HCD-RG333/RG441 SERVICE MANUAL
AEP Model UK Model
Ver 1.0 2004. 04
HCD-RG333
E Model HCD-RG441
• HCD-RG333/RG441 is the tuner, deck, CD and amplifier section in MHC-RG333/RG441.
(Photo: HCD-RG333)
CD Section
Model Name Using Similar Mechanism
NEW
CD Mechanism Type
CDM74-F1BD81
Optical Pick-up Name
KSM-215DCP/C2NP
Tape Deck Model Name Using Similar Machanism
NEW
Section
CWM43FF-25
Tape Transport Mechanism Type
SPECIFICATIONS Amplifier section European and Russian models: HCD-RG333: DIN power output (rated): 100 + 100 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 125 + 125 watts (6 ohms at 1 kHz, 10% THD) Music power output (reference): 250 + 250 watts (6 ohms at 1 kHz, 10% THD) Other models: HCD-RG441: The following measured at AC 120, 127, 220, 240 V, 50/60 Hz DIN power output (rated): 120 + 120 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 150 + 150 watts (6 ohms at 1 kHz, 10% THD)
Inputs GAME INPUT AUDIO L/R (phono jacks): voltage 250 mV, impedance 47 kilohms GAME INPUT VIDEO (phono jack): 1 Vp-p, 75 ohms Outputs PHONES (stereo mini jack): accepts headphones of 8 ohms or more VIDEO OUT (phono jack): max. output level 1 Vp-p, unbalanced, Sync negative, load impedance 75 ohms SPEAKER: accepts impedance of 6 to 16 ohms
– Continued on next page –
MINI HI-FI COMPONENT SYSTEM 9-877-772-01
Sony Corporation
2004D04-1 © 2004. 04
Home Audio Company Published by Sony Engineering Corporation
1
HCD-RG333/RG441
CD player section System Laser
Frequency response Signal-to-noise ratio Dynamic range
General Compact disc and digital audio system Semiconductor laser (λ=770 – 810 nm) Emission duration: continuous 2 Hz – 20 kHz (±0.5 dB) More than 90 dB More than 90 dB
Tape deck section Recording system Frequency response
4-track 2-channel, stereo 50 – 13,000 Hz (±3 dB), using Sony TYPE I cassettes
Tuner section FM stereo, FM/AM superheterodyne tuner
FM tuner section Tuning range Antenna Antenna terminals Intermediate frequency
87.5 – 108.0 MHz (50 kHz step) FM lead antenna 75 ohms unbalanced 10.7 MHz
AM tuner section Tuning range European models: Other models:
Antenna Antenna terminals Intermediate frequency
2
531 – 1,602 kHz (with the tuning interval set at 9 kHz) 530 – 1,710 kHz (with the tuning interval set at 10 kHz) 531 – 1,602 kHz (with the tuning interval set at 9 kHz) AM loop antenna External antenna terminal 450 kHz
Power requirements European models: Argentine model: Mexican model: Other models:
Power consumption European models: HCD-RG333:
Other models: HCD-RG441:
230 V AC, 50/60 Hz 220 V AC, 50/60 Hz 127 V AC, 60 Hz 120 V, 220 V or 230 – 240 V AC, 50/60 Hz Adjustable with voltage selector
180 watts 0.25 watts (at the Power Saving Mode) 155 watts
Dimensions (w/h/d) incl. projecting parts and controls Amplifier/Tuner/Tape/CD section: Approx. 280 × 327 × 425 mm Mass European models: HCD-RG333: Other models: HCD-RG441:
Approx. 10.0 kg Approx. 10.0 kg
Design and specifications are subject to change without notice.
HCD-RG333/RG441
SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)
To Exposed Metal Parts on Set
0.15 µF
1.5 kΩ
AC Voltmeter (0.75 V)
Earth Ground Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
3
HCD-RG333/RG441
The release method of a CD disc tray LOCK function There is a disc lock function for the disc theft prevention for a demonstration at a shop front in this machine. Procedue: 1. Press the ?/1 button to turn the set on. 2. Press two buttons of x and Z (EJECT) simultaneously for five seconds. 3. The message “LOCKED” is displayed and the tray is locked. (Even if exiting from this mode, the tray is still locked.) 4. Press two buttons of x and Z (EJECT) simultaneously for five seconds again. 5. The message “UNLOCKED” is displayed and the tray is unlocked. 6. To exit from this mode, press the ?/1 button to turn the set off. Unleaded solder Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.) : LEAD FREE MARK Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40°C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350°C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Laser component in this product is capable of emitting radiation exceeding the limit for Class 1.
CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. Notes on Chip Component Replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of soldering iron around 270°C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering.
4
HCD-RG333/RG441
TABLE OF CONTENTS 1. SERVICING NOTE 1-1. Service Position-1 (AMP Board) ........................................ 6 1-2. Service Position-2 (BD81A Board) .................................... 6
2. GENERAL Main Unit ................................................................................ 7 Remote Control ....................................................................... 8
3. DISASSEMBLY 3-1. Case (Top) ......................................................................... 10 3-2. CD Door ............................................................................ 10 3-3. Front Panel Section ........................................................... 11 3-4. CD Mechanism Deck ........................................................ 11 3-5. Tape Mechanism Deck, Game Jack Board ........................ 12 3-6. Panel Board ....................................................................... 12 3-7. Back Panel Section, Sub Trans Board ............................... 13 3-8. Trans Board ....................................................................... 13 3-9. Main Board ....................................................................... 14 3-10. Amp Board ........................................................................ 14 3-11. BD81A Board ................................................................... 15 3-12. Connect Board ................................................................... 15 3-13. Driver Board, SW Board ................................................... 16 3-14. Optical Pick-up ................................................................. 16 3-15. Sensor Board ..................................................................... 17 3-16. Motor (TB) Board ............................................................. 17 3-17. Motor (LD) Board ............................................................. 18
4. TEST MODE ..................................................................... 19 5. DIAGRAMS 5-1. 5-2. 5-3. 5-4.
IC Pin Descriptions ........................................................... 22 Block Diagram –CD Section– ........................................... 27 Block Diagram –Main Section– ........................................ 28 Block Diagram –Panel/Power Section– ............................ 29
5-5. Circuit Boards Location .................................................... 30 5-6. Note for Printed Wiring Boards and Schematic Diagrams .................................................. 31 5-7. Waveforms ......................................................................... 31 5-8. Printed Wiring Board –CD Mechanism Section (1/2)– .... 32 5-9. Schematic Diagram –CD Mechanism Section (1/2)– ....... 33 5-10. Printed Wiring Boards –CD Mechanism Section (2/2)– ... 34 5-11. Schematic Diagram –CD Mechanism Section (2/2)– ....... 35 5-12. Schematic Diagram –Main Section (1/2)– ........................ 36 5-13. Schematic Diagram –Main Section (2/2)– ........................ 37 5-14. Printed Wiring Board –Main Section– .............................. 38 5-15. Printed Wiring Boards –Panel Section– ............................ 39 5-16. Schematic Diagram –Panel Section (1/2)– ....................... 40 5-17. Schematic Diagram –Panel Section (2/2)– ....................... 41 5-18. Printed Wiring Boards –Jack Section– .............................. 42 5-19. Schematic Diagram –Jack Section– .................................. 43 5-20. Printed Wiring Board –Power Amp Section (RG333)– .... 44 5-21. Printed Wiring Boards –Transformer Section (RG333)– .. 45 5-22. Schematic Diagram –Power Section (RG333)– ................ 46 5-23. Printed Wiring Board –Power Amp Section (RG441)– .... 47 5-24. Printed Wiring Boards –Transformer Section (RG441)– .. 48 5-25. Schematic Diagram –Power Section (RG441)– ................ 49 5-26. IC Block Diagrams ............................................................ 50
6. EXPLODED VIEWS 6-1. 6-2. 6-3. 6-4. 6-5. 6-6. 6-7.
Main Section ..................................................................... 52 Front Panel Section (1) ...................................................... 53 Front Panel Section (2) ...................................................... 54 Front Panel Section (3) ...................................................... 55 Main Board Section .......................................................... 56 CD Mechanism Section (1) ............................................... 57 CD Mechanism Section (2) ............................................... 58
7. ELECTRICAL PARTS LIST ........................................ 59
5
HCD-RG333/RG441 SECTION 1 SERVICING NOTE 1-1. SERVICE POSITION-1 (AMP BOARD) To inspect the AMP board, turn both of the front panel and the CD mechanism deck so that the left side of the product faces down. CD mechanism deck front panel
AMP board
1-2. SERVICE POSITION-2 (BD81A BOARD) Remove the CD mechanism deck and place it on top of the pedestal as shown. Inspect the BD81A bard in this set up.
BD81A board CD mechanism deck
6
HCD-RG333/RG441 SECTION 2 GENERAL
This section is extracted from instruction manual.
7
HCD-RG333/RG441
8
HCD-RG333/RG441 SECTION 3 DISASSEMBLY Note : Disassemble the unit in the order as shown below.
SET 3-1.
CASE (TOP) (Page 10)
3-2.
CD DOOR (Page 10)
3-3.
FRONT PANEL SECTION (Page 11)
3-4.
CD MECHANISM DECK (Page 11)
3-5.
TAPE MECHANISM DECK, GAME JACK BOARD (Page 12)
3-6.
PANEL BOARD (Page 12)
3-11. BD81A BOARD (Page 15)
3-12. CONNECT BOARD (Page 15)
3-15. SENSOR BOARD (Page 17)
3-14. OPTICAL PICK-UP (Page 16)
3-13. DRIVER BOARD, SW BOARD (Page 16)
3-16. MOTOR (TB) BOARD (Page 17)
3-7.
BACK PANEL SECTION, SUB TRANS BOARD (Page 13)
3-8.
TRANS BOARD (Page 13)
3-17. MOTOR (LD) BOARD (Page 18)
3-9.
MAIN BOARD (Page 14)
3-10. AMP BOARD (Page 14)
9
HCD-RG333/RG441 Note : Follow the disassembly procedure in the numerical order given.
3-1. CASE (TOP)
qf
qd two screws (+BVTP 3 × 10)
qh case (top) 7 two screws (case 3 TP2) qs case (side-L) qg 9 screw (+BVTP 3 × 10)
qf
qa
6 case (side-R) 5 0 screw (+BVTP 3 × 10)
3 screw (+BVTP 3 × 10)
8 screw (case 3 TP2)
1 two screws (case 3 TP2) 4 screw (+BVTP 3 × 10) 2 screw (case 3 TP2)
3-2. CD DOOR 3 two claws
4 CD door
CD mechanism deck (CDM74) 1 Turn the pulley to the direction of the arrow.
Front panel side pulley
2 Pull-out the disc tray.
10
HCD-RG333/RG441
3-3. FRONT PANEL SECTION
4 screw (+BVTP 3 × 8) qa CN304 1 CN805 3 CN873 8 screw (+BVTP 3 × 10)
5 screw (+BVTP 3 × 8)
qs CN112 7 screw (+BVTP 3 × 10)
0 CN309
qd CN103
9 2 CN302 qf front panel section 6 three screws (+BVTP 3 × 8)
3-4. CD MECHANISM DECK 1 three screws (+BVTP 3 × 10)
4 CD mechanism deck
MAIN board
2 CN701 3 CN874
MAIN board
11
HCD-RG333/RG441
3-5. TAPE MECHANISM DECK, GAME JACK BOARD
4 LEAD board 3 tape mechanism deck
2 six screws (+BVTP 2.6 × 8)
1 connector
6 GAME JACK board
5 two screws (+BVTP 2.6 × 8)
3-6. PANEL BOARD
4 seven claws
2 eight screws (+BVTP 2.6 × 8)
6 CN604
5 CN605
3 two screws (+BVTP 2.6 × 8)
7 PANEL board
1 connector
12
HCD-RG333/RG441
3-7. BACK PANEL SECTION, SUB TRANS BOARD
0 SUB TRANS board
qa back panel section
3 CN901 9 two screws (+BVTP 3 × 10) 2 CN906
7 two screws (+BVTP 3 × 10)
1 CN904 8
6 two screws (+BVTP 3 × 10)
5 CN308
4 CN101
3-8. TRANS BOARD
5 four screws (+ITC 4 × 8)
6 TRANS board
3 screw (+BVIT 3 × 8R)
1 CN905 2 CN907
4 earth wire
13
HCD-RG333/RG441
3-9. MAIN BOARD
4 MAIN board 1 CN907
MAIN board
3 CN441
2 two screws (+BVTP 3 × 8)
3-10. AMP BOARD
4 two screws (+BVIT 3 × 8R)
2 two screws (+BVTT 4 × 8)
3 screw (+BVTP 3 × 14)
7 heat sink
5 two screws (transistor)
6 8 AMP board
1 CN905
14
HCD-RG333/RG441
3-11. BD81A BOARD
3 screw (+BVTP 2.6 × 8)
1 CN202
4 gap tube
6 BD81A board
5 Remove soldering from the four points.
2 CN101
3-12. CONNECT BOARD
2 two screws (+BVTP 2.6 × 8)
1 CN871
3 CONNECT board
15
HCD-RG333/RG441
3-13. DRIVER BOARD, SW BOARD
1 two screws (+BTTP (M2.6)) 3 CN703 4 DRIVER board
5 screw (+BTTP (M2.6)) 6 SW board
2 CN702
3-14. OPTICAL PICK-UP
1 floating screw (+PTPWH M2.6) 2 holder (213) ASSY qd optical pick-up (KSM-215DCP/C2NP)
qs
7 two insulators 6 two coil springs (insulator)
qa two insulators 0 two coil springs (insulator) 9 two stoppers (BU) 8 two screws (BVTT M2.6)
16
5 stopper (BU) 4 screw (BVTT M2.6) 3 floating screw (+PTPWH M2.6)
HCD-RG333/RG441
3-15. SENSOR BOARD
1 floating screw (+PTPWH M2.6) 2 tray
8 screw (+BTTP (M2.6)) 3 belt (table) 0 SENSOR board 4 floating screw (+PTPWH M2.6) 5 pulley (table)
9 CN731
6 floating screw (+PTPWH M2.6) 7 gear (geneva)
3-16. MOTOR (TB) BOARD
2 stopper
4
1 stopper 7 table motor assy (M741)
3 CN742 8 MOTOR (TB) board 6 Remove the two solderings of motor. 5 two screws (+BTTP (M2.6))
17
HCD-RG333/RG441
3-17. MOTOR (LD) BOARD
2 two screws (+BTTP (M2.6)) 4 Remove the two solderings of motor. 3 MOTOR (LD) board
5 loading motor assy (M751)
1 belt (loading)
18
HCD-RG333/RG441 SECTION 4 TEST MODE [Change-over of AM Tuner Step between 9 kHz and 10 kHz] • A step of AM channels can be changed over between 9 kHz and 10 kHz. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select the function “TUNER”, and press TUNER/BAND button to select the BAND “AM”. 3. Press ?/1 button to turn the set OFF. 4. Press TUNER/BAND and ?/1 buttons simultaneously, and the display of fluorescent indicator tube changes to “AM 9 k STEP” or “AM 10 k STEP”, and thus the channel step is changed over. [Cold Reset] • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Press three buttons x , PLAY MODE/TUNING MODE , and DISC 1 simultaneously. 2. The fluorescent indicator tube displays “COLD RESET” and the set is reset. [Aging Mode] This mode can be used for operation check of CD section and tape deck section. • If an error occurred: The aging operation stops and is displayed status. • If no error occurs: The aging operation continues repeatedly. 1. Operating method of Aging Mode Turn on the main power and select “CD” of the function. 1) Set three discs in tray. Select ALL DISCS, and REPEAT OFF. 2) Load the tapes recording use into both decks. 3) Press three buttons x , PLAY MODE/TUNING MODE , and EX-CHANGE simultaneously. 4) Aging operations of CD and tape are started at the same time. 5) To exit the aging mode, perform [Cold Reset]. 2. Aging mode in CD section 1) Operation during aging mode • In the agining mode, the program is excuted in the following sequence. (1) The disc tray opens and closes. (2) The disc tray turns to select a disc 3. (3) The pick-up accesses to the first track, and plays 3 seconds. (4) The pick-up accesses to the last track, and plays 3 seconds. (5) The disc tray opens and closes. (6) The disc tray turns to select a disc 1. (7) The same operation starts like step (3). (8) After a disc 1 aging operation, a disc 2 is selected. (9) When an aging operation of a disc 3 is completed, the display “AGING ∗∗∗∗” value increases. (10) If no error occurs, the aging operation continues repeatedly.
