPECIFICATIONS Amplifier section Power output Stereo mode
Surround mode
Frequency response
(DIN 1kHz, 4ohms) STR-DE415 : 80W + 80W STR-DE315 : 80W + 80W (DIN 1kHz, 4ohms) Front : STR-DE415 : 70W/ch STR-DE315 : 60W/ch Center : STR-DE415 : 70W STR-DE315 : 60W (only in PROLOG MODE) Rear : STR-DE415 : (DIN 1kHz, 4ohms) 70W STR-DE315 : (DIN 1kHz, 4ohms) 60W PHOTO : RIAA equalization curve ± 0.5dB TV/LD, CD, TAPE/MD, VIDEO : 10Hz - 50kHz ± 1dB
Inputs
PHONO (MM) CD, TAPE/MD, TV/LD, VIDEO
Sensitivity Impedance S/N (Weighting network, input level) 2.5mV 50 74dB Kilohms 72dB*** (A,2.5mV) 200mV 50 82dB Kilohms 82dB*** (A, 150mV) 150mV
BASS BOOST
+ 10dB at 70Hz
TONE
± 8dB at 100Hz and 10kHz
FM tuner section Tuning range
87.5 - 108.0MHz (OTHER) 65.0 - 74.0MHz (East European)
Aerial range
75ohms, unbalanced
Sensitivity
Mono : 18.3 dBf, 2.2µV /75ohms Stereo : 38.3 dBf, 22.5µV /75ohms
Usable sencitivity
11.2 dBf, 1µV /75ohms (IHF)
S/N
Mono : 76dB Stereo : 70dB
Harmonic diatortion at 1kHz
Mono : 0.3% Stereo : 0.5%
Separation
45dB at 1kHz
***78 IHF Output
Muting
TAPE/MD REC OUT : Voltage : 150mV, Impedance : 10 kilohms VIDEO AUDIO OUT : Voltage : 150mV, Impedance : 10 kilohms MIX AUDIO OUT (STR-DE415 only) Voltage : 2V Impedance : 10 kilohms PHONES :Accepts low and high impedance headphones Full mute
Frequency response
+ 0.5
30Hz - 15kHz – 2 dB — C ontinued on next page —
FM STEREO/FM-AM RECEIVER MIC R O F ILM
TABLE OF CONTENTS Selecitivity
60dB at 400kHz
Specifications ··············································································· 1
AM tuner section Tuning range
522 - 1611 kHz
1.
GENERAL
Aerial
Loop aerial
Location and Function of controls ················································ 3
Usable sensitivity
50dB/m (at 999kHz)
2.
EXPLANATION OF IC TERMINALS ··················· 5
S/N
54dB (at 50mV/m)
3.
DIAGRAMS
Harmonic distortion
0.5% (50mV/m, 400Hz)
Selectivity
35dB
3-1. 3-2. 3-3. 3-4. 3-5.
Circuit Boards Location ····················································· 6 Printed Wiring Boards — Main Section — ························ 7 Schematic Diagram — Main Section — ·························· 11 Schematic Diagram — Display Section — ······················ 16 Printed Wiring Boards — Display Section — ·················· 19
4.
EXPLODED VIEWS
General system
Tuner section : PLL quartz-locked digital synthesizer system Preamplifier section : Low-noise NF type equalizer Power amplifier section : Pure-complimentary SEPP
Power requirements
230VAC, 50/60Hz
Power consumption
STR-DE415 : 175W STR-DE315 : 175W
AC outputs
Switched 100W (except for the U.K. model)
Dimensions
430 × 145 × 295mm
4-1. Front Panel Section ·························································· 23 4-2. Chassis Section ································································· 24
5.
Mass (Approx.) 6.4kg Supplied accessories
FM wire aerial (1) AM loop aerial (1) Remote controller (remote) (1) Size AA (R6) batteries (2) Scart adaptor (1)
Design and specifications are subject to change without notice.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
—2—
ELECTRICAL PARTS LIST ································ 25
SECTION 1 GENERAL LOCATION AND FUNCTION OF CONTROLS 1
2 3
5
SECTION 2 EXPLANATION OF IC TERMINALS • IC201 µPD78044FGF-064-3B9
4
6
@º !• !§ !¢ @∞
@¢
@£
@™
SECTION 3 DIAGRAMS
@¡ !ª !¶ !∞
!£ !™ !¡!º 9 8 7
!¢ TA P E /MD button !∞ P H O N O button !§ T V /LD button !¶ T U N E R button !• V ID E O button !ª C D button @º D IR E C T button @¡ S H IF T button @™ N umeric buttons @£ Tuner control buttons @¢ P H O N E S jack @∞ S P E A K E R S (A /B ) buttons
1 P O W E R switch 2 C E N T E R LE V E L +, – buttons 3 R E A R LE V E L +, – buttons 4 S TA N D B Y indicator 5 F U N C T IO N indicators 6 MA S T E R V O LU ME control 7 B A LA N C E control 8 T R E B LE control 9 B A S S control !º B A S S B O O S T button/indicator !¡ S U R R O U N D O N /O F F button !™ MO D E button !£ E F F E C T /D E LAY T IME , S E T U P buttons
1
2
3-1.
Pin No.
Pin Name
I/O
1
DIG7
O
2
DIG6
O
3
DIG5
O
4
DIG4
O
5
DIG3
6
DIG2
7
DIG1
O
8
+5V
—
9
S. CLK
10
S. DATA
Description
Pin No.
Pin Name
I/O
41
VOLUME UP
O
Volume up.
42
VOLUME DOWN
O
Volume down.
43
STANDBY
O
Standby LED drive.
44
SYS. POWER
I
System power ON/OFF.
O
45
RDS. DATA. IN
I
RDS data input.
O
46
RDS. CLK. IN
I
RDS clock input. Stop signal input from NJM2103D (IC950).
Fluorescent indicator tube drive.
S E C O N DA RY board
47
STOP
I
Power supply (+5V).
48
Vss
—
I
System clock.
49
SIRCS
I
Sircs signal input.
I
System data.
50
POWER SW
I
Power switch input terminal.
PLL. DATA
I
PLL data input from TU001.
51
5.1ch LED
—
5.1ch LED drive.
12
S. CE (LC7288)
O
Chip enable output.
52
+5V
—
Power supply (+5V).
13
S. CE (LV100)
O
Chip enable output.
53
BASS BOOST
I
Bass boost LED drive.
REAR-R
I
Input for model select.
54
FUNC. MUTE
O
Line mute drive.
15
BRIDGE
I
Protector detect input.
55
SL MUTE
O
SL mute drive.
16
PROTECT
I
Protector detect input.
56
VERSION
I
Input for model select.
I
17
RESET
System reset terminal.
57
K14
I
Key in 4.
18
AUTO-STOP
I
Auto stop detect input.
58
K13
I
Key in 3.
19
STEREO-IN
I
Stereo detect input.
59
K12
I
Key in 2.
20
AVss
—
Ground.
60
K11
I
Key in 1.
21
SP-RY
O
Speaker relay drive.
61
SR MUTE
O
SR mute drive.
22
SURR-RY
O
Surround Relay.
62
S15
O
Key out 15.
23
POWER-RY
O
Power relay drive.
63
S14
O
Key out 14.
24
AVss
—
Ground.
64
S13
O
Key out 13.
25
SIGNAL
I
A/D signal input terminal.
65
S12
O
Key out 12.
26
A/D3
I
A/D3 key input terminal.
66
S11
O
Key out 11.
27
A/D2
I
A/D2 key input terminal.
67
S10
O
Key out 10.
28
A/D1
I
A/D1 key input terminal.
68
S9
O
Key out 9.
29
AVDD
—
Power supply (+5V).
69
S8
O
Key out 8.
30
AV. REF
—
Reference voltage (+5V).
70
S7
O
Key out 7.
31
GND
—
Ground.
71
VLOAD
—
Connect to –24V.
32
NC
—
Not used (Open).
72
S6
O
Key out 6.
33
Vss
—
Ground.
73
S5
O
Key out 5.
34
X1
I
System clock (4.19MHz).
74
S4
O
Key out 4.
35
X2
O
System clock (4.19MHz).
75
S3
O
Key out 3.
36
IC. MUTE
O
Mute drive output for µPD2581V (IC701).
76
S2
O
Key out 2.
37
Key out 1.
38
PROLOGIC
O
Plologic LED.
77
S1
O
SIMULATED
O
CINEMA STUDIO LED.
78
DIG10
O
39
HALL
O
HALL LED.
79
DIG9
O
40
T. MUTE
O
Tuner mute drive output.
80
DIG8
O
S T B Y board
P R IMA RY board
Ground.
11
14
CIRCUIT BOARDS LOCATION
Description
MIX board
S W board
MA IN board S P S W (A ) board
D IS P LAY board S P S W (B ) board K E Y board
Fluorescent indicator tube drive.
VO LU ME board V R -TO N E board
Fluorescent indicator tube drive.
Fluorescent indicator tube drive.
!¡ !£
!™
!º 9 8 7
1 WO O FE R 2 AC O U T LE T (E X C E P T U K ) 3 AC power cord 4 F R O N T S P E A K E R S (A /B ) 5 S U R R O U N D S P E A K E R S (C E N T E R ) 6 S U R R O U N D S P E A K E R S (R E A R ) 7 V ID E O
6 5
4
3
8 T V /LD 9 TA P E /MD !º C D !¡ P H O N O !™ A N T E N N A (F M/A M) !£ S IG N A L G N D
—3—
—4—
—5—
—6—
SECTION 4 EXPLODED VIEWS Note: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.
• • •
SECTION 5 ELECTRICAL PARTS LIST
The mechanical parts with no reference number in the exploded views are not supplied. Hardware (#mark) list is given in the last of this parts list. Abbreviation G : German EE : East European
4-2. T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.
CHASSIS SECTION pB : S W (A ) board pC : S W (B ) board
•
T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.
• •
FRONT PANEL SECTION
Abbreviations G : German EE : East European •
pA : V O LU ME board
7
8
8
Part No.
*
A-4392-962-A DISPLAY BOARD, COMPLETE (DE415:AEP,UK,G) ************************ A-4392-971-A DISPLAY BOARD, COMPLETE (DE315:AEP,UK,G) ************************ A-4398-073-A DISPLAY BOARD, COMPLETE (DE415:EE) ************************ A-4398-075-A DISPLAY BOARD, COMPLETE (DE315:EE) ************************
* *
8
a
Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. CAPACITORS: uF: µF
Ref. No.
*
* *
DISPLAY Ref. No.
W hen indicating parts by reference number, please include the board name.
•
4-1.
DISPLAY
Note:
Description
Remarks
4-921-941-01 CUSHION (FL) 4-943-107-11 HOLDER (FL TUBE)
Ref. No.
Part No.
•
• •
RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... Description
KEY
Description
S211 S212 S213 S214 S215
1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11
SWITCH, KEY BOARD (PRESET TUNING–) SWITCH, KEY BOARD (PRESET TUNING+) SWITCH, KEY BOARD (FM MODE) SWITCH, KEY BOARD (FM) SWITCH, KEY BOARD (AM)
S216
1-554-937-11 SWITCH, KEY BOARD (MEMORY)
SW200
10 13
11
13
a
not supplied
C201 C202 C203 C204 C205
1-104-905-11 1-164-159-21 1-124-465-00 1-164-159-21 1-162-294-31
C206 C207
1-164-159-21 CERAMIC 1-126-096-11 ELECT
4
1-410-509-11 INDUCTOR
#1
18 S O N Y
0.22F 0.1uF 0.47uF 0.1uF 0.001uF 0.1uF 10uF
10%
5.5V 50V 50V 50V 50V
20%
50V 35V
20%
CNS201 1-569-327-11 SOCKET, CONNECTOR 27P CNS202 1-770-400-11 HOUSING, CONNECTOR (PC BOARD) 7P
17 3 pA
15
< DIODE >
14
(Including pA ) #1
#1
2
18 1
Ref. No.
CAPACITOR CERAMIC ELECT CERAMIC CERAMIC
#1
15
Part No.
Description
Ref. No.
Part No.