2) Error display Disc error Display E00D01022
Error Focus error (No disc)
E00D02022
Sub Q error (Focus is good)
E00D02023
TOC reading error
E00D02014
Access error (Unable within regular time) Mechanism error
Display E00M__E_0
Error Error during opening tray
E00M__C_2
EX-CHANGE disc error
E00M__D_0
Error during closing tray
E00M__F_3
EX-OPEN error
E00M__D_5
EX-CLOSE error
E00M__C_2
Chuck-up error
E00M__C_3
Unchucking error
3. Aging mode in Tape Deck section 1) Operation during aging mode • In the agining mode, the program is excuted in the following sequence. Step
Operation
Display
1
Rewind the TAPE A
TAPE
AAG-1
2
Rewind the TAPE B
TAPE
BAG-2
3
Play the TAPE A (1 minute)
TAPE
AAG-2
4
Stop the TAPE A (1 second)
TAPE
AAG-3
5
Play the TAPE A (3 minutes)
TAPE
AAG-4
6
Rewind(AMS) the TAPE A
TAPE
AAG-5
7
F.F.(AMS) the TAPE A
TAPE
AAG-6
8
Play the TAPE B (1 minute)
TAPE
BAG-2
9
Stop the TAPE B (1 second)
TAPE
BAG-3
10
Record the TAPE B (3 minutes)
TAPE
BAG-4
11
Rewind(AMS) the TAPE B
TAPE
BAG-5
12
F.F.(AMS) the TAPE B
TAPE
BAG-6
2) Error display • If error occurred, the display remains like “TAPE BAG-2”. 4. Exiting from the aging mode • Be sure to perform Cold Reset to exit from the aging mode.
19
HCD-RG333/RG441
[PANEL Test Mode] • All fluorecent segments and LEDs are tested. • Keyboard check. Procedure: 1. Press ?/1 button to turn the set ON. 2. To enter the test mode, press the three buttons x , PLAY MODE/TUNING MODE and ENTER simultaneously. 3. All segments and LEDs (without STANDBY LED) are turned on. 4. Press X and ENTER buttons simultaneously, and the key check mode is activated. 5. The message “KEY 0 0 0 ” is displayed. Each time a button is pressed, the key code number is displayed. 6. Press X and ENTER buttons simultaneously, and the key count mode is activated. 7. The message “KEYCNT 0” is displayed. Each time a button is pressed, “KEYCNT 0” value increased. However, once a button is pressed, it is no longer taken into account. 8. Press X and ENTER buttons simultaneously, and the head phone detect mode is activated. 9. The message “H_P OFF” is displayed when a headphone jack is not inserted. “H_P ON ” is displayed when a headphone jack is inserted. 10. Press X and ENTER buttons simultaneously, and the volume control detect mode is activated. 11. The message “VOLUME FLAT” is displayed. “VOLUME UP” is displayed if rotating MASTER VOLUME knob clockwise, or “VOLUME DOWN” is displayed if rotating counterclockwise. 12. To exit from the GC test mode after the head phone detect mode, press X and ENTER buttons simultaneously. [Version and Destination Display Mode] • The version or destination is displayed. Procedure: 1. Press ?/1 button to turn the set ON. 2. To enter the test mode, press the three buttons x , PLAY MODE/TUNING MODE and DISC 2 simultaneously. 3. The destination is displayed. 4. Press DISPLAY buttons simultaneously. 5. The version is displayed. 6. To exit from this mode, press ?/1 button to turn the set OFF. [CD Service Mode] • This mode can run the CD sled motor freely. Use this mode, for instance, when cleaning the pick-up. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select the function “CD”. 3. To enter the test mode, press three buttons x , PLAY MODE/ TUNING MODE , and Z simultaneously. 4. The CD service mode is selected. 5. With the CD in stop status, press M button to move the pick-up to outside track, or press m button to inside track. 6. To exit from this mode, perform as follows: 1) Move the pick-up to the most inside track. 2) Press ?/1 button to turn the set OFF. Note: • Always move the pick-up to most inside track when exiting from this mode. Otherwise, a disc will not be unloaded. • Do not run the sled motor excessively, otherwise the gear can be chipped.
20
[MC Test Mode] • This mode is used to test the function of the equalizer. Procedure: 1. Press ?/1 button to turn the set ON. 2. To enter the test mode, press the three buttons x , PLAY MODE/TUNING MODE and DISC 3 simultaneously. 3. Press the EQ + button. The function of the equalizer is set to “MIN”. 4. Press the EQ – button. The function of the equalizer is set to “MAX”. 5. Press the PRESET EQ button. The function of the equalizer is set to “EQ FLAT”. 6. MASTER VOLUME up and down. “VOLUME MIN” “VOLUME 16” “VOLUME MAX” is displayed. 7. Press the GROOVE button. The message “VACS OFF” or “VACS ON” is displayed. 8. To exit from this mode, press ?/1 button to turn the set OFF. [CD Ship Mode (LOCK) ] • This mode moves the pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press ?/1 button to turn the set ON. 2. Select the function “CD”. 3. Press ?/1 button to turn the set OFF. 4. Press CD button and ?/1 button simultaneously. 5. The “STANDBY” display blinks instantaneously, and the CD ship mode is set. [CD Ship (LOCK) & COLD RESET MODE] Procedure: 1. Press ?/1 button to turn the set ON. 2. Select the function “CD”. 3. Press ?/1 button to turn the set OFF. 4. Press three buttons x , CD and DISPLAY simultaneously. 5. The “STANDBY” display blinks instantaneously and CD ship mode is set. 6. To fluorescent indicator tube displays “COLD RESET” and the set is reset. [Disc Tray Lock] Procedure: 1. Press the ?/1 button to turn the set ON. 2. Press two buttons of x and Z simultaneously for five seconds. 3. The message “LOCKED” is displayed and the tray is locked. (Even if exiting from this mode, the tray is still locked.) 4. Press two buttons of x and Z simultaneously for five seconds again. 5. The message “UNLOCKED” is displayed and the tray is unlocked. 6. To exit from this mode, press the ?/1 button to turn the set OFF.
HCD-RG333/RG441
[CD Repeat 5 Times Limit Release Mode] Procedure: 1. Press ?/1 button to turn the set ON. 2. Select the function “CD”. 3. Press three buttons x , CD and ENTER simultaneously. 4. The message “LIMIT OFF” is displayed. 5. Press ?/1 button the set OFF. [AMP TEST MODE] Procedure: 1. Press ?/1 button to turn the set ON. 2. To enter the test mode, press three buttons x , PLAY MODE/TUNING MODE and ENTER simultaneously. 3. Press the DISPLAY button. The message “V0 0 0” “ 000” is displayed. 4. Press the GROOVE button. The message “DBFB ON” “DBFB OFF” is displayed. 5. Press the SURROUND button. The message “SURROUND ON” “SURROUND OFF” is displayed. 6. Press the EQ BAND button. The message “LOW” “MID” “HIGH” is displayed. 7. Press ?/1 button to turn the set OFF.
21
HCD-RG333/RG441 SECTION 5 DIAGRAMS 5-1. IC PIN DESCRIPTIONS • IC101 CXD3059AR (RF AMP) (BD81A BOARD) Pin No. Pin Name I/O 1 MIRR I/O Mirror signal input/output
22
Pin Description Not used in this set. (Open)
2 3
DFCT FOK
I/O I/O
Defect signal input/output Not used in this set. (Open) Focus OK signal input/output Not used in this set. (Open)
4
VSS
—
5
LOCK
I/O
Internal digital ground pin GFS is sampled at 460Hz; when GFS is high , this pin outputs a high signal
6
MDP
O
If GFS is low eight consecutive Not used in this set. (Open) Spindle motor servo control signal output
7 8
SSTP IOVSS1
I —
Disc innermost detection signal input I/O digital ground pin
9 10
SFDR SRDR
O O
Sled drive signal output Sled drive signal output
11 12
TFDR TRDR
O O
Tracking drive signal output Tracking drive signal output
13 14
FFDR FRDR
O O
Focus drive signal output Focus drive signal output
15 16
IOVDD1 AVDD0
— —
I/O digital power supply pin (+3.3 V) Analog power supply pin (+3.3 V)
17 18
AVSS0 NC
— —
Analog ground pin Not used. (Open)
19 20
E F
I I
E signal input F signal input
21 22 23
TEI TEO FEI
I O I
Tracking error signal input Tracking error signal output Focus error signal input
24 25
FEO VC
O O
Focus error signal output Center voltage output
26 27
A B
I I
A signal input B signal input
28 29
C D
I I
C signal input D signal input
30 31
NC AVDD4
— —
Not used. (Open) Analog power supply pin (+3.3 V)
32 33
RFDCO PDSENS
O I
RFDC signal output Not used in this set. (Open) Reference voltage pin for PD Connect to ground in this set.
34 35
AC_SUM EQ_IN
O I
RFAC summing amplifier signal output Equalizer circuit signal input
36 37
LD PD
O I
APC amplifier signal output APC amplifier signal input
38 39
NC RFC
— I
Not used. (Open) Equalizer cut-off frequency adjustment pin
40 41
AVSS4 RFACO
— O
Analog ground pin RFAC signal output
42 43
RFACI AVDD3
I —
RFAC signal input or EFM signal input Analog power supply pin (+3.3 V)
44 45
BIAS ASYI
I I
Asymmetry circuit constant current signal input Asymmetry comparator voltage signal input
46 47
ASYO VPCO
O O
EFM full-swing signal output (Low=VSS, High=VDD) Wide-band EFM PLL charge pump signal output Not used in this set. (Open)
48 49
VCTL AVSS3
I —
Wide-band EFM PLL VCO2 control voltage signal input Analog ground pin
50
CLTV
I
Multiplier VCO1 control voltage signal input
HCD-RG333/RG441
Pin No. 51
Pin Name FILO
I/O O
Pin Description Master PLL (slave=digital PLL) filter signal output
52 53
FILI PCO
I O
Master PLL filter signal input Master PLL charge pump signal output
54 55
AVDD5 DDVROUT
— O
Analog power supply pin (+3.3 V) DC/DC converter signal output
56 57
DDVRSEN AVSS5
I —
DC/DC converter output voltage monitor pin Analog ground pin
58 59
DDCR NC
I —
DC/DC converter reset pin Not used. (Open)
60 61
BCKI PCMDI
I I
D/A interface bit clock signal input D/A interface serial data signal input (2’s COMP, MSB first)
62 63
LRCKI LRCK
I O
D/A interface LR clock signal input D/A interface LR clock signal output f=Fs
64 65
VSS PCMD
— O
Internal digital ground pin D/A interface serial data signal output (2’s COMP, MSB first)
66 67
BCK VDD
O —
D/A interface bit clock signal output Internal digital power supply pin (+3.3 V)
68 69
EMPH EMPHI
O I
High when the playback disc has emphasis, low it has not High when de-emphasis is ON, low when input OFF
70 71
IOVDD2 DOUT
— O
I/O digital power supply pin (+3.3 V) Digital signal output
72 73
TEST TES1
I I
74 75 76
IOVSS2 NC XVSS
— — —
I/O digital ground pin Not used. (Open) Master clock ground pin
77 78
XTAO XTAI
O I
Crystal oscillation circuit signal output (16.9 MHz) Crystal oscillation circuit signal input (16.9 MHz)
79 80
XVDD AVDD1
— —
Master clock power supply pin (+3.3 V) Analog power supply pin (+3.3 V)
81 82
AOUT1 VREFL
O O
Lch analog signal output Lch reference voltage signal output
83 84
AVSS1 AVSS2
— —
Analog ground pin Analog ground pin
85 86
VREFR AOUT2
O O
Rch reference voltage signal output Rch analog signal output
87 88
AVDD2 NC
— —
Analog power supply pin (+3.3 V) Not used. (Open)
89 90
IOVDD0 RMUT
— O
I/O digital power supply pin (+3.3 V) Rch “0” detection flag Not used in this set. (Open)
91 92
LMUT NC
O —
Lch “0” detection flag Not used. (Open)
Not used in this set. (Open)
93 94
XTSL IOVSS0
I —
Crystal selection input I/O digital ground pin
Not used in this set. (Connect to ground.)
95
XTACN
I
Oscillation circuit control signal input Self-oscillation when high, oscillation stop when low
96
SQSO
O
Subcode Q 80-bit and PCM peak and level data signal output CD TEXT data signal output Not used in this set. (Open)
97 98
SQCK SBSO
I O
SQSO readout clock signal input Subcode P to W serial signal output Not used in this set. (Open)
99 100
EXCK XRST
I I
SBSO readout clock signal input Not used in this set. (Open) System reset signal input “L”: Reset
101
SYSM
I
Mute signal input “H”: Mute Connect to ground in this set.
Test pin Normally ground Test pin Normally ground
23
HCD-RG333/RG441
Pin No. 102
Pin Name DATA
I/O I
Serial data signal input
103 104
VSS XLAT
— I
Internal digital ground pin Latch signal input The serial data is latched at the falling edge
105 106
CLOCK VDD
I —
Serial data transfer clock signal input Internal digital power supply pin (+3.3 V)
107 108
SENS SCLK
O I
SENS signal output SENS serial data readout clock signal input
109 110
ATSK WFCK
I/O O
111 112
XUGF XPCK
O O
XUGF signal output Not used in this set. (Open) XPCK signal output Not used in this set. (Open)
113 114
GFS C2PO
O O
GFS signal output Not used in this set. (Open) C2PO signal output Not used in this set. (Open)
115 116
SCOR VDD
O —
High output when the subcode sync, S0 or S1, is detected Internal digital power supply pin (+3.3 V)
117 118
C4M WDCK
O O
4.2336MHz signal output Not used in this set. (Open) Word clock signal output f=2Fs Not used in this set. (Open)
119 120
COUT NC
I/O —
24
Pin Description
Anti-shock signal input/output Not used in this set. (Open) WFCK signal output Not used in this set. (Open)
Track number count signal input/output Not used in this set. (Open) Not used. (Open)
HCD-RG333/RG441
• IC601 LC876996A-53H2-E (SYSTEM CONTROLLER) (PANEL BOARD) Pin No. Pin Name I/O Pin Description 1 O-MP3 CS O CS signal output to CD digital processor 2 3
O-MP3 LP MOTER I-MP3 ACK SOL-B
O I
LP signal output to CD digital processor and motor signal output ACK signal input from CD digital processor and motor signal input
4 5
O-MP3 REQ SOL-A I-SCOR
O I
REQ signal output to CD digital processor and motor signal output CD scor signal input
6 7
O-MP3 RESET I-BU1924 DATA
O I
RESET signal output to CD digital processor RG333: RDS data signal input RG441: Not used in this set. (Connect to ground.)
8 9
I-BU1924 CLK I-VOLUME-IN1
I I
RG333: RDS clock signal input RG441: Not used in this set. (Connect to ground.) Volume signal input from the encoder
10 11
I-VOLUME-IN2 RESET
I I
Volume signal input from the encoder Reset signal input
12 13
I-XT1 I-XT2
I O
Connection for input a crystal resonator (32.768 kHz) Connection for input a crystal resonator (32.768 kHz)
14 15
VSS1 CF1
— I
Ground pin Connection for input a ceramic resonator (10 MHz)
16 17
CF2 VDD1
O —
Connection for input a ceramic resonator (10 MHz) Power supply pin (+1.5 V)
18 19
I-PROTECT WFR/HP/MIC-IN
I I
Power amplifier circuit protection signal input SubWoofer or Headphone detection signal input
20 21
I-CD ENCODER I-CD OPEN/CLOSE
I I
Signal input from the CD encoder CD tray open switch signal input
22 23
I-TAPE A START I-TAPE B START
I I
TAPE A switches signal input TAPE B switches signal input
24 25 26
I-STREAM/VACS I-KEY 3 I-KEY 2
I I I
Stream/Vacs signal input Function key input 3 Function key input 2
27 28
I-KEY 1 I-SIRDS-IN
I I
Function key input 1 Data signal input from the remote contorol receiver
29 30 to 42
I-AC CUT G13 to G1
I O
Power down signal input FL tube grid signal output
43 to 45 46
S1 to S3 VDD3
O —
FL tube segment signal output Power supply pin (+3.3 V)
47 to 49 50
S4 to S6 S7/METER-SW1
O O
FL tube segment signal output FL tube segment signal output
51 52
–VPP S8/METER-SW2
— O
Power supply (–) pin (–26 V) FL tube segment signal output
53 54 to 63
S9/METER-SW3 S10/SW1 to S19/SW10
O O
FL tube segment signal output FL tube segment signal output
64, 65 66
S20, S21 I-SPEC/MODEL/METER
O I
FL tube segment signal output METER swich signal input
67 68
I-TUNED-IN I-STEREO-IN
I I
Tuning frequency signal input Stereo tuning signal input
69 70
I-AMS-IN I-REEL-A-IN
I I
AMS signal input A deck photo sensor signal input
71 72
I-REEL-B-IN VDD4
I —
B deck photo sensor signal input Power supply pin (+3.3 V)
73 74
I-CD NUM SENSOR O-POWER-RELAY
I O
Table address sensor swich signal input POWER RELAY control signal output
75 76
O-SYSTEM-MUTE O-POWER-LED
O O
System muting signal output POWER LED control signal output
77 78
STREAM-LED6/SOL B STREAM-LED5/SOL A
O O
Illumination LED control signal output Illumination LED control signal output
25
HCD-RG333/RG441
Pin No. 79
Pin Name STREAM-LED4/MOTOR
I/O O
80 81
STREAM-LED3/MP3-STB STREAM-LED2
O O
Illumination LED control signal output Illumination LED control signal output
82 83
STREAM-LED1 I-LC72121 DI
O I
Illumination LED control signal output Data signal input from tuner
84 85
O-LC72121 CE O-LC72121/BU2099FV DO
O O
Chip select signal output to tuner Data signal input from tuner and SP driver
86 87
O-LC72121/BU2099FV CLK O-BU2099FV LCH
O O
Clock signal output to tuner and SP driver LCH signal output to SP driver
88 89
O-BD3401 CLK VSS2
O —
Clock signal output to sound processor Ground pin
90 91
VDD2 O-BD3401 DATA
— O
Power supply pin (+3.5 V) Data signal output to sound processor
92 93
O-XTCN O-XRES (RESET)
O O
CD XTCN signal output CD reset signal output
94 95
O-XLT (CD-LAT) O-CD-DATA
O O
CD latch signal output CD data signal output
96 97
I-SENS O-CD-CLK
I O
CD SENS signal input CD clock signal output
98 99
O-MP3-DO I-MP3-DI
O I
MP3 data signal output to CD digital processor MP3 data signal input from CD digital processor
100
O-MP3-CLK
O
MP3 clock signal output to CD digital processor
26
Pin Description Illumination LED control signal output
HCD-RG333/RG441
5-2. BLOCK DIAGRAM — CD SECTION —
OPTICAL PICK-UP BLOCK (KSM-215DCP) DETECTOR VC
DIGITAL SIGNAL PROCESSOR IC301
RF AMP IC101
+1.7V +3.3V
VCC A
26 A
PCMDI 61
11 SDO0
B
27 B
LRCKI 62
16 LRCKIA
VDD 55
C
28 C
LRCK 63
19 SFSY/LRCKIB
D
29 D
PCMD 65
14 SDIO
E
19 E
BCK 66
15 BCKIA
F
20 F
BCKI 60
18 SBSY/BCKIB
LD
LD DRIVER Q10
+3.3V
VR SL/SP MOTOR DRIVER IC251 F+ FOCUS COIL
F T+
TRACKING COIL
T
S101 (LIMIT)
XLAT 104 CLOCK 105 SENS 107 SCOR 115
MP3-REQ MP3-ACK MP3-CLK
MIDIO 6
MP3-DI
MILP 5
MP3-LP
MICS 4
MP3-CS
XRST
RESET 2
MP3-RST
CH1FIN 5
XLT
SCOR
CLOCK
SENS
SENS
CLOCK
SCOR
XLT
XTCN
13 FFDR
DOUT
18 CH1OUT-F
MP-3STB
OPIN+ 3
B
MAIN SECTION
(Page 28)
14 FRDR
9 SFDR
AOUT1 81
10 SRDR
AOUT2 86
6 MPD
DOUT 71
• R-CH is omitted due to same as L-CH. • Signal Path
21 CH3OUT-F
M
RE701
XRST
CD-R
CH3RIN 29 M102 (SLED)
CD-DATA
CD-L
20 CH4OUT-F
: CD
22 CH3OUT-R MUTE 24
27
OUT1 4 OUT2 2
M
M751 (LOADING)
M
M741 (TABLE)
TBL MOTOR DRIVER IC712 9 RIN 7 FIN
OUT1 4 OUT2 2 D+3.3V
XLT(CD-LAT)
12 TRDR
19 CH4OUT-R
9 RIN 7 FIN
CD-CLOCK
17 CH1OUT-R
CH3FIN 30
S751 (OPEN)
SENS
XRST
11 TFDR
PANEL SECTION
(Page 29)
XTACN
CH2FIN 7
A
D
LM-R LM-F TM-R TM-F TBL ADDRESS SENS E-1 E-2 E-3 OPEN SW
SCOR
DATA
15 CH2OUT-R CH1RIN 6
MAIN SECTION
(Page 28)
DATA
16 CH2OUT-F
CH2RIN 8
M101 M (SPINDLE)
XRST 100 DATA 102
7 SSTP
MP3-DO
XTACN
78 XTAI
37 PD
LD MOTOR DRIVER IC701
MIACK 8 MICK 7
XTACN 95
PD
+3.3V
VDD 21 VDDM 40
PO11/BUCK/AD1 36
77 XTAO X171 16.9344MHz
+1.5V REG 1 IC303
STANBY 3
36 LD
GND
5
27
E-3 E-2 E-1
ROTARY ENCODER
TBL ADDRESS SENSE SWITCH Q731
TABLE SENSOR IC731
HCD-RG333/RG441
5-3. BLOCK DIAGRAM — MAIN SECTION —
SOUND PROCESSOR IC101 CD SECTION
MP3-STB CD-L CD-R
B
(Page 27)
1 CDL R-CH
VOUT1 33 VOUT2 32
MUTE Q306 MUTE CONTROL Q304,305
BUFFER IC102
RG333 RG441 POWER AMP IC441
R-CH
DO DI CLK CE TUNED STEREO RG333
RDS DATA RDS INT
RG441:Q489-491 RG333:Q489
OVERLOAD DET Q441,442
RELAY DRIVE Q485-488
61 TUNER_L
DO DI CLK CE TUNED STEREO
Q483,Q484
TH441
BBIN1 35 DATA
RDS DATA RDS CLK
RCLK
19 SI
BBNF2 31
18 SO
BBIN2 30
AC3
OVERHEAT DET
BUFFER Q106
BBNF1 34
SP R-CH R-CH
SWITCH Q351,Q352
SAOUT2 55 BUFFER Q327
11 TAPEB1
J804 VIDEO
FAN901
15 REC-OUT1 ASMOUT 40
FAN DRIVE Q310-Q312
FRONT SP RELAY
L R
J801 PHONES
BUFFER Q107
59 GAME-L 9 TAPEA1
AUDIO
R
R-CH
TU-MUTE
GAME INPUT
SPEAKER R-CH
MUTE
RELAY+B
TUNER-L TUNER-R
STK
MUTE CONTROL Q101,102
TM901 TUNER
L OVERLOAD DET Q481,482
MUTE Q103
CD-MUTE
JK441 RY441
R-CH
J803 VIDEO OUT
STK MUTE CONTROL Q308
DECK-A HP2 L
24 I-STREEMA/VACS 75 SYSTEM-MUTE 69 AMS
STK
WFR/HP/MIC 19 PROTECT 18
SP DRIVER IC371
R-CH
HP1 R
SYSTEM CONTORLLER IC601(1/2)
STK MUTE CONTROL Q309,313
AC4
RG333 11 Q5
DECK-B HRP2 L
12 Q6
Q324
HRP1 R
R-CH
RDS DATA RDS CLK
+9V L101 BIAS OSC Q321
HE1
RCLK DATA
7 Q1
9 REC SW CONT 4 7 P/B SW SELECTOR IC201
REC(FWD) B MODE REC(REW) A MODE B HALF
TBL ADDRESS SENS OPEN SW
CD NUM SENSOR 73 CD-OPEN/CLOSE 21 CD ENCORDER 20
88 CLK 91 DATA
E-1 E-2 E-3 LM-R LM-F
LM-R LM-F
TUNED
TAPE MECHANISM DECK
7 DATA 8 CLK
SWITCH Q322,323 CD-MUTE FRONT SP RELAY LM-R LM-F TM-R TM-F
STEREO
6 Q0 10 Q4 17 Q11 13 14 15 16
Q7 Q8 Q9 Q10
DATA 3 CLOCK 4 LCH 5
SO
DI CE DO CLK LCH
67 TUNED 68 STEREO 83 84 85 86 87
TM-R TM-F
23 22 70 71
DI CE DO CLK LCH
CAPM+
CAP M DRIVE Q601
MOTOR
B SOL
B TRIP DRIVE Q602
SOL-B
A SOL
A TRIP DRIVE Q603
SOL-A
TAPE B START TAPE A START I-REEL-A I-REEL-B
CD SECTION
(Page 27)
TM-R TM-F
VIDEO BUFFER IC602 11 MP3 STB 3 DATA 18 SO
DO SO
A HALF A-PHOTO B-PHOTO
D
CLK LCH SOL-A SOL-B MOTOR
4 CLK 5 LCK
• R-CH is omitted due to same as L-CH. • Signal Path : TUNER
6 SOL-A
: CD
7 SOL-B
: PB(DECK A)
8 MOTOR
: PB(DECK B) : REC(DECK B) : AUDIO
28
28
HCD-RG333/RG441
5-4. BLOCK DIAGRAM — PANEL/POWER SECTION —
SYSTEM CONTROLLER IC601(2/2) PT901 POWER TRANSFORMER S641-S650,SW601 FUNCTION KEY
25 KEY3
STREM-LED1 82
D401 LED610
S601-S608,S610-S612 FUNCTION KEY
VH+ VH–
27 KEY1
S621-624,626-630 FUNCTION KEY
STREM-LED3 80
LED DRIVER Q612
STREM-LED2 81
LED DRIVER Q611
9 VOLUME-IN1 10 VOLUME-IN2
ENCODER
F908
LED612
26 KEY2
S660 MASTER VOLUME
RG441
LED DRIVER Q610
D402
STREM-LED6 77
F904
VL+ LED611
RG441:E2,E51 MODEL S901 VOLTAGE SELECTOR LIVE 220V 240V LIVE 220V 240V
F905
VL–
LED DRIVER Q615
F909 LED615
STREM-LED5 78
LED DRIVER Q614
28 SIRDS-IN
STREM-LED6 79
RY901
RG333 LED614
REMOTE CONTROL 1 RECIEVER IC610
LED DRIVER Q613
B+ LED613
F905
B–
POWER LED 76
A+3.5V
2
LED601
A+3.5V REG 1 IC302
F906
D301-D304
CD SECTION
(Page 27)
A
SCOR XTCN XRST XLT(CD LAT) CD-DATA SENS CD-CLK MP3-DO MP3-DI MP3-CLK MP3-CS MP3-LP MP3-ACK MP3-REQ MP3-RESET
C1 C2 C3 C4 C5 C6 C7 C8 C9 C10 C11 C12 C13 C14 C15
C15 C14 C13 C12 C11 C10 C9 C8 C7 C6 C5 C4 C3 C2 C1
6 MP3-RESET 4 MP3-REQ 3 MP3-ACK 2 MP3-LP 1 MP3-CS 100 MP3-CLK 99 MP3-DI 98 MP3-DO 97 CD-CLK 96 SENS 95 CD-DATA 94 XLT 93 XRES 92 XTCN 5 SCOR
D+3.5V SW+3.5V
3 D+3.5V REG 1 IC301
–VFL
G01-G13
D908
REG Q902
+9V
3
+9V REG IC303
1
M+9V
3
M+9V REG IC304
1
FL601 43 45 47 S1-S21 50 52 65
AC3
F907
D305-D308
42 30
FLUORESCENT INDICATOR TUBE
AC IN
F904
D401
VF1 VF2 –VFL
RG333/RG441:AR,MX MODEL
RY901
AC4
D309-D312
VF1 AC IN
VF2 M+9V
B+ SWITCH Q314,315
AC4
EVER+9V RELAY DRIVE Q361,362 D902-905
+4V
12 I-XT1 X601 32.768kHz
POWER RELAY 74 +3.5V
13 I-XT2 RESET 11 15 CF1
X602 10MHz
RESET SWITCH Q605
B+ SWITCH Q604,616
RESET 3 1 IC604
AC CUT 29 16 CF2
29
29
5
+4V REG IC603
1
PT902 SUB TRANSFORMER
HCD-RG333/RG441
5-5. CIRCUIT BOARDS LOCATION
SENSOR board SW board
BD81A board MOTOR (TB) board
MOTOR (LD) board
DRIVER board
CONNECT board
TRANS board
AMP board
SUB TRANS board
VIDEO OUT board
REM board
PANEL board MAIN board
6 STREAM LED board
GAME JACK board
LEAD board
30
30
H/P JACK board
HCD-RG333/RG441
5-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS Note on Printed Wiring Board: • X : parts extracted from the component side. • Y : parts extracted from the conductor side. • : Pattern from the side which enables seeing. (The other layer’s patterns are not indicated.) Caution: Pattern face side: (Conductor Side) Parts face side: (Component Side)
Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
• Indication of transistor. C Q
These are omitted.
B E
Q B C
E These are omitted.
Q B
C
E These are omitted.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size)
5-7. WAVEFORMS
Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • 2 : nonflammable resistor. • C : panel designation.
– PANEL Board –
1
2V/DIV, 10µs/DIV
5.2 Vp-p
30.5 s
IC601
Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
2
• A : B+ Line. • B : B– Line. • Voltage and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM ( ) : CD PLAY : Impossible to measure ∗ • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. • Circled numbers refer to waveforms. • Signal path. F : TUNER (FM/AM) J : CD PLAY E : TAPE PLAY (DECK-A) d : TAPE PLAY (DECK-B) G : REC f : AUDIO • Abbreviation MX : Mexican model AR : Argentine model E2 : 120 V AC area in E model E51 : Chilean and Peruvian model
qd
2V/DIV, 40ns/DIV
4.9 Vp-p
100 ns
IC601
: LEAD FREE MARK
Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40 °C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350 °C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscou-s (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder.
31
31
(I-XT2)
qh
(CF2)
HCD-RG333/RG441
5-8. PRINTED WIRING BOARD — CD MECHANISM SECTION (1/2) — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
13
14
A
M101
C302
B
IC303
C305
C255
C303
R404
R403
R354
R163
R131 C131
• Semiconductor Location
Q10
G-6
R161 R151
R204 R133
H
32
32
C185 C186
C162 C122
C132 R143 R141
Q10
R132 C133
R11 R12
C124
C123
Location F-11 D-8 D-11 B-12
R181
C161 CN101
R13
C18
C11
C15
C111
R10
C134
R121
R111
C17
CN201
R182
C194 R412 R406 IC101
R112
C10
C171
R171
C209
C125
C16
C181
C115 C112 C195
C151
Ref. No. IC101 IC251 IC301 IC303
R410
C213
C211
C114 C113 R113 R114
C14
R172
G
R401 R409
C172
X171 C203
R407
C163
R173 C196
C174 C201
F
R303 C310
R191
C182
R201
C317 R305 R402
R162
R165
C183
R252
R306
R408
C309 R251
C184
R411
C116
C318
C251
FB301
C308
IC301
C311
C320
R307
C259
C307
R253
C258
R205
R301
R353
C312
C210
M102
C313
IC251
C314
E
R419
C306
R352 R302
D
C252
C257
C212
C315 C316
S101
C260
R405
R313
R351
C
C143 R203 R142 C141 C142
R202
(Page 42)
HCD-RG333/RG441
5-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 50 for IC Block Diagrams.
CN101 C15
TP423
R307
C134
TP122
TP123
C123
R121
TP124
TP15 TP16
R132
C306 IC301
R303
R11
TP17
TP121
C309
TP102
C18
TP125 R141
R351
TP303
TP14
C10
C122
R133
TP302 C308
JPO10
C132
C133
R142
TP13
Q10 C11
C124
C143
TP12
C14
C141
R151
TP11
TP424
C16 R10
R143
R203
C17
R12
C151
IC B/D
TP10
R13
R131
C142
TP304 C307
C131
C125
TP18 TP19
R302
R405
TP427
R404 C310 R419
TP103
R352
R403 R402
R353
TP104
R354 R401
R111
C317
JPO102
C161
R301
TP301
TP105
C318
R313 C315
C112 C113
R305
R113
R114
C114
JPO103
C316 C162
R306
C311
C111 R112
R161
C171
C320
C116
C115
R171
TP177 TP428
IC101 X171
TP429
R172
C174 R173 IC303
C172
TP430 C195
C314
C312
R181 C313
TP431
C185
C181
C186
C182
C183 TP432 TP433
C184
TP167
R182 TP178
FB301
C302
C303
TP166
C305
TP422
TP165 C194
TP162
TP146
TP153
TP147
TP160
R191
TP144
TP145
TP149
TP148
TP142
TP425
S101
R252
JPO004
R251
C251
C258
C259
R165 TP426
C163
R162
C196
C210 CN201
R253
TP186
TP187 TP401 TP402
IC251
TP436
TP403 TP404 TP405 C201
TP406
R163
C209
TP407 R201 TP420
TP408
C203
TP250
R205
(Page 43)
R410
TP415
R409
TP414
R408
TP413
R407
TP412
TP421
TP251
TP416
C252
TP252
R411
TP253
TP417
M102 C257
R406
TP419
R412 C260
C213
TP434 TP410
C212
C211
TP411
TP409
R204
M101
TP435
33
33
C255
IC B/D
HCD-RG333/RG441
5-10. PRINTED WIRING BOARDS — CD MECHANISM SECTION (2/2) — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
13
14
A
CN704 CN702
C751
B
CN705
R733
C
R734
C736
Q731
R732
R735
C737
C735 JW710
JW707 JW706
C715
JW705
R713
D711
R701
D701
JW708
C752 JW712
JW709
CN703
R722 R721
CN741
CN721
R702
JW711
C741
D
CN742
R751
R723
R711
E
IC731
R712
CN701
JW713 JW704 JW714
(Page 38)
IC712
IC701
JW703
F
MAIN BOARD CN301 CN731
JW702 R731
C731
JW701
G CN751
• Semiconductor Location
H
Ref. No. D701 D711
Location D-6 D-7
IC701 IC712 IC731
F-6 F-7 E-11
Q731
C-9
34
34
S751 (LEVER SW)
HCD-RG333/RG441
5-11. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 50 for IC Block Diagrams.