Description
1 2 3 3 4
4-980-639-01 X-4946-873-1 4-989-844-31 4-989-844-51 4-980-109-01
KNOB (R14) KNOB (R48) ASSY PANEL, FRONT (DE415) PANEL, FRONT (DE315) BUTTON (P-M)
Remarks
* 9 10 11 12 13
A-4398-075-A 1-773-252-11 1-769-908-11 1-765-314-11 4-951-620-01
DISPLAY BOARD, COMPLETE (DE315:EE) WIRE (FLAT TYPE) (27 CORE) WIRE (FLAT TYPE) (9 CORE) WIRE (FLAT TYPE) (7 CORE) SCREW (2.6X8), +BVTP
* 5 * 6 * 7 8 * 9
4-921-941-01 4-943-107-11 4-980-658-01 3-704-366-01 A-4392-962-A
CUSHION (FL) HOLDER (FL TUBE) CASE (413226) SCREW (CASE) (M3X8) DISPLAY BOARD, COMPLETE(DE415:AEP,UK,G)
* 14 15 16 * 17 18
A-4392-964-A 4-977-593-11 3-008-600-11 A-4392-966-A 4-977-358-11
VR-TONE BOARD, COMPLETE RING (DIA. 50), ORNAMENTAL EMBLEM (5-AR), SONY KEY BOARD, COMPLETE CUSHION (8X12.5)
* 9 * 9
A-4392-971-A DISPLAY BOARD, COMPLETE(DE315:AEP,UK,G) A-4398-073-A DISPLAY BOARD, COMPLETE (DE415:EE)
FL201
— 23 —
1-517-141-11 INDICATOR TUBE, FLUORESCENT
Remarks
Remarks
D201 D202 D203 D204 D211
8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85
DIODE DIODE DIODE DIODE DIODE
1S1585 1S1585 1S1585 1S1585 1S1585
D212 D213 D214 D221 D223
8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85
DIODE DIODE DIODE DIODE DIODE
1S1585 1S1585 1S1585 1S1585 (DE315:EE/DE415:EE) 1S1585
DIODE DIODE DIODE DIODE DIODE
1S1585 (DE415) 1S1585 (DE315) 1S1585 SEL6810A-TH12 (HALL) SEL6810A-TH12 (C.STUDIO)
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
* 51 52 * 54 * 55 * 56
A-4392-965-A 4-951-801-01 1-665-273-11 1-665-274-11 1-665-272-11
SW BOARD, COMPLETE BUTTON (S) PRIMARY BOARD SECONDARY BOARD STANDBY BOARD
61 62 63 64 * 65
1-773-252-11 X-4947-207-1 4-924-098-01 4-812-134-00 4-924-098-21
WIRE (FLAT TYPE) (27 CORE) FOOT ASSY (F50150S) HOLDER, PC BOARD RIVET (DIA.3.5), NYLON HOLDER, PC BOARD
D224 D225 D231 D235 D236
8-719-815-85 8-719-815-85 8-719-815-85 8-719-313-50 8-719-313-50
* * * * *
57 57 57 57 58
A-4392-970-A A-4392-972-A A-4398-074-A A-4398-076-A 3-703-244-21
MAIN BOARD, COMPLETE (DE415:AEP,UK,G) MAIN BOARD, COMPLETE (DE315:AEP,UK,G) MAIN BOARD, COMPLETE (DE415:EE) MAIN BOARD, COMPLETE (DE315:EE) BUSHING (2104), CORD
67 70 ! 71 ! 71 ! 72
4-956-370-12 3-905-609-01 1-751-520-11 1-769-744-11 1-770-019-11
BAND, PLUG FIXED (DE315:UK) SCREW (TRANSISTOR) CORD, POWER (DE315:UK) CORD, POWER (EXCEPT DE315:UK) ADAPTER CONVERSION PLUG 3P (DE415:UK)
D237
8-719-313-50 DIODE SEL6810A-TH12 (PRO LOGIC)
DTA124ES DTC124ES DTC124ES DTC124ES
A-4392-966-A KEY BOARD, COMPLETE ********************
3-905-609-01 SCREW (TRANSISTOR) 4-812-134-00 RIVET (DIA. 3.5), NYLON 7-685-872-09 SCREW +BVTT 3X8 (S)
Q201 Q202 Q203 Q231
8-729-900-63 8-729-900-36 8-729-900-36 8-729-900-36
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
R200 R201 R202 R203 R204
1-247-863-91 1-247-903-00 1-249-429-11 1-249-429-11 1-249-425-11
CARBON CARBON CARBON CARBON CARBON
22K 1M 10K 10K 4.7K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W F
R232 R233 R234 R235 R236
1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11
CARBON CARBON CARBON CARBON CARBON
330 470 680 1K 1.5K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W F 1/4W F
R205 R206 R207 R211 R212
1-249-441-11 1-249-429-11 1-249-429-11 1-247-863-91 1-247-863-91
CARBON CARBON CARBON CARBON CARBON
100K 10K 10K 22K 22K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R237 R238 R239 R240 R241
1-249-421-11 1-247-843-11 1-249-411-11 1-249-413-11 1-249-415-11
CARBON CARBON CARBON CARBON CARBON
2.2K 3.3K 330 470 680
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W F 1/4W F
R213 R214 R216 R221 R222
1-247-863-91 1-247-863-91 1-247-863-91 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
22K 22K 22K 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R242 R243 R244 R245 R246
1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-411-11
CARBON CARBON CARBON CARBON CARBON
1K 1.5K 2.2K 3.3K 330
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W F 1/4W 1/4W
R223 R224 R225 R226 R227
1-247-807-31 1-247-807-31 1-247-807-31 1-249-441-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
100 100 100 100K 100K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R247 R248 R249 R280 R281
1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
470 680 1K 1.5K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R228 R229 R230 R231 R270
1-249-412-11 1-249-410-11 1-249-410-11 1-249-427-11 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
390 270 270 6.8K 100
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W F 1/4W F 1/4W
R282
1-247-843-11 CARBON
3.3K
5%
1/4W
R283 R284 R286
1-249-427-11 CARBON 1-249-427-11 CARBON 1-249-437-11 CARBON
6.8K 6.8K 47K
5% 5% 5%
1/4W F 1/4W F 1/4W
S201 S202 S203 S204 S205
1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11
SWITCH, KEY BOARD (CENTER LEVEL–) SWITCH, KEY BOARD (CENTER LEVEL+) SWITCH, KEY BOARD (REAR LEVEL–) SWITCH, KEY BOARD (REAR LEVEL+) SWITCH, KEY BOARD (CHARACTER)
S206 S207 S208 S209 S210
1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11
SWITCH, KEY BOARD (DISPLAY) SWITCH, KEY BOARD (EON) SWITCH, KEY BOARD (PTY) SWITCH, KEY BOARD (TUNING–) SWITCH, KEY BOARD (TUNING+)
< CONNECTOR > CNP205 1-779-366-11 CONNECTOR, BOARD TO BOARD 4P < RESISTOR >
Remarks
* 59 * 59 * 59 60
4-989-901-51 4-989-901-61 4-989-902-31 1-666-496-11
PANEL, BACK (DE315:UK) PANEL, BACK (DE315:AEP,G,EE) PANEL, BACK (DE415) MIX BOARD (DE415)
! CNJ903 1-526-794-11 OUTLET, AC (EXCEPT DE315:UK) ! T901 1-431-260-11 TRANSFORMER, POWER (DE315) ! T901 1-431-266-11 TRANSFORMER, POWER (DE415)
< SWITCH >
— 24 —
T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.
* *
*
Remarks
A-4392-970-A MAIN BOARD, COMPLETE (DE415:AEP,UK,G) ********************** A-4392-972-A MAIN BOARD, COMPLETE (DE315:AEP,UK,G) ********************** A-4398-074-A MAIN BOARD, COMPLETE (DE415:EE) ********************** A-4398-076-A MAIN BOARD, COMPLETE (DE315:EE) **********************
*
X201 1-577-101-11 VIBRATOR, CERAMIC 4.19MHz ************************************************************
10uH
< TRANSISTOR >
Description SWITCH, KEY BOARD (2) SWITCH, KEY BOARD (3) SWITCH, KEY BOARD (4) SWITCH, KEY BOARD (5) SWITCH, KEY BOARD (DIRECT)
< CAPACITOR >
< CONNECTOR >
12 16
*
< VIBRATOR >
< COIL > L401
Part No. 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11
S238 1-554-937-11 SWITCH, KEY BOARD (MODE) S239 1-554-937-11 SWITCH, KEY BOARD (CD) ************************************************************
1-771-054-11 SWITCH, PUSH (1 KEY) (POWER)
Remarks
Ref. No. S233 S234 S235 S236 S237
< CAPACITOR >
5 13 9
F L201
Remarks
< SWITCH >
< RESISTOR >
6
5
MAIN
Part No.