IC701
IC B/D
R702
R701 C715
D701 CN721
CN704 C751
M751
IC712
IC B/D R712 CN751
R713
CN705C752 D711
S751
R711
R751
R734
R735 CN702
CN742
C741
M741 IC731
CN731
R733
(Page 37)
R732
R731 C731
CN741
CN701
Q731
CN751
CN703
R723
R722
R721
C737
C736
C735
RE701
35
35
HCD-RG333/RG441
5-12. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 51 for IC Block Diagram.
CN309
R151 Q101
(Page 43)
R216
R217
R219
R385
R388
R391
R386
R152
R392
C235 R218 R387 JW201
R390 R394
Q311
CN308
D203
D204
Q102
C175
R393
JW202
R162
R157
R395
EP101 FAN901
R389
R153
R154
R155 R158
D205 R156
Q312
C228
Q103
Q104 R231 R227
Q310
R159
R228 R163
R225 C229
R232
C230
R226
D207
R160
R161
R164
R165
D206
C188
D202 R230
R229
R174
R220 R222
CN307
D201
Q105
R223
C186 R167
R170
R166
C189
(Page 46)
C187
R172
C177 C178
R175 R221
C185
C176
R173
C181
R168
C190
C184
C183
C179
R171
R169
IC102
C166 C165
(Page 49) C290
R141
C162
R142
C164
R139
C289 R138
R204
R272
R203
C153
C160
C161
C152
IC B/D
R105 C106
R101
C105
R103
C151 C150
R205
C103
C102
R206
C214
R210
C222
C206
C148
R198
C146
R107
C110 R108 C193
IC101
C109
C144
C278 R212
C280 C281
R211
C143
R283
FB203
C141 C140
R284
R281
FB202
R282
R209
FB201
(Page 43)
C142
C279
R208
C212
C145
R133
R106
C277
C213
C217
C147
R134 C108
Q306
Q307 C216
R197
R207
R135
C149 C104
CN305
R136
R104
C101
Q305
Q304 C211
C107
R102
C276
R202
C163
R201
C157
C154
R137 C159
C139
FB204
R132 D324
R109
C275
R112
C113
C114
C111
C112
C138 D325
C115 C116
C137
C274 R177
C135
R194
C122
C124
JW311 FB205
R127
C136 C129
C191
R115
C128
C192
R114
C127
R195
C121
C123
C117
C125
C118
R131
R113
D326
CN314
R176
C120 R110
R111
(Page 43)
C119
C271
FB205
Q106
C272
R129
R128 R121 Q107
R116
C132
R117 R254
(Page 37)
36
36
C126
R120
R119
HCD-RG333/RG441 5-13. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 51 for IC Block Diagrams. (Page 36)
Q362
C270 R361 R362
R364
Q361
R363 R275 D316
R274
Q315
Q314 R323 R321
R253
C252 C312
R324
R322
D215
IC302
C315
C321
C311
C258
C309
C318
C253
D212
R262
D213 Q327
D321
R264
Q321
C241 C308
JW303 R273
R266
D313
IC303
IC304
JW301
C259
R241
IC301
R325
D314
C242
C243
R263 R265
R242
C251
CN303
D315
C244
R243
R252
(Page 46)
D214 C351
Q324
EP301 JW302 D310
D309
D312
D311
JW305
R251
C302
Q351
L101
R356
C301
D308
C306
(Page 49)
R352
C310
D307 D306
R351
R353
R250 C313
C316
R354
R357
D305 D301
D302
C303
C248
R244
C246
Q352
C305
R358
C304 D303
D304
IC B/D
C354
C352 IC201
C374
C375 R245
C371
C264
CN112
HP1
R371 C372
R372
HP2
C249 C265
R384
R373
R313
C373
R312
R374
D322 C353
R306 R375
R382
HRP1
C376 Q308
R381
R376
CN103
C266
R383
C267 R246
R307
R377
HRP2
R311 R247 R308
R378
C288 HE1
R379
IC B/D
Q313 IC371
Q322
R310
R248
C250
R380 Q309
C342
R348
D211
CN302
R347 R343
R213
R214
Q323
R249
R346
R345
R342
R341
R344
CN301
(Page 35)
(Page 40)
37
37
CN101
HCD-RG333/RG441 5-14. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
(Page 42)
6
: Uses unleaded solder.
7
8
9
10
11
12
(Page 34)
(Page 42)
A • Semiconductor Location
JW109
JW4 JW5
JW115
R344
R343 R342 R341
JW143
JW144
JW9
JW10
JW11
JW12
JW13
JW26
C181
JW14
JW15
JW17 C178
R161 R165
JW35 R172
Q105
IC302
C190
R254
C189 JW50
C309
D313
C315
C318
JW46
JW105 D203
Q312
JW55
Q311 D202
D204
R232
R223
JW61
JW62
R163
R159
R155 R154
JW54
R231
JW57
C302
D205 R230
R220
JW149
JW204
R227
C230
R222 R221 D201
Q101
R152 R151
R162 JW52
D304
D207 D206
R229
JW148
JW59
CN303
CN307
JW303
JW58
EP101
JW305
C289
JW302
J (Page 45)
(Page 48)
(Page 44)
38
(Page 47)
38
EP301
D303
R228
JW51
JW56
JW69
LP304
R225
C229
R157 C175
C290
R273
Q310 R226
JW53
JW68
I
R158
JW63 C301
D302
D301
JW65 D308
D306
D305
D309
D311
D310
D312
D307
C304
Q103 Q104
JW47
JW48
JW49
JW70
JW71
JW72
JW73
JW76
JW77
JW74
JW75
Q361 Q314
C303
JW202
C305
JW203
R156
JW64
JW83
D321
JW66 JW67
C306
C235
JW31 R153
Q102
D315 C310
R325
LP302
JW30
C313 C316
R218
JW201
R169
JW33
JW37
JW38
C308 C270 Q315 R323 R275
JW80 D316 R274
R395 R390 R389 R387 R386 R385
CN309
JW29 IC301
JW158
R394 R393
R219
R361 R324
JW301
IC303
Ref. No. D201 D202 D206 D207 D211 D212 D213 D214 D215 D301 D302 D303 D304 D305 D306 D307 D308 D309 D310 D311 D312 D313 D316 D321 D322 D324 D325 D326
Location H-8 H-9 H-9 H-9 F-3 G-4 G-4 G-3 G-3 H-6 H-6 H-6 H-7 H-5 H-6 H-6 H-6 H-5 H-5 H-5 H-5 F-6 G-5 H-4 H-3 E-3 E-2 E-2
IC101 IC102 IC201 IC301 IC302 IC303 IC304 IC371
D-5 D-7 E-4 F-6 E-7 F-6 F-5 B-3
Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q312 Q313 Q314 Q315 Q321 Q322 Q323 Q324 Q327 Q351 Q352 Q361 Q362
G-7 G-7 G-8 G-8 E-9 D-6 D-6 E-3 E-3 D-3 D-3 B-3 B-2 G-9 H-9 H-9 B-2 G-5 G-4 F-5 E-3 E-3 F-3 F-4 G-3 G-3 G-5 G-4
R173 R175 R174
D314
JW82
JW157 R391
H
JW32
C194
IC304
R362
R322
R313
JW85
D322
R388 R392
R216 R217
R321
C321
R363
JW86
JW87 LP303
(Page 42)
C252
R263
D212
D213 C259
JW81
JW88
JW156
JW89
JW90
JW92
JW93
JW91
R364
JW84
D215
R354
Q352
G
R266
R357
Q351
JW27 JW28
C311
R115 C242 R242
C243
C312 JW40 JW41
Q362
JW304
C353
R262
C184
JW78 R253
C253
C258
R352
D214 R265
JW94
C351 R353 R264 R356
Q327
R351
R358 C352
JW20
JW45
C251 R252
JW19 JW24
R241
JW79
R213
JW34
C143 R129
R132 C274
R127
C275
R250 R214
C187
JW44
JW42
Q324 JW95
JW21 JW23
R170 C183 R171
FB205 C123
JW97 JW96
JW22
R160
C129
C125 JW39
C124 R194
R164
C185
JW36
C186
R120 R119
C246
CN103
C137
C132
R121
C266
C267
C176
R168 R167 R166 C179 C177 IC102
Q107
JW16
C148
R134 R131 R176 C139
C146
C144
R116
R117
C122
R114 JW104
C241
C127
C248
C117
C116 R110
JW99
R251
C140
R137 R107 R197
L101
JW103
D211
JW102
C249
R247 R246 C288
C126
C244
R245
JW100
R112
C118 C192
JW101
R249 C250
C114
C128
C120 C119
R195
R243
C113 IC201
JW155
C121
R113 C191 R111
C115
R244 R109
C112 R248
R177 R128 Q106
C164 JW118
R135
JW117
C161 R106
R284
C264
R283
C138
C271 C272
C278 C279
C280 C281 JW159
R108 C109
C166
Q321
R211 C102 R101 C106
C104 R198
C108
C277
C111
Q323 Q322
D326
C193
C136 C135
C103
JW106
C265
CN112
D324
JW98
C206 C105
R102
C107
C211
C101
R103 R104
R282 R281 C110
R205 Q305
C163 C276
R204 R207 R210 Q306 Q304
R203 D325
C141
1
JW141 R206 R105
R201
JW138
C154
C147
C145
10
JW139 JW137
C153
CN308
JW8
R348 C228
R133
C149 C142
C152
IC
Q307
JW135 JW136
R136 C162
C213 R212 R208 R209
C214
JW140
C160
C159
JW142
R202
JW134
D
C212
C216
C222
C217
JW133
F
R139
R138
FB201
E
JW116
JW119
JW120
FB203 FB202
CN305
CN302
JW131
(Page 39)
C157
C151
C150
FB204
JW130
JW311
R346 R347 R345
JW18
R272
JW132
R141
LP301
C165
C342
JW114
JW150
JW129
JW7 CN301
R142
JW128
JW6
CN314 JW113
C188
JW110
C354
C
JW1
JW107
R379 R380
R307 R384 R383
R382 R381
JW145
JW2 JW3
R373
JW124
JW127
CN101
JW112
R378
JW123
JW126
C375 R371
JW125
IC371
R374 R375 R376 R377
JW122 JW121
R312
C371
C373
JW151
C372
C376
R372
R311
B
Q309 R310 C374 R308 Q308
JW108
Q313
R306
JW146
B1
• Semiconductor Location Ref. No. Location Ref. No. D603 C-12 D613 D604 C-12 D614 D605 C-12 D615 D606 E-9 D616 D607 C-11 D620 D608 E-9 D621 D609 E-9 D622 D610 E-10 D623 D611 E-9 D625 Location E-10 D-10 G-7 G-7 B-7 B-6 B-6 B-6 B-6 Ref. No. D626 D630 D631 D632 D633 Location B-6 G-4 D-10 D-10 D-9
IC601 IC602 IC603 C-7 E-12 E-10
H
Ref. No. IC604 IC610 Location D-10 A-14
LED601 C-12
Q601 Q602 Q603 Q604 H-7 H-7 H-7 B-11
CN602
Ref. No. Q605 Q610 Q611 Q612 Q613 Q614 Q615 Q616
39 JW661
Q613
CN605
(Page 42)
Location D-9 F-9 G-8 G-8 G-8 G-9 G-9 B-11
39 JW657 JW655
Q615 Q614
R706 R713
C655 CN604
(Page 42)
C617
R624 R722
Q612 JW811
JW677 IC603
R720
JW665 S648 R671
C608
JW639 JW637
JW646
S650
R721
S630
S627
JW638
S647 JW606
S628
S649
JW662 S629
JW627
S626 R674
D604
S602
R735 R653
JW641
JR607
R654 R642
R736
D603
R643
R644
R772
D622
R660 R659
JW633 R672 R731 R675
R639
D605
R715
JW616
R640
R641
R687
R638
JW628
JW611
R683
R656 R655
JW636
JW612
Q604
R634
C615
JW613
Q616 R684
JR624
R737 C628
R738 C629
C630
A CN610
11
R633 C603
JW679
JR609
D633
C604
JW632
C601 C602
JW635
JW642
JW664
JW603
R632
C614
JW607
C644
JW629
D631
JW640 JR614
JW625 JW634
JW608
D614
C619
R658 R657
JW663 R661
JW618
R662
JW678
JW619 JW620
D607
JW617 C605
R791
JW630
R689
JW614
JW643
C611 Q605 C656
JW621
JW622
JW687
C631 R739
C632 R740
C633 R741
R742
10
JW631
R682
JW623
JW624
JW686
JW688
C649
JW644
R688
JW690
JW691
JW694
JW626
D632
IC604
R686
R854
R714
C623
JW647
D608
JW680
CN608
R743 C634
R744 C635
9
JW648
JW645
D613
D610
JW815
C646
JW651
D606
JW676 C606
R863
R685
JW652
JW666
C609
C610
R788
R711 R710
Q610
JW656
JW653
JW654
JW667
R679
JW693
R745 C636
R746 C637
C638
C639 R747
C640 R748
R750 R749
R752 R751
R753
R755 R754
R757 R756
R759 R758
R761 R760
R762
R764 R763
R766 R765
R768 R767
R770 R769
8
R698
Q611
C653
R733 R681
JW703
D611 D609
JW669
R680
X602 C607
C654 JW692
C642
JW681
C624 C626
1
FL601
JW668
JW672
R730
R729 JW682
C625
60
JW695
JW671
C613
JR611 JR612
R732
JW670
R631 JW683
R727
X601
JW658
JW673
JW684
JW719
JW659
JW674
IC
R792
R702
JW660
R728
C643
R704
JW720 JW685
R630
JW813
D620
D623
R716
R717 R718
7
R712 C618
JW740
R725
JW712
R637 R787
R636
D621
JW696
R700
D616
R723
R623
S646 JW675
JW716
JW713
JW714
R784
D615
S645 JW736
R796
JW701
JW702
JW697
JW737
JW715
JW814
JW704
JW698
R621
JW750 JW739
D630 JW738
JW728
JW717
JW718
C612
JW729
JW721
JW705 JW706
R615
JW730
R771
JW805
JW806
JW807
R719
6
R626 Q602
JW746 JW722
JW700
JW802
JW803
D625
R625 R622
JW745 JW723
JW708 JW707
JW804
C641
C647
D626
Q603
S644 JW725
WIRE806 R773
R616 R617
S610 R601 R618 R799 R798
R677 JW731
JW726
JW709
JW782
JW724
JW727
JW800 JW801
C620
R794 JW699 R793
JW743 R607 R608
JW810 JW710
JW711
S603
JW732
JW733
JW770
R774
5-15. PRINTED WIRING BOARDS — PANEL SECTION — • Refer to page 30 for Circuit Boards Location.
R708
JW748 R795
R619
S611 JW769
JW792
JW734
JW735
R669
JW793
R605
R663 R775
R777 R776
R778
R781
R785 R783
C622
JW744
R678 JW760 R789
JW794
R609
R652 JW799
R604
R697 JW773
JW795
JW751
S612 JW772 JW771
JW796
R670
JW789
JW774
JW797
R610 R790
R664 JW776
S642
JW775
R665
JW753
S643 JW777
JW781
JW757
JW788
JW754
R666
JW790
5
JW741
JW747
4
R611 R613 R602 R603 R606
G CN603
R797
R676 R696 JW798
C621
R612
JR622 JR617
JW808
(Page 42)
JW752
R695 S641
JW755
R694 JW759
JW780
JW812
R691 R667
R782
JW756
R692
JW758
R690
JW761
JW778
JW784
JW763
JW787
R668
R635
R734
R628 R627
JW762
JW602
3
R614
C648
JR623 JW765
R780 R779 JW791
R620
S608 JW786
R629
R651
CN601 JW779
JW783
JW764
(Page 38) JW785
JW809
2
JR621
Q601
JW749
R693 JW766
S606
E JW768
D
JW767
F S607
S604
R649 R650
C
R645
JW601
B
R648
S605
R646
1
Administrator SV-HCDRG333-PANEL
R647
HCD-RG333/RG441
: Uses unleaded solder.
12 13
R786
JW689
LED601 S601
JW615
JW610
S621
S622
IC602
JR608
S623
S624
14
IC610
HCD-RG333/RG441
5-16. SCHEMATIC DIAGRAM — PANEL SECTION (1/2) — • Refer to page 51 for IC Block Diagram.
CN605 R704 R706 R708
(Page 43)
R700
JW660
R702
JW659
Q610
CN604
Q612
Q611
Q614
Q615
Q613
R698 JW674 JW718
(Page 43)
JW705
JW655
JW656
JW658
CN601 JW784
D605
JW783 JW601 JW602 R629
R628
(Page 41) R639
D604 R640
R627
C605
R641
D603
R854
R690 R691 R672
R731
JW811
R692 R693 R638
R694 R695 R696 R697
IC B/D
C655
R674
IC602
R663
R652
R651
R650
R649
R648
R647
R646
R645
R644
R643
R642
R635 S612
S611
S610
S608
S607
S606
S605
S604
S603
S602
S601
C602
C603
JR607
JR609
JR608
R634
R633
JW714 JW635
C601
JW701
C604
JW625
JW626
C644
JW716
R632
JW641
JW703
(Page 37)
R662
S630
R722
R721
S650
40
40
R661
R660
R659
S629
S628
S627
R720
S649
R671
S648
R658
R657
S626
R670
R669
S647
S646
R656
R655
S624
R668
S645
R667
S644
S623
R666
S643
R665
S642
R654
R653
S622
S621
R675
R664
S641
R676
HCD-RG333/RG441
5-17. SCHEMATIC DIAGRAM — PANEL SECTION (2/2) — • Refer to page 31 for Waveforms.
FL601 CN603 JW812 R785 R783
C629
C623
C628
C632
C631
C630
C634
C635
C633
C638
C637
C636
C640
C639
R751
R750
R753
R752
R756 R755
R754
R759
R758
R757
R762
R761 R760
R764
R763
R767
R766
R765
R770
C622
R780
R769
R781
R768
R782
R779
(Page 43)
R710
R712
LED601
R778 C620
R719
C621
R777 R772
R718
R771
C642
R711
R713 C617
C618
R602
R601
R605
R604
R603
R607
R608
D621 D620
JW721
D622
JW673
D625
JW722
D623
JW723
JW729
D626
JW724
JW728
R793
JW670
R792
R717
R794
R716
JR617
R796
R774
R606
R776 R775
R621
JW706
R622
R795
JW708
JW709
JW707
JW606
Q601
JR621
R790
R609
R610
R611
CN602
R797 R773 JW607
R624
R789
R613
R612
R623
Q602
R614
C641 R615 D615 R798
R749 C643
R748 IC601
R616
R617
R747
53H2
R746
JW608
R626
R625
R799
R745
R618
R744 R784
R619
Q603
R743
R620
R742 R741
D616
R740 R787
R739 R738
R637
R636 IC610 CN608
R714
R734
R735
R736
R791
R733
R727
C626
R728
R788
R737
R730
R630 R631
R725
R723
R729
JR624
(Page 40)
R715
CN610
C619
R732
C654
D611
C607
C625 C610
C647
R681 C653
X601
JR611
D607
JR612
X602 C624
C649
R680
C611
D609
R682
D608 D630
R677
Q605
R678 IC603
R687
R863
C648
R686 C612
R679
D606
C646
C606
C608
C613
C609
C656
R685
D633
C614 Q604 R689
R786
R683
R684
D632 D610
C615 D631
41
41
IC604
R688
Q616 WIRE806
D614
D613
HCD-RG333/RG441
5-18. PRINTED WIRING BOARDS — JACK SECTION — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
: Uses unleaded solder.
7
8
9
10
11
12
13
14
LED613
JW874
R701
SW
60
R699
1
LED615
C
(Page 38)
S660 R709
CN871
(Page 38)
J801
(Page 39)
LED611
CN874
JW873
R707
C831
JR871
JW876 JW878
C832
C830
R703
R673
JW877
R705
JW875
C873
LED614
B
JW872 JW879 JR872
JW871
LED612
W803
CN804
CN607
(Page 39)
CN873
FB871 FB872
JW831
C872 C871
C876 C875
C874
A
LED610
CN606
D
LP872
LP874
LP871
LP873
(Page 39)
E (Page 32)
F
G
CN801
(Page 38)
C804 WIRE801
C803
R801
R804
C801
JR801
R803 J804
LP804
LP802
W806
EP802
CN802
H
42
C861
J803
CN805
R802
C802
42
• Semiconductor Location Ref. No. LED610 LED611 LED612 LED613 LED614 LED615
Location C-9 B-9 A-9 A-7 B-7 C-7
HCD-RG333/RG441
5-19. SCHEMATIC DIAGRAM — JACK SECTION —
C830 C831
CN874 S660
SW601
CN804
JW877
R709
(Page 36)
LED615
R705
R701
R703
R707 LED614
R673
LED613
(Page 36)
JW878
LED612
FB871 JW875
LED610
JW876
CN871
LED611
R699
J801
C832
FB872
JW871
W803
JW872 CN873
JW873
CN606
CN607
JW874
(Page 33) JW879
C874
(Page 40)
(Page 40)
CN805
CN802
C876
C875
C873
C872
C871
(Page 41)
J803
JR872 R801
JR871 R803
C801
R804
C802
J804
JR801 C804
C803
R802 CN801 C861
(Page 36)
WIRE801
43
43
EP802
W806
HCD-RG333/RG441 5-20. PRINTED WIRING BOARD — POWER AMP SECTION (RG333) — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
6
7
8
A
• Semiconductor Location
R483
Q481
C481
R493
D483
B
R467
R491
Q489
R486
R484
JW471Q483
R485
Q482
R492 R465
R466
R494
C488
JW468
Q484
TH441
JW466 JW403
JW465
JW461
R453
JW464 R496
JW432
R451 JW404
JW462
C451
C453
JW469
C
R454
R455
JW458
JW457 JW455
JW456
JW452
JW453
JW446
JW447
JW454
C405
JW436 JW435
JW401
C403
JW444
JW445
D401
LP401
JW417
C406
JW416
JW419
R402
C458
(Page 45)
JW412
JW411 JW409
R407
JW407
D443
JW408
R461
L441
L442
R462
JW415
RY441
JW472
JW400
JW418
C457
C455
JW413
C456 R464
CN442
JW443
C404
JW421
JW414
JW420
C459
JW434 JW433
C460
JK441
C407
C408
I
R401
C402
R463
JW402 EP402
JW423
Q487
EP401
R489 JW422
R488
R457 R459 D481
Q486 C486
D441
R458
D482
R487
R482
D442
JW427 R490
JW474
JW437
Q485
G
Q441
Q442
R456 R460
R411 JW426 R412
JW439 JW438
JW473
C487 R481
JW440
JW425
R448
Q488
R442
C491
JW424
R414 C442
R444
C444
C448
JW449
JW442 JW451
R446
JW429
JW428
C441
R443
C443
C447
C446
R441
R413
F
JW431
R495
C489
IC441
R445 C445
JW450
C452
R447
JW441
E
JW430
JW463
JW460
R452
JW459
C454
D
Ref. No. D401 D441 D442 D443 D481 D482 D483
Location H-6 E-5 E-4 J-4 E-5 G-4 B-4
IC441
D-3
Q441 Q442 Q481 Q482 Q483 Q484 Q485 Q486 Q487 Q488 Q489
D-5 D-4 B-4 B-4 B-5 B-5 G-3 G-4 G-4 F-4 B-4
JW470
JW467
H
: Uses unleaded solder.
JW410 CN441
J (Page 38)
44
44
HCD-RG333/RG441 5-21. PRINTED WIRING BOARDS — TRANSFORMER SECTION (RG333) — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
13
14
A
JW918 LP903 CN902
CN906
C LP901
C910
C909
D908
D901
C911
CN904
C908
D906
D903
R903
D902
R904
B
D905
R908
D904
Q902 C906
JW900
RY901 PT902
PT901
JW923
D
FH907
FH908
E
CN905
(Page 44)
FH909
JW922
JW903
JW906
F904
FH910
F
JW908
C920
FH912
JW929
JW921
CN901
F905
FH911
F906 C921 C922
JW902
C926
C925
JW926
JW924
(Page 38)
FH914
FH913
JW917
H
CN907
JW930
JW920
JW910
G
F907
C924
CN903
C923
LP902
• Semiconductor Location
I
45
45
Ref. No. D901 D902 D903 D904 D905 D906 D908
Location C-3 B-2 B-2 B-2 B-2 C-12 C-10
Q902
C-12
HCD-RG333/RG441
5-22. SCHEMATIC DIAGRAM — POWER SECTION (RG333) —
JW403 C441
L441 RY441
R451
R441
JW441
R461
IC441(1/2)
C445
R413
R466
R462
R465
R411
R464
R463
C456
C455
TH441 L442
R447 R483 R455 R445
R491
R467
C451
Q481
Q482
Q441
R485
C459
D443
Q483
JK441 C458
C457
R484 R407
C460
C453
R443
R444
C444
Q489
C488
C491 0.001
R493
R494
R446
EP401
R486
Q484
C481 R459
C408
C407
R453
C489
C448
D442
C443
R492
D441
D483
C447
R457
R495
D481
R460
Q485
R454
R414
C486
R482
R458 C454
R448 Q442
D401
C452 R481
R456
C446
C402
Q487
JW401
IC441(2/2) C442
CN441
R487
JW442
C405
R452
R401
C403
Q486 JW404
R490 R488
R412
C487
D482
R442
Q488
C406
C404 JW402
R402
R489 R496
JW407
(Page 36)
EP402
CN442
PT901 F904 FH908
CN905
FH907
F905
CN904
FH910
FH909
FH912
FH911
CN907
CN903
JW908
JW902 RY901
D901
F906
JW910 F907 FH914
(Page 37)
PT902
FH913
R908
CN902
D908
D903
D902
JW903
CN906 Q902
D905
C908
D906
C924
C925
C926
C922
C923
C920
C921
C910
CN901
JW917
R903 R904
D904
JW906 C906
C911
C909
46
46
HCD-RG333/RG441 5-23. PRINTED WIRING BOARD — POWER AMP SECTION (RG441) — • Refer to page 30 for Circuit Boards Location.
1
2
3
4
5
6
7
: Uses unleaded solder.
8
9
10
11
12
C492
R483
Q484
R484
Q483
R486
• Semiconductor Location EP491
JW453
R457
D481 C481
R466 R465
JW446
Q442
JW404
C445
R446
EP402
JW412
JW409
LP401 CN442
C403
JW410
D401 R409
LP402
C413
C404
R410
JW415
JW475 JW474
JW477
C406
D402
C4
JW483
JW414
JW424
JW425
R404
JW413
JW401
09
JK441
(Page 48) C414
R402
JW426 JW427
JW411
C405
R490 R489
R488 Q487 C402
JW482
Q488
Q486
JW418 JW417
Q485
EP401
D482
JW471 JW470
R447 R487
R482
JW488 JW479
JW473 JW472
C486
C487
R481
JW481 JW487 JW478
R403
JW430 JW431
R401
JW428 JW429
C441
C447
H
JW458
JW455
JW469 JW468
R412 C442
R413
R414
R445
R441
R411
JW441 C443 R443
R453 R454
10
R444 R442
G
C454
C448 C446 C444
F
C452
R448
JW442
E
JW467 JW466
C453 R476
JW447
D442 R460 C451
R458
JW445
JW465
R456
R459
Q441
JW457
IC441
R449
JW460
JW486
JW459 JW448
Q482
JW403
JW485
Q481
D441
JW449
JW461 JW462
R455
R450
R474
JW451 JW450
JW464 R495
JW420 JW421
CN441
J (Page 38)
47
47
LP403
JW422
JW423
R407
JW432
R461
RY441
JW419
D443
R462
I
L442
L441
JW489
JW416
JW476
LP404
D
R478 Q491
R496 JW452 JW463
C
C463
R470 R473
R475
JW443
D445
JW484
D446
Q489
TH441
Q490
C461
R472 D444
R469
R477
R471
C4
B
R467
R468
C462
R485
A
Ref. No. D401 D402 D441 D442 D443 D444 D445 D446 D481 D482
Location G-8 H-9 C-4 D-5 I-4 B-5 C-3 C-3 D-5 G-4
IC441
D-3
Q441 Q442 Q481 Q482 Q483 Q484 Q485 Q486 Q487 Q488 Q489 Q490 Q491
D-4 D-4 D-4 D-4 A-4 A-4 G-3 G-4 G-4 F-4 B-4 C-5 C-5
HCD-RG333/RG441 5-24. PRINTED WIRING BOARDS — TRANSFORMER SECTION (RG441) — • Refer to page 30 for Circuit Boards Location.
2
1
3
4
5
6
7
8
: Uses unleaded solder.