< FILTER > FL201
1-517-141-11 INDICATOR TUBE, FLUORESCENT
IC201 IC202 IC203
8-759-479-19 IC uPD78044FGF-064-3B9 8-759-962-08 IC BA6208 8-759-332-18 IC GP1U27XB (REMOTE SENSOR)
< IC >
— 25 —
< SWITCH > S217 S218 S219 S220 S221
1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11
SWITCH, KEY BOARD (SURROUND ON/OFF) SWITCH, KEY BOARD (SET UP) SWITCH, KEY BOARD (EFFECT/DELAY TIME) SWITCH, KEY BOARD (TV/DBS) SWITCH, KEY BOARD (TUNER)
S222 S223 S224 S225 S226
1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11
SWITCH, KEY BOARD (PHONO) SWITCH, KEY BOARD (VIDEO) SWITCH, KEY BOARD (6) SWITCH, KEY BOARD (7) SWITCH, KEY BOARD (8)
S227 S228 S229 S231 S232
1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11
SWITCH, KEY BOARD (9) SWITCH, KEY BOARD (0) SWITCH, KEY BOARD (SHIFT) SWITCH, KEY BOARD (TAPE/MD) SWITCH, KEY BOARD (1)
F F F F F
C3 C4 C5 C6 C7
1-162-286-21 1-126-961-11 1-162-306-11 1-162-291-31 1-102-527-11
CERAMIC ELECT CERAMIC CERAMIC CERAMIC
220PF 2.2uF 0.01uF 560PF 82PF
10% 20% 20% 10% 5%
50V 50V 16V 50V 50V
C8 C302 C303 C304 C305
1-102-852-91 1-126-934-11 1-130-494-11 1-137-367-11 1-130-494-11
CERAMIC ELECT MYLAR FILM MYLAR
47PF 220uF 0.082uF 0.0033uF 0.082uF
5% 20% 5% 5% 5%
50V 16V 50V 50V 50V
C306 C307 C308 C309 C310
1-126-959-11 1-126-964-11 1-126-964-11 1-162-291-31 1-126-962-11
ELECT ELECT ELECT CERAMIC ELECT
0.47uF 10uF 10uF 560PF 3.3uF
20% 20% 20% 10% 20%
50V 50V 50V 50V 50V
C311 C312 C313 C314 C316
1-126-961-11 1-126-934-11 1-126-934-11 1-136-165-00 1-124-252-00
ELECT ELECT ELECT FILM ELECT
2.2uF 220uF 220uF 0.1uF 0.33uF
20% 20% 20% 5% 20%
50V 16V 16V 50V 50V
C317 C318 C322 C323 C324
1-126-933-11 1-137-363-91 1-126-962-11 1-136-173-00 1-126-967-11
ELECT FILM ELECT FILM ELECT
100uF 680PF 3.3uF 0.47uF 47uF
20% 5% 20% 5% 20%
16V 50V 50V 50V 16V
C325 C326 C327 C328 C329
1-136-165-00 1-136-165-00 1-126-959-11 1-126-963-11 1-126-959-11
FILM FILM ELECT ELECT ELECT
0.1uF 0.1uF 0.47uF 4.7uF 0.47uF
5% 5% 20% 20% 20%
50V 50V 50V 50V 50V
C335 C336 C337 C338 C339
1-136-161-00 1-126-934-11 1-126-964-11 1-126-964-11 1-126-964-11
FILM ELECT ELECT ELECT ELECT
0.047uF 220uF 10uF 10uF 10uF
5% 20% 20% 20% 20%
50V 16V 50V 50V 50V
C340 C341 C342 C343 C344
1-126-964-11 1-126-934-11 1-126-962-11 1-126-962-11 1-136-165-00
ELECT ELECT ELECT ELECT FILM
10uF 220uF 3.3uF 3.3uF 0.1uF
20% 20% 20% 20% 5%
50V 16V 50V 50V 50V
— 26 —
MAIN Ref. No.
Part No.
Description
Part No.
Description
C345 C346 C347 C348 C349
1-136-165-00 1-126-959-11 1-126-963-11 1-126-959-11 1-126-963-11
FILM ELECT ELECT ELECT ELECT
0.1uF 0.47uF 4.7uF 0.47uF 4.7uF
5% 20% 20% 20% 20%
Remarks 50V 50V 50V 50V 50V
C721 C722 C740 C741 C742
1-126-923-11 1-126-964-11 1-128-562-11 1-128-562-11 1-126-925-11
ELECT ELECT ELECT ELECT ELECT
220uF 10uF 47uF 47uF 470uF
20% 20% 20% 20% 20%
10V 50V 100V 100V 10V
C350 C351 C352 C353 C354
1-124-250-11 1-126-962-11 1-124-250-11 1-164-159-21 1-164-159-21
ELECT ELECT ELECT CERAMIC CERAMIC
0.15uF 3.3uF 0.15uF 0.1uF 0.1uF
20% 20% 20%
50V 50V 50V 50V 50V
C743 C752 C753 C755 C760
1-126-925-11 1-162-282-31 1-126-933-11 1-102-233-00 1-126-967-11
ELECT CERAMIC ELECT CERAMIC ELECT
470uF 100PF 100uF 33PF 47uF
20% 10% 20% 10% 20%
10V 50V 10V 500V 16V
C355 C356 C357 C359 C360
1-164-159-21 1-164-159-21 1-164-159-21 1-126-963-11 1-126-963-11
CERAMIC CERAMIC CERAMIC ELECT ELECT
0.1uF 0.1uF 0.1uF 4.7uF 4.7uF
50V 50V 50V 50V 50V
C761 C770 C799 C801 C802
1-137-372-11 1-162-286-21 1-164-159-21 1-104-664-11 1-104-664-11
FILM CERAMIC CERAMIC ELECT ELECT
0.022uF 220PF 0.1uF 47uF 47uF
5% 10% 20% 20%
50V 50V 50V 25V 25V
C363 C365 C366 C401 C402
1-164-159-21 1-126-966-11 1-164-159-21 1-162-286-21 1-126-962-11
CERAMIC ELECT CERAMIC CERAMIC ELECT
0.1uF 33uF 0.1uF 220PF 3.3uF
50V 16V 50V 50V 50V
C803 C804 C805 C806 C807
1-128-506-11 1-128-506-11 1-130-781-00 1-130-781-00 1-104-664-11
ELECT ELECT FILM FILM ELECT
6800uF 6800uF 0.22uF 0.22uF 47uF
20% 20% 10% 10% 20%
50V 50V 100V 100V 25V
C403 C404 C405 C406 C407
1-126-966-11 1-162-282-31 1-137-459-11 1-164-159-21 1-137-365-11
ELECT CERAMIC FILM CERAMIC FILM
33uF 100PF 0.0056uF 0.1uF 0.0015uF
20% 10% 5%
16V 50V 100V 50V 50V
C808 C809 C810 C811 C812
1-104-664-11 1-126-960-11 1-126-960-11 1-126-942-61 1-126-942-61
ELECT ELECT ELECT ELECT ELECT
47uF 1uF 1uF 1000uF 1000uF
20% 20% 20% 20% 20%
25V 50V 50V 25V 25V
C408 C409 C410 C412 C413
1-162-294-31 1-126-962-11 1-164-159-21 1-162-291-31 1-164-159-21
CERAMIC ELECT CERAMIC CERAMIC CERAMIC
0.001uF 3.3uF 0.1uF 560PF 0.1uF
10% 20%
50V 50V 50V 50V 50V
C813 C814 C820 C821 C822
1-101-001-00 1-101-001-00 1-161-494-00 1-161-494-00 1-104-664-11
CERAMIC CERAMIC CERAMIC CERAMIC ELECT
0.001uF 0.001uF 0.022uF 0.022uF 47uF
20%
50V 50V 25V 25V 25V
C415 C416 C434 C435 C451
1-164-159-21 1-164-159-21 1-162-286-21 1-162-286-21 1-162-286-21
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
0.1uF 0.1uF 220PF 220PF 220PF
C823 C950 C951 C952 C953
1-104-664-11 1-126-767-11 1-164-097-11 1-126-960-11 1-124-464-11
ELECT ELECT CERAMIC ELECT ELECT
47uF 1000uF 0.022uF 1uF 0.22uF
20% 20%
10% 10% 10%
50V 50V 50V 50V 50V
C452 C453 C454 C455 C457
1-126-962-11 1-126-966-11 1-162-282-31 1-137-459-11 1-137-365-11