9
10
11
12
13
14
A LP903 D904
D905
D902
D903
CN904
JW911
CN906
CN902
B
D901 C911 Q902
C906 D908
R908
C909
C
C908
R904
LP901 R903
C910
JW912
D906 FH916
RY901
FH915
PT902
JW923
F908 JW905
D
PT901 FH908
CN905
F905
F909
JW909
CN907
(Page 38)
C926
C922
C921
C920
C925
C923
W901
C924
LP902
JW929
JW928 JW917
JW902
JW930
JW934 JW932
JW924
FH914
FH913
F907
JW931
JW933
F906
JW920
JW910
JW901
CN903
FH912
FH911
S901
G
H
FH917
FH918
CN901
JW921
JW908
F
(Page 47)
FH910
FH909
JW907
JW925
E
F904
JW922
JW903
JW906
FH907
• Semiconductor Location
I
48
48
Ref. No. D901 D902 D903 D904 D905 D906 D908
Location B-3 B-2 B-2 B-2 B-2 C-13 C-10
Q902
B-12
HCD-RG333/RG441 5-25. SCHEMATIC DIAGRAM — POWER SECTION (RG441) —
C461
R496
R467
D445
L441 R411
C441
R449
R474
R441
RY441 JK441
R461
Q491 JW441
R462
IC441(1/2)
R466
C445
JW403 R472
R473
R465 L442
C451
R455
TH441
D443
R485 Q483
C453 R483 R413
Q489
EP491
Q490
R447 R470
D444 R486
R445
Q441
R457
R469
Q484
C463 R443
C447
R475
C492
D441
R471 C443
R407
R484
Q482
C481
R459
Q481
R453 D401
R444
C462 R468
C448 R495
R478
R460
D442
C444
D481
EP402 D402
R477
CN441
R458 R454
R448 R414
Q485
R403
R456
C413
C409
R401
C486
R482
C454 D446
JW411
R409
R481 C405
C403
JW409
C452
(Page 36)
R487
JW404
JW442 C442
Q487
IC441(2/2) R442
C446
C406
R490
C404 R410
Q488
Q486
C414
D482 R412
R450
C487 R488
C410
R489
R404
CN442
R402
F908 FH916
FH915 CN905
F904 FH908
FH907 FH909
FH910
JW907
CN904
F905
CN903 JW901
FH917 FH912 CN907
FH918
JW908 JW912
F909
JW902
FH911
JW910
S901
JW909
RY901
D901
F906
FH914
FH913 F907
JW925 R908
D908
(Page 37) PT902
JW917
Q902
JW903
C926
C925
C924
C923
C922
C921
C920
C910
R904 D906
EP401
Q442
R476
R446
C402 JW401
R903
CN902
PT901
C908
D903
D902 JW906
CN906 C911
C906
CN901 D905
C909 W901
49
49
D904
JW905
HCD-RG333/RG441
5-26. IC BLOCK DIAGRAMS
SFSY
SBSY
DATA
26
TXO
27
VDD
PIO3
28
CKI
PIO4
29
VSS
PIO5
30
PIO0
PIO6
31
IC251 BA5947FM (BD81A BOARD)
PIO1
PIO7
32
PIO2
WE
IC301 TC94A34FG-002 (BD81A BOARD)
25
24
23
22
21
20
19
18
17
CH4OUTF 20
D
CH3OUTF 21
D
LEVEL SHIFT
D
18 CH1PUTF
D
17 CH1OUTR
D
16 CH2OUTF
D
15 CH2OUTR
Sub code I/F
DIT
Audio I/F
POW VCC (ch1, 2)
50k 50k
50k 50k
POW VCC
GND 25 GND 26
12 GND 11 C-M 10 C-P
CT 28
ALU
round & limit
A3
AY
A2
AX
11 SDO0
MZ
round & limit
A1 A0
MAC
MY
OUTVREF 33
9 VDDT
F
9 VG
R R
INTER FACE
8 CH2RIN
INTER FACE F F
7 CH2FIN
R
100k
10 VSS
CH4CAPA 32
MX
F
CH3FIN 30 CH4IN 31
F
R R
CH3RIN 29
register XO • X1 • X2 Y0 • Y1 • Y2
14 POWVCC 13 CNF4
Vref
MUTE
Y-Bus
X-Bus
C-Pointer register
Vref
PREGND 27
ERAM 2k word
SRMSTB 41
10k
50k 50k
12 BCKO
CRAM 4k word
VDDM 40
MUTE 24
13 LRCKO
CROM 4k word
AD11 39
14 SDI0
PIN26 6.5k
D
POW VCC (ch3, 4)
POWVCC 23
X-Pointer register
CDP Cont I/F
CCE 37
19k
CH3OUTR 22
15 BCKIA
Y-Pointer register
Address Calc. 2sets
BUCK 36
AD12 38
1Mbit SRAM
SRAM I/F
General In/Output Port SRAM/ DRAM I/F
OE 35
D
16 LRCKIA
RAS 33
CAS 34
CH4OUTR 19
6 CH1RIN
INTER FACE
PIN3
5 CH1FIN
F
10k 50k
SW
4 SW 3 OPIN+
DPOUT 34 8 MIACK
Pre Vcc
TREVCC 35
2 OPIN-
NC 36
VDDT 42
1 NC
MCU. I/F
YRAM 4k word
7 MICK
6 MIDIO
Program Control
XRAM 4k word
AD10 43
AD9 44 Bus Switch
5 MILP
IC701 BA6956AN (DRIVER BOARD) IC712 BA6956AN (DRIVER BOARD)
AD8 45
PRAM
POM
AD7 46
Instruction Decoder
4 MICS
TSD
3 STANBY
AD6 47
2 RESET
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
50
50
AD4
AD3
AD2
AD1
AD0
VSS
VDD
CKO
VDDX
XO
XI
VSSX
TEST
MIMD
VSSP
VCOI
1
2
3
4
5
6
7
8
9
RNF
OUT1
VM
VCC
FIN
GND
RIN
1 VDDP
Timing Generator
VC0
OUT2
AD5 48
VREF
CONTROL LOGIC
HCD-RG333/RG441
MNF2
MOUT2
MOUT1
MNF1
BNF1
BOUT1
BOUT2
BNF2
AMS OUT
TONE OUT2
VIN2
TONE OUT1
VIN1
BBIN1
BBNF1
VOLOUT1
IC101 BD3401KS2 (MAIN BOARD)
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
TNF1
BASS
MIDDLE
+ -
+ -
TNF2 49
TREBLE
32 VOLOUT2
+ -
50
31 BBNF2
+ SUR1 51
BASS
MIDDLE
+
TREBLE
30 BBIN2
+ -
SURROUND
29 LF1
SUR2 52
+ -
28 LF2
f
0
LINEOUT1 54
+
27 LF3 BUFFER MIX MIC MIX VOCAL FADER
SAOUT2 55
26 LF4
Di-LIMITER
+ -
fc=100HZ
+ -
LINEOUT2 53
G
ATT
ATT
SAOUT1 56
+
SOFT SWITCH
CAP 57
+ -
25 SWOUT
+ -
24 FILTER
+ -
MIC 58
23 1/2 Vcc
+ -
22 Vcc
GAME R 60
+ -
21 GND
+ -
+ -
GAME L 59
TUNER L 61
20 VDD
19 SI
DIGITAL CONTROL
INPUT SELECTOR
TUNER R 62
+ -
+ -
MD L 63
18 SC
ALC
ALC
17 ALC
TAPE R
PBNF2
PBOUT2
PBOUT1
PBNF1
12
13
14
15
16
RECNF1
TAPE L
11
+ -
CD R
10
VCC
PB SW2
GND
REC SW2
V DD
OE
SO
Q11
Q10
Q9
Q8
Q7
Q6
Q5
12BIT STORAGE RAGESTER OUTPUT BUFFER (Open Drain)
1
2
3
4
5
6
7
8
9
10 Q4
GND
12BIT SHIFT REGESTER
Q3
CONT
11
Q2
PB SW1
12
Q1
9
13
Q0
8
14
LCK
7
15
L. P. F
6
16
CLOCK
5
17
CONTOROL CIRCUIT
4
18
DATA
3
19
N.C.
2
20
V SS
1
GND
IC371 BU2099FV (MAIN BOARD) IC602 BU2099FV (PANEL BOARD)
REC SW1
IC201 BA3126N (MAIN BOARD)
9
RECOUT1
8
RECOUT2
7
RECNF2
6
TAPE B2
5
TAPE B1
4
TAPE A2
3
TAPE A1
+ -
2
+ -
+ -
1
CD L
MD R 64
51
HCD-RG333/RG441 SECTION 6 EXPLODED VIEWS NOTE: • The mechanical parts with no reference number in the exploded views are not supplied. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • -XX and -X mean standardized parts, so they may have some difference from the original one.
• Accessories are given in the last of this parts list. • Abbreviation MX : Mexican model AR : Argentine model E2 : 120 V AC area in E model E51 : Chilean and Peruvian model
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
6-1. MAIN SECTION not supplied
#1
5
b b #1
1
#1
not supplied (VIDEO OUT board)
#1
#1 #1
4
8
#1
CDM74-F1BD81 #1
1
#1 #1
not supplied
#1
3 a
6
FAN901
7 not supplied
#1 TM901
#2
#1
#1 not supplied
1 #1 chassis section
#2
2
not supplied
front panel section
1
#2
Ref. No.
Part No.
Description
1 2 3 4 4
3-363-099-32 4-245-184-71 4-245-183-71 4-252-196-61 4-252-196-71
SCREW (CASE 3 TP2) CASE (SIDE-R) CASE (SIDE-L) DOOR, CD (RG333) DOOR, CD (RG441)
5 6 7 7
4-244-849-71 1-400-285-11 1-769-940-11 1-777-353-11
CASE (TOP) F-BEAD, E2515MRT WIRE (FLAT TYPE) (11 CORE) (RG441) WIRE (FLAT TYPE) (15 CORE) (RG333)
52
Remark
Ref. No.
Part No.
Description
Remark
8 8
X-4956-293-1 SUB TRANS BOARD, COMPLETE (RG333) X-4956-294-1 SUB TRANS BOARD, COMPLETE (RG441:E2,E51,AR) 8 X-4956-322-1 SUB TRANS BOARD, COMPLETE (RG441:MX) FAN901 1-763-117-13 FAN, DC TM901 1-693-615-11 TUNER PACK (FM/AM) (ANTENNA) (RG441) TM901 #1 #2
1-693-616-11 TUNER PACK (FM/AM) (ANTENNA) (RG333) 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
HCD-RG333/RG441
6-2. FRONT PANEL SECTION (1)
51 not supplied (REM board)
55 54 FL601
56 51
53 not supplied (GAME JACK board)
not supplied (LEAD board)
51
not supplied
not supplied
52
51
51
not supplied (H/P JACK board)
Ref. No. 51 52 53 54
Part No.
Description
4-951-620-01 1-796-485-51 1-769-975-11 1-773-048-11
SCREW (2.6X8), +BVTP DECK, MECHANICAL WIRE (FLAT TYPE) (13 CORE) WIRE (FLAT TYPE) (17 CORE)
Remark
Ref. No. 55 55 56 FL601
Part No.
Description
A-4751-547-A A-4751-553-A 1-773-317-11 1-518-976-11
PANEL BOARD, COMPLETE (RG333) PANEL BOARD, COMPLETE (RG441) WIRE (FLAT TYPE) (31 CORE) (RG333) INDICATOR TUBE, FLUORESCENT
Remark
53
HCD-RG333/RG441
6-3. FRONT PANEL SECTION (2)
104 not supplied
105 not supplied
103 101
102
103
Ref. No. 101 102 103
54
Part No.
Description
4-231-841-01 SPRING (HEART CAM-B) 4-231-825-01 CAM (B), HEART 4-224-104-41 DAMPER
Remark
Ref. No. 104 105
Part No.
Description
4-231-824-01 CAM (A), HEART 4-231-836-01 SPRING (HEART CAM-A)
Remark
HCD-RG333/RG441
6-4. FRONT PANEL SECTION (3)
157 156 155 153
not supplied not supplied
not supplied
162 161
160
154 not supplied
159 158 not supplied (6 STREAM LED board)
163 not supplied
not supplied not supplied
153
not supplied
152 not supplied
Ref. No.
Part No.
Description
151 152 153 154 155
4-252-202-01 4-252-201-01 4-951-620-01 4-252-214-01 X-4956-295-1
DOOR (B), CASS DOOR (A), CASS SCREW (2.6X8), +BVTP KNOB, VOLUME RING ASSY, KNOB
156 156
4-252-198-01 WINDOW, DISPLAY (RG441) 4-252-198-11 WINDOW, DISPLAY (RG333)
151
Remark
Ref. No.
Part No.
Description
157 158 159 160 161
4-252-195-31 4-252-205-01 4-252-207-11 4-252-200-01 4-252-208-11
PANEL, FRONT BUTTON, PLAY BUTTON, FF/ALBUM+ COVER, BUTTON BUTTON, FR/ALBUM–
162 163
4-252-206-01 BUTTON, STOP 4-225-252-01 CUSHION (FOOT)
Remark
55
HCD-RG333/RG441
6-5. MAIN BOARD SECTION #4
203 #3
204 not supplied
201
202
209
PT901
203
201
206
not supplied
205 F908
207 208
F905 F904
F906 F907
F909
not supplied
#2 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Ref. No.
Part No.
Description
Ref. No.
Part No.
201 202 202 202 202
4-242-527-01 A-4751-549-A A-4751-555-A A-4752-193-A A-4752-198-A
S-SCREW, ITC+4-8 R AMP BOARD, COMPLETE (RG333) AMP BOARD, COMPLETE (RG441:E2,E51) AMP BOARD, COMPLETE (RG441:MX) AMP BOARD, COMPLETE (RG441:AR)
0 F904
203 204 205 * 205 0 206
4-242-539-01 3-905-609-41 3-703-244-00 3-703-571-12 1-777-071-83
BVIT3B+3-8R W/O SLOT SCREW (TRANSISTOR) BUSHING (2104), CORD (EXCEPT RG441:E2,MX) BUSHING (S) (4516), CORD (RG441:E2,MX) CORD, POWER (RG333,RG441:E51)
0 F905
1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V) (RG441) 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG333) 1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V) (RG441) 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG333) 1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)
0 206 0 206 207 208 208
1-783-941-22 1-827-226-11 4-988-533-01 A-4751-788-A A-4752-183-A
CORD, POWER (RG441:AR) CORD, POWER (RG441:E2,MX) HOLDER, PWB MAIN BOARD, COMPLETE (RG333) MAIN BOARD, COMPLETE (RG441)
209 209 209 209
A-4750-766-A A-4751-524-A A-4752-191-A A-4752-196-A
TRANS BOARD, COMPLETE (RG333) TRANS BOARD, COMPLETE (RG441:E2,E51) TRANS BOARD, COMPLETE (RG441:MX) TRANS BOARD, COMPLETE (RG441:AR)
56
Remark
0 F904 0 F905
0 F906 0 F907 0 F908
Description
Remark
0 PT901 0 PT901
1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V) 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG441) 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG441) 1-443-234-11 TRANSFORMER, POWER (RG333) 1-443-255-11 TRANSFORMER, POWER (RG441:E2,E51,AR)
0 PT901 #2 #3 #4
1-443-294-11 7-685-646-79 7-685-649-79 7-685-881-09
0 F909
TRANSFORMER, POWER (RG441:MX) SCREW +BVTP 3X8 TYPE2 IT-3 SCREW +BVTP 3X14 TYPE2 IT-3 SCREW +BVTT 4X8 (S)
HCD-RG333/RG441
6-6. CD MECHANISM SECTION (1) (CDM74-F1BD81)
256
262
258
251 256
257 256
257
263
259
258 261
264 264 265
260
255 255
M741
252 254 253 266 CD mechanism deck section-2
251
Ref. No.
Part No.
Description
251 252 253 254 255
4-218-253-21 1-776-182-11 1-687-134-12 4-243-815-01 4-245-571-02
SCREW (M2.6), +BTTP WIRE (FLAT TYPE) (5 CORE) MOTOR (TB) BOARD TABLE (LOADING) GEAR (STOPPER)
256 257 258 259
4-218-252-61 4-245-570-01 4-245-572-01 1-687-132-12
SCREW (+PTPWH M2.6), FLOATING GEAR (JOINT) BUSHING (GEAR) SENSOR BOARD
Remark
Ref. No.
Part No.
Description
260 261 262 263 264
4-243-820-01 4-243-819-01 4-243-816-01 4-243-823-01 4-985-672-01
GEAR (TABLE) GEAR (GENEVA) TRAY BELT (TABLE) SCREW (+PTPWH M2.6), FLOATING
265 266 M741
4-243-821-01 PULLEY (TABLE) 3-231-598-01 SHEET (BA) A-4723-963-A MOTOR ASSY, TABLE (TBL)
Remark
57
HCD-RG333/RG441
6-7. CD MECHANISM SECTION (2) (CDM74-F1BD81)
315
308
316
308 319 317
314
320 308 318
313
322
321
323
RE701
304 308
312 325
308 324
328 M751
301
325
325
324
324 326
311 309
325 324
326
310
302
304
303
308
327
329 330
305
307 not supplied (CONNECT board)
not supplied
FC901
306
327
326
S101
304
332
331
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Ref. No.
Part No.
Description
301 302 303 304 305
1-471-035-11 X-4955-707-2 1-687-135-12 4-218-253-31 A-4751-431-A
MAGNET ASSY PULLEY (A5) ASSY, CHUCKING DRIVER BOARD +BTTP M2.6 BD81A BOARD, COMPLETE
306 307 308 309 310
4-951-620-01 4-244-034-01 4-218-252-61 4-225-844-01 1-687-669-12
SCREW (2.6X8), +BVTP BELT (LOADING) SCREW (+PTPWH M2.6), FLOATING GEAR (LOADING A) SW BOARD
311 312 313 314 315
4-224-613-01 1-687-133-12 4-244-108-01 4-224-609-01 4-224-608-01
GEAR (SHAFT) MOTOR (LD) BOARD GEAR, SWING GEAR (LOADING C) COLLAR, SWING
316 317 318
3-016-533-11 WASHER (FR), STOPPER 4-224-611-01 GEAR (LOADING B) 4-224-606-01 GEAR (RV)
58
Remark
Ref. No.
Part No.
Description
Remark
319 320 321 322 323
4-243-818-01 4-243-822-02 4-243-817-01 4-231-189-01 X-4955-536-1
GEAR (U/D) LEVER (LIFTER) CHASSIS PULLEY (B), CHUCKING HOLDER (213) ASSY
324 325 326 327 0 328
4-227-045-31 4-227-549-11 4-231-151-01 4-218-253-31 8-820-244-01
SPRING (INSULATOR), COIL INSULATOR STOPPER (BU) +BTTP M2.6 OPTICAL PICK-UP (KSM-215DCP/C2RP)
329 330 331 332 FC901
1-827-992-11 1-775-251-11 4-951-620-01 4-985-672-01 1-469-854-11
WIRE (FLAT TYPE) (16 CORE) WIRE (FLAT TYPE) (27 CORE) SCREW (2.6X8), +BVTP SCREW (+PTPWH M2.6), FLOATING CORE, FERRITE
M751 RE701 S101
A-4736-655-A MOTOR ASSY, LOADING (LOADING) 1-477-680-12 ENCODER, ROTARY 1-771-853-11 SWITCH, DETECTION (LIMIT)
HCD-RG333/RG441 SECTION 7 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Ref. No.
• SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. • CAPACITORS uF : µF • COILS uH : µH • Abbreviation MX : Mexican model AR : Argentine model E2 : 120 V AC area in E model E51 : Chilean and Peruvian model
Part No.
Description
Remark
A-4751-549-A A-4751-555-A A-4752-193-A A-4752-198-A
AMP BOARD, COMPLETE (RG333) AMP BOARD, COMPLETE (RG441:E2,E51) AMP BOARD, COMPLETE (RG441:MX) AMP BOARD, COMPLETE (RG441:AR) *********************
Ref. No.
AMP The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board.
Part No.