ELECT ELECT CERAMIC FILM FILM
3.3uF 33uF 100PF 0.0056uF 0.0015uF
20% 20% 10% 5% 5%
50V 16V 50V 100V 50V
C954 C955 CC01 CC02 CC03
1-126-096-11 1-164-159-21 1-162-282-31 1-162-282-31 1-162-282-31
ELECT CERAMIC CERAMIC CERAMIC CERAMIC
10uF 0.1uF 100PF 100PF 100PF
20% 10% 10% 10%
35V 50V 50V 50V 50V
C459 C460 C602 C603 C605
1-126-962-11 1-164-159-21 1-162-282-31 1-126-933-11 1-102-233-00
ELECT CERAMIC CERAMIC ELECT CERAMIC
3.3uF 0.1uF 100PF 100uF 33PF
20% 10% 20% 10%
50V 50V 50V 10V 500V
CC04 CC05 CC06 CC07 CC51
1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
100PF 100PF 100PF 100PF 100PF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C610 C611 C620 C652 C653
1-126-967-11 1-137-372-11 1-162-286-21 1-162-282-31 1-126-933-11
ELECT FILM CERAMIC CERAMIC ELECT
47uF 0.022uF 220PF 100PF 100uF
20% 5% 10% 10% 20%
16V 50V 50V 50V 10V
CC52 CC53 CC54 CC55 CC56
1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
100PF 100PF 100PF 100PF 100PF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C655 C660 C661 C670 C702
1-102-233-00 1-126-967-11 1-137-372-11 1-162-286-21 1-162-282-31
CERAMIC ELECT FILM CERAMIC CERAMIC
33PF 47uF 0.022uF 220PF 100PF
10% 20% 5% 10% 10%
500V 16V 50V 50V 50V
CC57
1-162-282-31 CERAMIC
100PF
10%
50V
C703 C705 C710 C711 C720
1-126-933-11 1-102-233-00 1-126-967-11 1-137-372-11 1-162-286-21
ELECT CERAMIC ELECT FILM CERAMIC
100uF 33PF 47uF 0.022uF 220PF
20% 10% 20% 5% 10%
10V 500V 16V 50V 50V
20% 20%
20% 10% 20%
5%
10%
Ref. No.
Remarks
20% 20%
< CONNECTOR > CNP702 CNP706 CNS204 CNS301 CNS701
1-750-388-11 1-764-477-11 1-569-327-11 1-568-442-11 1-568-439-11
PIN, CONNECTOR 5P PIN, CONNECTOR (PC BOARD) 8P SOCKET, CONNECTOR 27P SOCKET, CONNECTOR 9P SOCKET, CONNECTOR 7P
CNS802 1-770-480-11 SOCKET, CONNECTOR PIN 4P
— 27 —
25V 16V 50V 50V 50V
MAIN Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
< DIODE >
Description
Remarks
< TRANSISTOR >
D610 D710 D721 D722 D723
8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85
DIODE DIODE DIODE DIODE DIODE
1S1585 1S1585 1S1585 1S1585 1S1585
Q303 Q304 Q307 Q308 Q601
8-729-922-37 8-729-922-37 8-729-922-37 8-729-922-37 8-729-119-76
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
D724 D725 D801 D802 D804
8-719-815-85 8-719-815-85 8-719-002-33 8-719-302-38 8-719-010-38
DIODE DIODE DIODE DIODE DIODE
1S1585 1S1585 UZL-24L RBV-602-01 UZ-5.1BSB
Q602 Q603 Q604 Q610 Q620
8-729-141-30 8-749-010-25 8-749-010-26 8-729-119-78 8-729-140-82
TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SC403SP-51 TRANSISTOR 2SA988-PAFAEA
D810 D811 D812 D813 D814
8-719-200-82 8-719-200-82 8-719-200-82 8-719-200-82 8-719-815-85
DIODE DIODE DIODE DIODE DIODE
11ES2 11ES2 11ES2 11ES2 1S1585
Q651 Q652 Q653 Q654 Q670
8-729-119-76 8-729-141-30 8-749-010-25 8-749-010-26 8-729-140-82
TRANSISTOR 2SA1175-HFE TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SA988-PAFAEA
D815 D817 D818 D820 D821
8-719-815-85 8-719-001-31 8-719-815-85 8-719-200-82 8-719-200-82
DIODE DIODE DIODE DIODE DIODE
1S1585 UZL-9H3-TA 1S1585 11ES2 11ES2
Q701 Q702 Q703 Q704 Q710
8-729-119-76 8-729-141-30 8-749-010-25 8-749-010-26 8-729-119-78
TRANSISTOR 2SA1175-HFE TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SC403SP-51
D822 D823 D901
8-719-200-82 DIODE 11ES2 8-719-200-82 DIODE 11ES2 8-719-815-85 DIODE 1S1585
Q720 Q721 Q722 Q723 Q751
8-729-140-82 8-729-140-82 8-729-140-84 8-729-119-78 8-729-119-76
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
Q752 Q753 Q754 Q770 Q801
8-729-141-30 8-749-010-25 8-749-010-26 8-729-140-82 8-729-140-97
TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SA988-PAFAEA TRANSISTOR 2SB734-34
Q802 Q808 Q809 Q951
8-729-119-78 8-729-180-92 8-729-119-78 8-729-030-18
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
< TERMINAL > * G200 * G201 * G202
1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH < IC >
IC1 IC300 IC301 IC302 IC401
8-759-450-86 8-759-442-97 8-759-442-96 8-759-636-74 8-759-805-14
IC IC IC IC IC
BU1922 LV1016 LA2786 M5218AP-22 LC7822
IC402 IC701 IC702 IC801 IC802
8-759-636-74 8-759-326-52 8-759-326-52 8-759-231-58 8-759-604-45
IC IC IC IC IC
M5218AP-22 uPC2581V uPC2581V TA7812S M5F79M12
IC950
8-759-333-83 IC NJM2103D
2SD2144S 2SD2144S 2SD2144S 2SD2144S 2SA1175-HFE
2SA988-PAFAEA 2SA988-PAFAEA 2SC1841-PAFAEA 2SC403SP-51 2SA1175-HFE
2SC403SP-51 2SD809-K 2SC403SP-51 2SD2525
< RESISTOR >
< JACK > J401 J402 J403
1-770-614-11 JACK, PIN 4P (PHONO/CD) 1-770-015-11 JACK, PIN 6P (TAPE/MD,TV DBS AUDIO IN) 1-770-614-11 JACK, PIN 4P (VIDEO) < COIL >
L1 L301 L302 L601 L651
1-410-521-11 1-410-509-11 1-410-509-11 1-420-872-00 1-420-872-00
INDUCTOR 100uH INDUCTOR 10uH INDUCTOR 10uH COIL, AIR-CORE COIL, AIR-CORE
L701 L751
1-420-872-00 COIL, AIR-CORE 1-420-872-00 COIL, AIR-CORE
R5 R6 R7 R300 R301
1-249-421-11 1-247-807-31 1-247-807-31 1-247-903-00 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
2.2K 100 100 1M 2.2K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W F
R302 R303 R304 R306 R307
1-249-421-11 1-249-439-11 1-249-441-11 1-249-436-11 1-247-862-11
CARBON CARBON CARBON CARBON CARBON
2.2K 68K 100K 39K 20K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R308 R309 R352 R353 R354