Description
Remark
C452 C453 C454 C455
1-136-497-81 1-136-497-81 1-136-497-81 1-136-497-81
FILM FILM FILM FILM
0.1uF 0.1uF 0.1uF 0.1uF
5% 5% 5% 5%
C456
1-136-497-81 FILM
0.1uF
5%
C457
1-136-497-81 FILM
0.1uF
5%
C458
1-136-497-81 FILM
0.1uF
5%
C459
1-162-294-31 CERAMIC
0.001uF
10%
C460
1-162-294-31 CERAMIC
0.001uF
10%
C461
1-128-562-11 ELECT
47uF
20%
C462
1-128-562-11 ELECT
47uF
20%
C463
1-104-655-91 ELECT
470uF
20%
C481 C486 C487
1-104-658-91 ELECT 1-126-961-11 ELECT 1-126-963-11 ELECT
100uF 2.2uF 4.7uF
20% 20% 20%
C488
1-126-965-11 ELECT
22uF
20%
50V (RG441) 50V (RG441) 50V (RG441) 50V 50V
C489
1-128-563-11 ELECT
100uF
20%
C491
1-162-294-31 CERAMIC
0.001uF
10%
C492
1-162-306-11 CERAMIC
0.01uF
20%
CN441
7-685-872-09 SCREW +BVTT 3X8 (S) < CAPACITOR > C402 C403 C404 C405
1-162-306-11 1-137-749-11 1-137-749-11 1-127-813-11
CERAMIC MYLAR MYLAR ELECT
C405
1-135-516-11 ELECT
0.01uF 0.1uF 0.1uF 3300uF
20%
20%
3300uF
20%
C406
1-127-813-11 ELECT
3300uF
20%
C406
1-135-516-11 ELECT
3300uF
20%
C407
1-162-306-11 CERAMIC
0.01uF
20%
C408
1-162-306-11 CERAMIC
0.01uF
20%
C409
1-127-811-11 ELECT
3300uF
20%
16V 100V 100V 71V (RG441) 63V (RG333) 71V (RG441) 63V (RG333) 16V (RG333) 16V (RG333) 50V (RG441)
C410
1-127-811-11 ELECT
3300uF
20%
C413
1-136-497-81 FILM
0.1uF
5%
C414
1-136-497-81 FILM
0.1uF
5%
C441 C442
1-126-964-11 ELECT 1-126-964-11 ELECT
10uF 10uF
20% 20%
C443 C444 C445 C446 C447
1-162-294-31 1-162-294-31 1-162-282-31 1-162-282-31 1-126-965-11
0.001uF 0.001uF 100PF 100PF 22uF
10% 10% 10% 10% 20%
50V 50V 50V 50V 50V (RG333)
C447
1-126-967-11 ELECT
47uF
20%
C448
1-126-965-11 ELECT
22uF
20%
C448
1-126-967-11 ELECT
47uF
20%
C451
1-136-497-81 FILM
0.1uF
5%
50V (RG441) 50V (RG333) 50V (RG441) 50V
CERAMIC CERAMIC CERAMIC CERAMIC ELECT
50V 50V 50V 50V (RG333) 50V (RG333) 50V (RG333) 50V (RG333) 50V (RG333) 50V (RG333) 100V (RG441) 100V (RG441) 6.3V (RG441) 10V 50V 50V 50V (RG333) 100V (RG333) 50V (RG333) 16V (RG441)
< CONNECTOR > 1-778-981-21 CONNECTOR, BOARD TO BOARD 13P < DIODE > D401 D402 D441 D442 D443
6-500-360-01 6-500-360-01 8-719-991-33 8-719-991-33 8-719-991-33
DIODE DIODE DIODE DIODE DIODE
D10XB20 D10XB20 (RG441) 1SS133T-77 1SS133T-77 1SS133T-77
D444 D445 D446 D481
8-719-991-33 8-719-947-65 8-719-947-65 8-719-991-33
DIODE DIODE DIODE DIODE
1SS133T-77 (RG441) MTZJ-T-72-16B (RG441) MTZJ-T-72-16B (RG441) 1SS133T-77
59
HCD-RG333/RG441 AMP Ref. No. D482 D483
Part No.
Description
Remark
8-719-991-33 DIODE 1SS133T-77 8-719-991-33 DIODE 1SS133T-77 (RG333)
Ref. No.
Part No.
Description
Remark
R444
1-247-871-91 CARBON
47K
5%
R444
1-247-873-91 CARBON
56K
5%
R445 R446 R447
1-247-831-91 CARBON 1-247-831-91 CARBON 1-247-871-91 CARBON
1K 1K 47K
5% 5% 5%
R447
1-247-873-91 CARBON
56K
5%
R448
1-247-871-91 CARBON
47K
5%
R448
1-247-873-91 CARBON
56K
5%
0 R449
1-217-156-00 METAL
0.22
10%
0 R450
1-217-156-00 METAL
0.22
10%
0 R451
1-217-156-00 METAL
0.22
10%
0 R452
1-217-156-00 METAL
0.22
10%
R453 R454 R455
1-260-076-11 CARBON 1-260-076-11 CARBON 1-247-831-91 CARBON
10 10 1K
5% 5% 5%
R456 R457
1-247-831-91 CARBON 1-249-431-11 CARBON
1K 15K
5% 5%
R457
1-247-863-91 CARBON
22K
5%
R458
1-249-431-11 CARBON
15K
5%
R458
1-247-863-91 CARBON
22K
5%
R459
1-247-871-91 CARBON
47K
5%
R459
1-247-879-91 CARBON
100K
5%
R460
1-247-871-91 CARBON
47K
5%
R460
1-247-879-91 CARBON
100K
5%
R461
1-260-076-11 CARBON
10
5%
R462 R463
1-260-076-11 CARBON 1-260-076-11 CARBON
10 10
5% 5%
R464
1-260-076-11 CARBON
10
5%
R465 R466
1-247-871-91 CARBON 1-247-873-91 CARBON
47K 56K
5% 5%
1-215-872-11 METAL OXIDE
3.3K
5%
1-249-435-11 CARBON
33K
5%
1-215-872-11 METAL OXIDE
3.3K
5%
R469
1-249-435-11 CARBON
33K
5%
R470
1-249-435-11 CARBON
33K
5%
R471
1-249-439-11 CARBON
68K
5%
< GROUND TERMINAL BOARD > EP401 EP402 EP491
1-537-771-21 TERMINAL BOARD, GROUND 1-537-771-21 TERMINAL BOARD, GROUND 1-537-771-21 TERMINAL BOARD, GROUND (RG441) < IC >
IC441 IC441
6-600-169-01 IC STK412-240 (RG441) 6-600-221-01 IC STK403-130 (RG333) < TERMINAL BOARD >
JK441
1-694-884-11 TERMINAL BOARD (4P) (SPEAKER) < COIL >
L441 L441 L442 L442
1-422-009-13 1-422-009-13 1-422-009-13 1-422-009-13
COIL, AIR-CORE (RG441) COIL, AIR-CORE (RG333) COIL, AIR-CORE (RG441) COIL, AIR-CORE (RG333) < TRANSISTOR >
Q441 Q442 Q481 Q482 Q483
8-729-140-84 8-729-140-84 8-729-119-79 8-729-119-79 8-729-119-79
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC1841-PAFAEA 2SC1841-PAFAEA 2SC2785-FEK 2SC2785-FEK 2SC2785-FEK
Q484 Q485 Q486 Q487 Q488
8-729-119-79 8-729-119-76 8-729-119-79 8-729-119-79 8-729-119-79
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2785-FEK 2SA1175-HFE 2SC2785-FEK 2SC2785-FEK 2SC2785-FEK
Q489 Q490 Q491
8-729-140-84 TRANSISTOR 2SC1841-PAFAEA 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA (RG441) 8-729-821-00 TRANSISTOR 2SA1207 (RG441) < RESISTOR >
R401 R402 R403
1-247-879-91 CARBON 1-247-879-91 CARBON 1-247-879-91 CARBON
100K 100K 100K
5% 5% 5%
R404
1-247-879-91 CARBON
100K
5%
R407
1-260-316-51 CARBON
100
5%
R409
1-247-879-91 CARBON
100K
5%
R410
1-247-879-91 CARBON
100K
5%
R411 R412 R413
1-249-421-11 CARBON 1-249-421-11 CARBON 1-247-847-91 CARBON
2.2K 2.2K 4.7K
5% 5% 5%
R414 R441 R442 R443
1-247-847-91 1-247-831-91 1-247-831-91 1-247-871-91
CARBON CARBON CARBON CARBON
4.7K 1K 1K 47K
5% 5% 5% 5%
R443
1-247-873-91 CARBON
56K
5%
1/4W 1/4W 1/4W (RG441) 1/4W (RG441) 1/2W 1/4W (RG441) 1/4W (RG441) 1/4W 1/4W 1/4W
0 R467 R467 0 R468
60
1/4W 1/4W 1/4W 1/4W (RG333) 1/4W (RG441)
1/4W (RG333) 1/4W (RG441) 1/4W 1/4W 1/4W (RG333) 1/4W (RG441) 1/4W (RG333) 1/4W (RG441) 5W F (RG441) 5W F (RG441) 5W F (RG333) 5W F (RG333) 1/2W 1/2W 1/4W 1/4W 1/4W (RG441) 1/4W (RG333) 1/4W (RG441) 1/4W (RG333) 1/4W (RG333) 1/4W (RG441) 1/4W (RG333) 1/4W (RG441) 1/2W 1/2W 1/2W (RG333) 1/2W (RG333) 1/4W 1/4W 1W F (RG441) 1/4W (RG333) 1W F (RG441) 1/4W (RG441) 1/4W (RG441) 1/4W (RG441)
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
HCD-RG333/RG441 AMP Ref. No.
Part No.
Description
Remark
R472
1-249-435-11 CARBON
33K
5%
R473
1-247-863-91 CARBON
22K
5%
R474
1-249-421-11 CARBON
2.2K
5%
R475
1-249-429-11 CARBON
10K
5%
R476
1-249-431-11 CARBON
15K
5%
1/4W (RG441) 1/4W (RG441) 1/4W (RG441) 1/4W (RG441) 1/4W (RG441)
0 R477
1-212-881-11 FUSIBLE
100
5%
R478
1-249-429-11 CARBON
10K
5%
R481 R482 R483
1-247-847-91 CARBON 1-249-429-11 CARBON 1-247-791-91 CARBON
4.7K 10K 22
5% 5% 5%
1/4W F (RG441) 1/4W (RG441) 1/4W 1/4W 1/4W
R484 R485 R486 R487 R488
1-247-873-91 1-247-879-91 1-247-879-91 1-249-435-11 1-247-863-91
CARBON CARBON CARBON CARBON CARBON
56K 100K 100K 33K 22K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R489 R490 R491
1-247-847-91 CARBON 1-247-847-91 CARBON 1-247-863-91 CARBON
4.7K 4.7K 22K
5% 5% 5%
R492
1-247-831-91 CARBON
1K
5%
R493
1-249-435-11 CARBON
33K
5%
1/4W 1/4W 1/4W (RG333) 1/4W (RG333) 1/4W (RG333)
R494
1-249-421-11 CARBON
2.2K
5%
0 R495 0 R496
1-202-972-61 FUSIBLE 1-212-881-11 FUSIBLE
1 100
5% 5%
1/4W (RG333) 1/4W F 1/4W F
< RELAY > RY441 RY441
1-755-372-11 RELAY (RG441) 1-755-373-11 RELAY (RG333) < THERMISTOR >
TH441 1-807-796-11 THERMISTOR ************************************************************* A-4751-431-A BD81A BOARD, COMPLETE ********************** < CAPACITOR >
Ref. No.
BD81A
Part No.
Description
C122 C123 C124 C125 C131
1-107-826-11 1-107-826-11 1-162-959-11 1-164-360-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 330PF 0.1uF 100PF
10% 10% 5%
Remark
C132 C133 C134 C141 C142
1-117-863-11 1-162-970-11 1-164-360-11 1-107-826-11 1-162-965-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.47uF 0.01uF 0.1uF 0.1uF 0.0015uF
10% 10%
C143 C151 C161 C162 C163
1-164-360-11 1-128-995-21 1-164-360-11 1-164-360-11 1-164-360-11
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 100uF 0.1uF 0.1uF 0.1uF
C171 C172 C174 C181 C182
1-162-919-11 1-162-920-11 1-164-360-11 1-164-360-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
22PF 27PF 0.1uF 0.1uF 0.1uF
5% 5%
50V 50V 16V 16V 16V
C183 C184 C185 C186 C194
1-124-778-00 1-124-778-00 1-164-315-11 1-164-315-11 1-164-360-11
ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
22uF 22uF 470PF 470PF 0.1uF
20% 20% 5% 5%
6.3V 6.3V 50V 50V 16V
C195 C196 C201 C203 C209
1-164-360-11 1-164-360-11 1-128-995-21 1-128-995-21 1-162-970-11
CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP
0.1uF 0.1uF 100uF 100uF 0.01uF
20% 20% 10%
16V 16V 10V 10V 25V
C210 C211 C212 C213 C251
1-107-826-11 1-164-230-11 1-162-919-11 1-162-919-11 1-162-969-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 220PF 22PF 22PF 0.0068uF
10% 5% 5% 5% 10%
16V 50V 50V 50V 25V
C252 C255 C257 C258 C259
1-164-360-11 1-164-360-11 1-164-360-11 1-164-360-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
C260 C302 C303 C305 C306
1-128-394-11 1-164-360-11 1-164-360-11 1-126-246-11 1-164-360-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
220uF 0.1uF 0.1uF 220uF 0.1uF
5%
10% 10%
20%
16V 16V 50V 16V 50V 6.3V 25V 16V 16V 50V 16V 10V 16V 16V 16V
16V 16V 16V 16V 16V 20%
20%
10V 16V 16V 4V 16V
C10 C11 C14 C15 C16
1-165-989-11 1-165-989-11 1-164-360-11 1-164-360-11 1-115-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
10uF 10uF 0.1uF 0.1uF 1uF
10% 10%
6.3V 6.3V 16V 16V 10V
C307 C308 C309 C310 C311
1-164-360-11 1-126-208-21 1-164-360-11 1-164-360-11 1-164-360-11
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 47uF 0.1uF 0.1uF 0.1uF
C17 C18 C111 C112 C113
1-126-246-11 1-162-964-11 1-162-967-11 1-164-315-11 1-162-967-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
220uF 0.001uF 0.0033uF 470PF 0.0033uF
20% 10% 10% 5% 10%
4V 50V 50V 50V 50V
C312 C313 C314 C315 C316
1-164-360-11 1-164-360-11 1-126-208-21 1-107-826-11 1-162-966-11
CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 47uF 20% 0.1uF 10% 0.0022uF 10%
16V 16V 4V 16V 50V
C114 C115 C116
1-164-315-11 CERAMIC CHIP 1-164-360-11 CERAMIC CHIP 1-128-995-21 ELECT CHIP
470PF 0.1uF 100uF
5%
50V 16V 10V
C317 C318 C320
1-162-970-11 CERAMIC CHIP 1-162-970-11 CERAMIC CHIP 1-216-864-11 SHORT CHIP
0.01uF 0.01uF 0
25V 25V
20%
20%
10% 10%
16V 4V 16V 16V 16V
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
61
HCD-RG333/RG441 BD81A Ref. No.
CONNECT
Part No.
DRIVER
Description
Remark
< CONNECTOR > CN101 CN201
1-770-425-11 CONNECTOR, FFC/FPC 16P 1-818-350-11 CONNECTOR (FFC) 27P
Ref. No.
Part No.