1-249-421-11 1-249-421-11 1-249-441-11 1-249-425-11 1-249-425-11
CARBON CARBON CARBON CARBON CARBON
2.2K 2.2K 100K 4.7K 4.7K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R355 R356 R357 R358 R359
1-249-425-11 1-249-425-11 1-249-441-11 1-249-441-11 1-249-425-11
CARBON CARBON CARBON CARBON CARBON
4.7K 4.7K 100K 100K 4.7K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W F
— 28 —
F F F F
MAIN Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
Description
R360 R361 R362 R363 R401
1-247-843-11 1-249-429-11 1-249-429-11 1-249-411-11 1-249-411-11
CARBON CARBON CARBON CARBON CARBON
3.3K 10K 10K 330 330
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R620 R621 ! R622 R623 R630
1-249-419-11 1-249-426-11 1-249-403-11 1-249-437-11 1-249-426-11
CARBON CARBON CARBON CARBON CARBON
1.5K 5.6K 68 47K 5.6K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/4W
R402 R403 R404 R405 R406
1-249-421-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
2.2K 1K 1K 1K 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R631
1-247-887-00 CARBON
220K
5%
R632 R651 R652 R653
1-249-426-11 1-249-417-11 1-249-439-11 1-249-414-11
CARBON CARBON CARBON CARBON
5.6K 1K 68K 560
5% 5% 5% 5%
1/4W (DE415) 1/4W 1/4W F 1/4W 1/4W F
R407 R408 R409 R410 R411
1-249-417-11 1-249-429-11 1-249-437-11 1-247-897-11 1-249-416-11
CARBON CARBON CARBON CARBON CARBON
1K 10K 47K 560K 820
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W F
R654 R655 R660 R661 R663
1-249-439-11 1-249-441-11 1-249-421-11 1-249-437-11 1-249-414-11
CARBON CARBON CARBON CARBON CARBON
68K 100K 2.2K 47K 560
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W 1/4W F
R412 R413 R414 R415 R416
1-247-897-11 1-249-437-11 1-249-425-11 1-249-417-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
560K 47K 4.7K 1K 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W F
! R664 ! R665 ! R666 ! R667 R668
1-249-409-11 1-249-409-11 1-233-352-41 1-249-393-11 1-249-389-11
CARBON 220 5% CARBON 220 5% ENCAPSULATED COMPONENT CARBON 10 5% CARBON 4.7 5%
1/4W F 1/4W F
R417 R420 R435 R442 R443
1-247-897-11 1-249-441-11 1-249-418-11 1-249-418-11 1-249-418-11
CARBON CARBON CARBON CARBON CARBON
560K 100K 1.2K 1.2K 1.2K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W F
R670 R671 R672 R673 R701
1-249-419-11 1-249-426-11 1-249-431-11 1-249-437-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
1.5K 5.6K 15K 47K 1K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W F
R447 R448 R449 R451 R452
1-249-416-11 1-249-429-11 1-247-863-91 1-249-411-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
820 10K 22K 330 2.2K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W F
R702 R703 R704 R705 R710
1-249-439-11 1-249-414-11 1-249-439-11 1-249-441-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
68K 560 68K 100K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W F
R453 R454 R455 R456 R457
1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
1K 1K 1K 1K 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R711 R713 ! R714 ! R715 ! R716
1-249-437-11 1-249-414-11 1-249-409-11 1-249-409-11 1-233-352-41
CARBON 47K 5% CARBON 560 5% CARBON 220 5% CARBON 220 5% ENCAPSULATED COMPONENT
1/4W 1/4W F 1/4W F 1/4W F
R458 R459 R460 R461 R462
1-249-429-11 1-249-437-11 1-247-897-11 1-249-416-11 1-247-897-11
CARBON CARBON CARBON CARBON CARBON
10K 47K 560K 820 560K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W
! R717 R718 ! R719 R720 R721
1-249-393-11 1-249-389-11 1-249-405-11 1-249-419-11 1-249-426-11
CARBON CARBON CARBON CARBON CARBON
10 4.7 100 1.5K 5.6K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R463 R465 R466 R467 R470
1-249-437-11 1-249-417-11 1-249-417-11 1-247-897-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
47K 1K 1K 560K 100K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W 1/4W
! R722 R723 R724 R725 R726
1-249-403-11 1-249-437-11 1-249-425-11 1-249-429-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
68 47K 4.7K 10K 1K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/4W F
R473 R601 R602 R603 R604
1-249-437-11 1-249-417-11 1-249-439-11 1-249-414-11 1-249-439-11
CARBON CARBON CARBON CARBON CARBON
47K 1K 68K 560 68K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W F 1/4W
R727 R730 R731
1-249-427-11 CARBON 1-249-429-11 CARBON 1-247-887-00 CARBON
6.8K 10K 220K
5% 5% 5%
R734
1-249-429-11 CARBON
10K
5%
R605 R610 R611 R613 ! R614
1-249-441-11 1-249-421-11 1-249-437-11 1-249-414-11 1-249-409-11
CARBON CARBON CARBON CARBON CARBON
100K 2.2K 47K 560 220
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W F 1/4W F
! R740
1-249-393-11 CARBON
10
5%
1/4W F 1/4W 1/4W (DE415) 1/4W (DE415) 1/4W F
! R615 ! R616 ! R617 R618 ! R619
1-249-409-11 1-233-352-41 1-249-393-11 1-249-389-11 1-249-405-11
CARBON 220 5% ENCAPSULATED COMPONENT CARBON 10 5% CARBON 4.7 5% CARBON 100 5%
1/4W F
! R741 R742 R743 R751 R752
1-249-393-11 1-249-425-11 1-249-425-11 1-249-417-11 1-249-439-11
10 4.7K 4.7K 1K 68K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F
F F F F F
CARBON CARBON CARBON CARBON CARBON
Remarks
1/4W F 1/4W F
1/4W F 1/4W F 1/4W F
— 29 —
T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.
F F F F
F F F F
MAIN Ref. No.
MIX
PRIMARY
SECONDARY
STBY
Part No.
Description
Remarks
Ref. No.
Part No.
R753 R754 R755 R760 R761
1-249-414-11 1-249-439-11 1-249-441-11 1-249-421-11 1-249-437-11
CARBON CARBON CARBON CARBON CARBON
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W F 1/4W
*
1-666-496-11 MIX BOARD (DE415) **********
R763 ! R764 ! R765 ! R766 ! R767
1-249-414-11 1-249-409-11 1-249-409-11 1-233-352-41 1-249-393-11
CARBON 560 5% CARBON 220 5% CARBON 220 5% ENCAPSULATED COMPONENT CARBON 10 5%
1/4W F 1/4W F 1/4W F
R768 R770 R771 R772 R773
1-249-389-11 1-249-419-11 1-249-426-11 1-249-431-11 1-249-437-11
CARBON CARBON CARBON CARBON CARBON
4.7 1.5K 5.6K 15K 47K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W
R781
1-247-887-00 CARBON
220K
5%
! R803 R804 R821 R822
1-249-389-11 1-249-421-11 1-249-437-11 1-249-425-11
CARBON CARBON CARBON CARBON
4.7 2.2K 47K 4.7K
5% 5% 5% 5%
1/4W (DE415) 1/4W F 1/4W F 1/4W 1/4W F
R823 R824 R825 ! R830 ! R831
1-249-437-11 1-249-425-11 1-249-407-11 1-249-405-11 1-249-403-11
CARBON CARBON CARBON CARBON CARBON
47K 4.7K 150 100 68
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R950 R951 R952 R953 R954
1-249-421-11 1-249-429-11 1-247-843-11 1-247-863-91 1-249-439-11
CARBON CARBON CARBON CARBON CARBON
2.2K 10K 3.3K 22K 68K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R955 R956 R957 R958 R960
1-249-429-11 1-247-843-11 1-249-417-11 1-249-401-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
10K 3.3K 1K 47 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W
560 68K 100K 2.2K 47K
Description
Remarks
< CONNECTOR > CNS253 1-691-765-11 PLUG (MICRO CONNECTOR) 3P (DE415)
1/4W F
< JACK > J253 1-774-843-11 JACK, PIN 1P (MIX)(DE415) ************************************************************ *
1-665-273-11 PRIMARY BOARD ************** 1-533-233-21 HOLDER, FUSE < FUSE >
*
1-665-274-11 SECONDARY BOARD ***************** < CONNECTOR >
F F F F
CNP801 1-764-480-11 PIN, CONNECTOR (PC BOARD) 11P < RESISTOR > ! R810 1-249-381-11 CARBON 1 5% 1/4W F ! R811 1-249-381-11 CARBON 1 5% 1/4W F ************************************************************ *
1-665-272-11 STBY BOARD *********** 1-533-233-11 HOLDER, FUSE < CONNECTOR > CNP802 1-779-495-11 PLUG, CONNECTOR PIN 4P CNP901 1-564-321-00 PIN, CONNECTOR 2P CNP903 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P (AEP,G,EE)
< RELAY > RY601 RY701 RY801
! F901 1-532-259-00 FUSE TIME LAG 1.6A ************************************************************
1-515-921-11 RELAY (12V) 1-515-921-11 RELAY (12V) 1-755-013-11 RELAY
< DIODE > D816
8-719-815-85 DIODE 1S1585
< TERMINAL > < FUSE > TM1 TM601 TM701
1-694-266-11 TERMINAL BOARD, ANT (ANTENNA) 1-537-510-11 TERMINAL BOARD (SPEAKER) (6P) (SURROUND SPEAKER) 1-537-376-11 TERMINAL BOARD (SPEAKER) (FRONT SPEAKER)
1-532-286-00 FUSE TIME LAG 2.5A (AEP,G,EE) < RELAY >
! RY901
< TUNER > TU001 TU001
! F902
1-233-594-12 ENCAPSULATED COMPONENT (AEP,UK,G) 1-233-595-11 ENCAPSULATED COMPONENT (EE)
1-515-720-11 RELAY < TRANSFORMER >
! T902 1-450-358-11 TRANSFORMER, POWER ************************************************************
< VIBRATOR > X1 1-579-900-21 VIBRATOR, CRYSTAL 4.33MHz X301 1-579-952-21 VIBRATOR, CERAMIC 8MHz ************************************************************
— 30 —
T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.
SW Ref. No.
Part No.
*
A-4392-965-A SW BOARD, COMPLETE ******************* SW (A) BOARD ************ SW (B) BOARD ************
Description
SW (A)
Remarks
Ref. No.
SW (B) Part No.
VOLUME
VR-TONE
Description
Remarks
< CONNECTOR > CNP202 1-770-391-11 PIN, CONNECTOR (PC BOARD) 7P CNS402 1-568-439-11 SOCKET, CONNECTOR 7P CNS403 1-568-442-11 SOCKET, CONNECTOR 9P < DIODE >
< CONNECTOR > CNP703 CNP704 CNS205 CNS702
1-764-474-11 1-764-473-11 1-770-397-11 1-770-378-11
D238 D421
PIN, CONNECTOR (PC BOARD) 5P PIN, CONNECTOR (PC BOARD) 3P HOUSING, CONNECTOR(PC BOARD)4P CONNECTOR, BOARD TO BOARD 5P
8-719-313-50 DIODE SEL6810A-TH12 (BASS BOOST) 8-719-815-85 DIODE 1S1585 < IC >
IC404
8-759-636-74 IC M5218AP-22
< JACK > < TRANSISTOR > J741
1-750-733-11 JACK (LARGE TYPE) (PHONES) < RESISTOR >
R741 R742 R791 R792
1-260-100-11 1-260-100-11 1-260-100-11 1-260-100-11
CARBON CARBON CARBON CARBON
1.2K 1.2K 1.2K 1.2K
5% 5% 5% 5%
1/2W 1/2W 1/2W 1/2W
< SWITCH > S701 1-762-319-11 SWITCH, PUSH (2 KEY) (SPEAKERS) ************************************************************ *
A-4392-964-A VR-TONE BOARD, COMPLETE ************************ VOLUME BOARD **************
Q401 Q402 Q451 Q452
8-729-202-67 8-729-141-30 8-729-202-67 8-729-141-30
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SK246-GR3 2SC3623A-LK 2SK246-GR3 2SC3623A-LK
< RESISTOR > R420 R421 R422 R423 R424
1-249-415-11 1-249-430-11 1-249-422-11 1-247-903-00 1-247-903-00
CARBON CARBON CARBON CARBON CARBON
680 12K 2.7K 1M 1M
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/4W
R425 R426 R427 R430 R431
1-249-429-11 1-249-439-11 1-249-417-11 1-249-437-11 1-247-843-11
CARBON CARBON CARBON CARBON CARBON
10K 68K 1K 47K 3.3K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W 1/4W
R432 R433 R434 R438 R441
1-247-883-00 1-249-427-11 1-249-413-11 1-249-441-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
150K 6.8K 470 100K 100K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W 1/4W
R444 R464 R469 R470 R471
1-247-903-00 1-247-903-00 1-247-903-00 1-249-415-11 1-249-430-11
CARBON CARBON CARBON CARBON CARBON
1M 1M 1M 680 12K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W
R472 R473 R474 R475 R476
1-249-422-11 1-247-903-00 1-247-903-00 1-249-429-11 1-249-439-11
CARBON CARBON CARBON CARBON CARBON
2.7K 1M 1M 10K 68K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R477 R480 R481 R482 R483
1-249-417-11 1-249-437-11 1-247-843-11 1-247-883-00 1-249-427-11
CARBON CARBON CARBON CARBON CARBON
1K 47K 3.3K 150K 6.8K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W F
R484 R491 R492 R494
1-249-413-11 1-249-441-11 1-247-903-00 1-247-903-00
CARBON CARBON CARBON CARBON
470 100K 1M 1M
5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W
< CAPACITOR > C420 C421 C422 C423 C424
1-162-207-31 1-137-440-11 1-124-463-00 1-137-368-11 1-137-372-11
CERAMIC FILM ELECT FILM FILM
22PF 0.018uF 0.1uF 0.0047uF 0.022uF
5% 5% 20% 5% 5%
50V 50V 50V 50V 50V
C425 C426 C427 C428 C429
1-126-096-11 1-126-096-11 1-124-252-00 1-130-489-00 1-102-973-00
ELECT ELECT ELECT MYLAR CERAMIC
10uF 10uF 0.33uF 0.033uF 100PF
20% 20% 20% 5% 5%
35V 35V 50V 50V 50V
C430 C431 C432 C433 C470
1-126-301-11 1-126-301-11 1-126-096-11 1-126-096-11 1-162-207-31
ELECT ELECT ELECT ELECT CERAMIC
1uF 1uF 10uF 10uF 22PF
20% 20% 20% 20% 5%
50V 50V 35V 35V 50V
C471 C472 C473 C474 C475
1-137-440-11 1-124-463-00 1-137-368-11 1-137-372-11 1-126-096-11
FILM ELECT FILM FILM ELECT
0.018uF 0.1uF 0.0047uF 0.022uF 10uF
5% 20% 5% 5% 20%
50V 50V 50V 50V 35V
C476 C477 C478 C479 C492
1-126-096-11 1-124-252-00 1-130-489-00 1-102-973-00 1-124-464-11
ELECT ELECT MYLAR CERAMIC ELECT
10uF 0.33uF 0.033uF 100PF 0.22uF
20% 20% 5% 5% 20%
35V 50V 50V 50V 50V
C601 C651 C701 C751
1-126-163-11 1-126-163-11 1-126-163-11 1-126-163-11
ELECT ELECT ELECT ELECT
4.7uF 4.7uF 4.7uF 4.7uF
20% 20% 20% 20%
50V 50V 50V 50V
< VARIABLE RESISTOR > RV404 RV421 RV422 RV423
— 31 —
1-225-229-11 RES, VAR, CARBON 100KX4 (MASTER VOLUME) 1-223-362-11 RES, VAR, CARBON 100K/100K (BASS) 1-223-363-11 RES, VAR, CARBON 125K/125K (TREBLE) 1-225-447-11 RES, VAR, CARBON 100K/100K (BALANCE)
STR-DE315/DE415 VOLUME Ref. No.
VR-TONE
Part No.
Description
Remarks
Ref. No.
Part No.
< SWITCH >
1-475-042-11 1-475-136-21 1-475-137-11 1-501-374-11 1-501-594-11
MISCELLANEOUS ************** 1-769-908-11 1-765-314-11 1-773-252-11 1-751-520-11 1-769-744-11
Remarks
ACCESSORIES & PACKING MATERIALS *******************************
S240 1-554-937-11 SWITCH, KEY BOARD (BASS BOOST) ************************************************************
11 12 61 ! 71 ! 71
Description
WIRE (FLAT TYPE) (9 CORE) WIRE (FLAT TYPE) (7 CORE) WIRE (FLAT TYPE) (27 CORE) CORD, POWER (UK) CORD, POWER (AEP,G,EE)
! CNJ903 1-526-794-11 OUTLET, AC (AEP,G,EE) ! T901 1-431-260-11 TRANSFORMER, POWER (DE315) ! T901 1-431-266-11 TRANSFORMER, POWER (DE415) ************************************************************
ADAPTOR (21PIN D. SUB) REMOTE COMMANDER (RM-U301) (DE315) REMOTE COMMANDER (RM-P301) (DE415) ANTENNA, LOOP ANTENNA (FM)
3-859-657-11 MANUAL, INSTRUCTION (ENGLISH/FRENCH/GERMAN/DUTCH/ITALIAN)(AEP,UK,G) 3-859-657-41 MANUAL, INSTRUCTION (SPANISH/SWEDISH/FRENCH/DANISH/PORTUGUESE)(AEP) 3-859-657-51 MANUAL, INSTRUCTION (ENGLISH/RUSSIAN/POLISH)(EE) 4-981-643-01 COVER, BATTERY (for RM-P301/U301) ************************************************************ ************** HARDWARE LIST ************** #1 #2 #3 #4
7-685-646-79 7-685-881-09 7-685-872-09 7-658-646-71
SCREW +BVTP 3X8 TYPE2 IT-3 SCREW +BVTT 4X8 (S) SCREW +BVTT 3X8 (S) SCREW +BTP 3X8
T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.
Sony Corporation 9-920-941-11
Home A&V Products Company
— 32 —
97H 167554-1 P rinted in H ungary © 1997.8 Published by General Engineering Dept. (Shibaura)