Description
R351 R352 R353 R354 R401
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
Remark 1/10W 1/10W 1/10W 1/10W 1/10W
R402 R403 R404 R405 R406
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R407 R408 R409 R410 R411
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R412 R419
1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP
100 100
5% 5%
1/10W 1/10W
< FERRITE BEAD > FB301
1-500-445-21 FERRITE, EMI (SMD) (2012) < IC >
IC101 IC251 IC301 IC303
8-752-425-12 6-705-808-01 6-705-365-01 6-705-807-01
IC IC IC IC
CXD3059AR BA5947FM TC94A34FG-002 BH15FB1WG
< TRANSISTOR > Q10
6-550-363-01 TRANSISTOR 2SB1690KT146 < RESISTOR >
< VIBRATOR > R10 R11 R12 R13 R111
1-216-791-11 1-216-864-11 1-216-845-11 1-218-446-11 1-216-821-11
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
3.3 0 100K 1 1K
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
R112 R113 R114 R121 R131
1-216-835-11 1-216-821-11 1-216-835-11 1-216-835-11 1-216-857-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
15K 1K 15K 15K 1M
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R132 R133 R141 R142 R143
1-216-833-11 1-216-848-11 1-216-829-11 1-216-821-11 1-216-827-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 180K 4.7K 1K 3.3K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R151 R161 R162 R163 R165
1-216-864-11 1-216-809-11 1-216-841-11 1-216-809-11 1-216-864-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
0 100 47K 100 0
R171 R172 R173 R181 R182
1-216-817-11 1-216-857-11 1-216-295-91 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
470 1M 0 100 100
R191 R201 R203 R204 R205
1-216-864-11 1-500-445-21 1-216-864-11 1-500-445-21 1-216-864-11
SHORT CHIP 0 FERRITE, EMI (SMD) (2012) SHORT CHIP 0 FERRITE, EMI (SMD) (2012) SHORT CHIP 0
R251 R252 R253 R301 R302
1-216-833-11 1-216-837-11 1-216-833-11 1-216-845-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 22K 10K 100K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C715 C731 C735 C736 C737
1-126-933-11 1-126-964-11 1-164-159-21 1-164-159-21 1-164-159-21
ELECT ELECT CERAMIC CERAMIC CERAMIC
100uF 10uF 0.1uF 0.1uF 0.1uF
20% 20%
16V 50V 50V 50V 50V
R303 R305 R306 R307 R313
1-216-845-11 1-216-845-11 1-216-864-11 1-216-833-11 1-216-813-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
100K 100K 0 10K 220
5% 5%
1/10W 1/10W
C741 C751 C752
1-162-306-11 CERAMIC 1-162-306-11 CERAMIC 1-164-159-21 CERAMIC
0.01uF 0.01uF 0.1uF
20% 20%
16V 16V 50V
5% 5%
1/10W 1/10W
X171 1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz) ************************************************************* CONNECT BOARD *************** < CAPACITOR > C871 C872 C873 C874 C875
1-162-927-11 1-162-970-11 1-162-927-11 1-164-315-11 1-164-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
C876
1-164-156-11 CERAMIC CHIP
100PF 0.01uF 100PF 470PF 0.1uF
5% 10% 5% 5%
0.1uF
50V 25V 50V 50V 25V 25V
< CONNECTOR > 5% 5% 5%
1/10W 1/10W 1/10W
5% 5%
1/10W 1/10W
5% 5%
1/10W 1/10W
CN871 CN873 * CN874
1-779-295-11 CONNECTOR, FFC (LIF(NON-ZIF)) 27P 1-784-778-11 CONNECTOR, FFC 17P 1-564-725-11 PIN, CONNECTOR (SMALL TYPE) 9P < JUMPER RESISTOR >
62
FB871 1-216-864-11 SHORT CHIP 0 FB872 1-216-864-11 SHORT CHIP 0 JR871 1-216-864-11 SHORT CHIP 0 JR872 1-216-864-11 SHORT CHIP 0 ************************************************************* 1-687-135-12 DRIVER BOARD ************* < CAPACITOR >
HCD-RG333/RG441 DRIVER Ref. No.
Part No.
Description
GAME JACK Remark
Ref. No.
H/P JACK
Part No.
1-785-338-11 1-784-766-11 1-564-720-11 1-785-328-11
PIN, CONNECTOR (LIGHT ANGLE) 12P CONNECTOR, FFC 5P PIN, CONNECTOR (SMALL TYPE) 4P PIN, CONNECTOR (LIGHT ANGLE) 2P
C830 C831 C832
1-162-964-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP
0.001uF 0.001uF 0.1uF
10% 10%
50V 50V 25V
J801 1-793-829-11 JACK, HEADPHONE (PHONES) ************************************************************* LEAD BOARD (RG333) ***********
8-759-598-69 IC BA6956AN 8-759-598-69 IC BA6956AN
< CAPACITOR >
< TRANSISTOR > Q731
Remark
< JACK >
8-719-921-42 DIODE MTZJ-5.1A 8-719-109-69 DIODE RD3.6ESB2 < IC >
IC701 IC712
Description
< CAPACITOR >
< DIODE > D701 D711
MAIN
H/P JACK BOARD **************
< CONNECTOR > CN701 CN702 * CN703 CN704
LEAD
C861
8-729-029-66 TRANSISTOR DTC114ESA
1-162-964-11 CERAMIC CHIP
0.001uF
10%
50V (RG333)
< RESISTOR > < GROUND TERMINAL BOARD > R701 R702 R711 R712 R713
1-249-413-11 1-247-807-31 1-249-417-11 1-249-425-11 1-249-433-11
CARBON CARBON CARBON CARBON CARBON
470 100 1K 4.7K 22K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R721 R722 R723 R731 R732
1-249-425-11 1-249-425-11 1-249-425-11 1-247-807-31 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
4.7K 4.7K 4.7K 100 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
EP802 1-537-771-21 TERMINAL BOARD, GROUND (RG333) ************************************************************* A-4751-788-A MAIN BOARD, COMPLETE (RG333) A-4752-183-A MAIN BOARD, COMPLETE (RG441) ********************* 7-685-872-09 SCREW +BVTT 3X8 (S) < CAPACITOR >
R733 1-249-417-11 CARBON 1K 5% 1/4W R734 1-249-430-11 CARBON 12K 5% 1/4W R735 1-247-807-31 CARBON 100 5% 1/4W R751 1-249-425-11 CARBON 4.7K 5% 1/4W *************************************************************
C101 C102 C103 C104 C105
1-126-960-11 1-126-960-11 1-126-956-91 1-126-956-91 1-164-816-11
ELECT ELECT ELECT ELECT CERAMIC CHIP
1uF 1uF 0.1uF 0.1uF 220PF
20% 20% 20% 20% 2%
50V 50V 50V 50V 50V
GAME JACK BOARD ****************
C106 C107 C108 C109 C110
1-131-679-31 1-126-964-11 1-164-816-11 1-131-679-31 1-126-964-11
FILM ELECT CERAMIC CHIP FILM ELECT
0.01uF 10uF 220PF 0.01uF 10uF
5% 20% 2% 5% 20%
50V 50V 50V 50V 50V
C111 C112 C113 C114 C115
1-126-960-11 1-126-960-11 1-126-960-11 1-126-960-11 1-131-679-31
ELECT ELECT ELECT ELECT FILM
1uF 1uF 1uF 1uF 0.01uF
20% 20% 20% 20% 5%
50V 50V 50V 50V 50V
C116 C117 C118 C119 C120
1-164-816-11 1-164-816-11 1-126-964-11 1-131-679-31 1-164-816-11
CERAMIC CHIP CERAMIC CHIP ELECT FILM CERAMIC CHIP
220PF 220PF 10uF 0.01uF 220PF
2% 2% 20% 5% 2%
50V 50V 50V 50V 50V
C121 C122 C123 C124 C125
1-164-816-11 1-126-964-11 1-126-965-91 1-162-953-11 1-162-953-11
CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP
220PF 10uF 22uF 100PF 100PF
2% 20% 20% 5% 5%
50V 50V 50V 50V 50V
C126 C127 C128 C129
1-165-112-11 1-104-658-91 1-104-658-91 1-126-947-11
CERAMIC CHIP ELECT ELECT ELECT
0.33uF 100uF 100uF 47uF
20% 20% 20%
16V 10V 10V 35V
< CAPACITOR > C801 C802 C803 C804
1-162-962-11 1-162-962-11 1-165-128-11 1-165-128-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
470PF 470PF 0.22uF 0.22uF
10% 10%
50V 50V 16V 16V
< JACK > J804
1-815-684-11 JACK, PIN 3P (GAME INPUT) < JUMPER RESISTOR >
JR801
1-216-864-11 SHORT CHIP
0
< RESISTOR > R801 1-216-833-11 METAL CHIP 10K 5% 1/10W R802 1-216-833-11 METAL CHIP 10K 5% 1/10W R803 1-216-837-11 METAL CHIP 22K 5% 1/10W R804 1-216-837-11 METAL CHIP 22K 5% 1/10W *************************************************************
63
HCD-RG333/RG441 MAIN Ref. No.
Part No.
Description
Part No.
Description
C132 C135 C136 C137 C138
1-126-947-11 1-131-690-31 1-131-690-31 1-126-964-11 1-126-964-11
ELECT FILM FILM ELECT ELECT
47uF 0.068uF 0.068uF 10uF 10uF
20% 5% 5% 20% 20%
35V 50V 50V 50V 50V
Remark
C229 C230 C235 C241 C242
1-126-963-11 1-126-947-11 1-164-156-11 1-162-964-11 1-130-479-00
ELECT ELECT CERAMIC CHIP CERAMIC CHIP MYLAR
4.7uF 47uF 0.1uF 0.001uF 0.0047uF
20% 20% 10% 5%
50V 35V 25V 50V 50V
C139 C140 C141 C142 C143
1-131-690-31 1-131-690-31 1-126-964-11 1-126-964-11 1-126-960-11
FILM FILM ELECT ELECT ELECT
0.068uF 0.068uF 10uF 10uF 1uF
5% 5% 20% 20% 20%
50V 50V 50V 50V 50V
C243 C244 C246 C248 C249
1-131-681-31 1-131-681-31 1-131-681-31 1-162-964-11 1-126-964-11
FILM FILM FILM CERAMIC CHIP ELECT
0.015uF 0.015uF 0.015uF 0.001uF 10uF
5% 5% 5% 10% 20%
50V 50V 50V 50V 50V
C144 C145 C146 C147 C148
1-136-165-00 1-126-964-11 1-136-165-00 1-126-964-11 1-131-679-31
FILM ELECT FILM ELECT FILM
0.1uF 10uF 0.1uF 10uF 0.01uF
5% 20% 5% 20% 5%
50V 50V 50V 50V 50V
C250 C251 C252 C253 C258
1-126-947-11 1-126-947-11 1-126-933-11 1-126-956-91 1-126-959-11
ELECT ELECT ELECT ELECT ELECT
47uF 47uF 100uF 0.1uF 0.47uF
20% 20% 20% 20% 20%
35V 35V 16V 50V 50V
C149 C150 C151 C152 C153
1-131-679-31 1-131-679-31 1-131-679-31 1-130-475-00 1-130-475-00
FILM FILM FILM MYLAR MYLAR
0.01uF 0.01uF 0.01uF 0.0022uF 0.0022uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C259 C264 C265 C266 C267
1-126-957-11 1-162-971-11 1-162-971-11 1-162-971-11 1-162-971-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.22uF 0.001uF 0.001uF 0.001uF 0.001uF
20% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C154 C157 C159 C160 C161
1-131-700-31 1-126-960-11 1-126-960-11 1-126-960-11 1-162-971-11
FILM ELECT ELECT ELECT CERAMIC CHIP
0.47uF 1uF 1uF 1uF 0.001uF
5% 20% 20% 20% 10%
50V 50V 50V 50V 50V (RG333)
C270 C271
1-126-964-11 ELECT 1-162-971-11 CERAMIC CHIP
10uF 0.001uF
20% 10%
C272
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C274 C275
1-162-949-11 CERAMIC CHIP 1-162-949-11 CERAMIC CHIP
47PF 47PF
5% 5%
50V 50V (RG333) 50V (RG333) 50V 50V
C276
1-164-362-11 CERAMIC CHIP
470PF
5%
C277
1-164-362-11 CERAMIC CHIP
470PF
5%
C278
1-164-362-11 CERAMIC CHIP
470PF
5%
C279
1-164-362-11 CERAMIC CHIP
470PF
5%
C280
1-164-362-11 CERAMIC CHIP
470PF
5%
C281
1-164-362-11 CERAMIC CHIP
470PF
5%
C288
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C289
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C290
1-162-971-11 CERAMIC CHIP
0.001uF
10%
C301
1-136-165-00 FILM
0.1uF
5%
50V (RG333) 50V (RG333) 50V (RG333) 50V (RG333) 50V
C302 C303 C304 C305 C306
1-136-165-00 1-136-165-00 1-136-165-00 1-136-165-00 1-136-165-00
FILM FILM FILM FILM FILM
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C308 C309 C310 C311 C312
1-126-965-91 1-126-965-91 1-126-936-11 1-126-964-11 1-126-964-11
ELECT ELECT ELECT ELECT ELECT
22uF 22uF 3300uF 10uF 10uF
20% 20% 20% 20% 20%
50V 50V 16V 50V 50V
C313 C315 C316 C318
1-126-943-11 1-126-933-11 1-126-943-11 1-126-933-11
ELECT ELECT ELECT ELECT
2200uF 100uF 2200uF 100uF
20% 20% 20% 20%
25V 16V 25V 16V
C162 C163
1-126-960-11 ELECT 1-162-971-11 CERAMIC CHIP
1uF 0.001uF
20% 10%
C164 C165 C166
1-126-960-11 ELECT 1-126-960-11 ELECT 1-126-960-11 ELECT
1uF 1uF 1uF
20% 20% 20%
50V 50V (RG333) 50V 50V 50V
C175 C176 C177 C178 C179
1-109-953-11 1-126-964-11 1-162-945-11 1-126-947-11 1-162-949-11
ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP
2.2uF 10uF 22PF 47uF 47PF
20% 20% 5% 20% 5%
50V 50V 50V 35V 50V
C181 C183 C184 C185 C186
1-162-949-11 1-162-945-11 1-126-947-11 1-126-964-11 1-126-947-11
CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT
47PF 22PF 47uF 10uF 47uF
5% 5% 20% 20% 20%
50V 50V 35V 50V 35V
C187 C188 C189 C190 C191
1-162-974-11 1-126-965-91 1-126-965-91 1-162-974-11 1-126-961-11
CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT
0.01uF 22uF 22uF 0.01uF 2.2uF
C192 C193 C206 C211 C212
1-126-961-11 1-162-966-11 1-162-966-11 1-109-953-11 1-126-964-11
ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT
C213 C214 C216 C217 C222
1-126-964-11 1-126-926-11 1-164-156-11 1-164-156-11 1-164-156-11
ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
C228
1-164-156-11 CERAMIC CHIP
64
20%
50V 50V 50V 50V 50V
2.2uF 0.0022uF 0.0022uF 2.2uF 10uF
20% 10% 10% 20% 20%
50V 50V 50V 50V 50V
10uF 1000uF 0.1uF 0.1uF 0.1uF
20% 20%
50V 10V 25V 25V 25V
0.1uF
20% 20%
25V
Ref. No.
Remark
50V (RG333) 50V (RG333) 50V (RG333) 50V (RG333) 50V (RG333)
HCD-RG333/RG441 MAIN Ref. No.
Part No.
Description
C321 C342 C351 C352 C353
1-126-961-11 1-164-156-11 1-164-357-11 1-126-965-91 1-126-961-11
ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT
2.2uF 0.1uF 0.001uF 22uF 2.2uF
Remark
C354 C371 C372 C373 C374
1-164-156-11 1-164-362-11 1-162-953-11 1-162-953-11 1-126-947-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
C375 C376
1-164-156-11 CERAMIC CHIP 1-126-961-11 ELECT
20% 5% 20% 20%
50V 25V 50V 50V 50V
0.1uF 470PF 100PF 100PF 47uF
5% 5% 5% 20%
25V 50V 50V 50V 35V
0.1uF 2.2uF
20%
25V 50V
< CONNECTOR > CN101 CN101 * CN103 * CN112 CN302
1-568-830-11 1-784-776-11 1-564-710-11 1-564-705-11 1-568-844-11
CONNECTOR, FFC 11P (RG441) CONNECTOR, FFC 15P (RG333) PIN, CONNECTOR (SMALL TYPE) 8P PIN, CONNECTOR (SMALL TYPE) 3P CONNECTOR, FFC 29P (RG441)
CN302 CN307 CN308 CN309 CN314
1-784-792-11 1-778-982-21 1-564-506-11 1-564-707-11 1-564-506-11
CONNECTOR, FFC 31P (RG333) CONNECTOR, BOARD TO BOARD 13P PLUG, CONNECTOR 3P PIN, CONNECTOR (SMALL TYPE) 5P PLUG, CONNECTOR 3P
Ref. No.
Part No.
Description
Remark
< JUMPER RESISTOR > FB201 FB202 FB203 FB204 FB205
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0 (RG441)
FB205
1-543-958-22 BEAD, FERRITE (CHIP) (1608) (RG333) < IC >
IC101 IC102 IC201 IC301 IC302
6-705-852-01 8-759-710-97 8-759-508-69 6-702-771-01 6-702-771-01
IC IC IC IC IC
BD3401KS2 NJM4565M-D BA3126N TA78033LS TA78033LS
IC303 IC304 IC371
8-759-701-59 IC NJM78M09FA 8-759-701-59 IC NJM78M09FA 6-704-046-01 IC BU2099FV < COIL >
< DIODE > D201 D202 D206 D207 D211
8-719-988-61 8-719-083-63 8-719-988-61 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 UDZSTE-1713B 1SS355TE-17 1SS355TE-17 1SS355TE-17
D212 D213 D214 D215 D301
8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 6-500-522-21
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 10EDB40-TB3
D302 D303 D304 D305 D306
6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21
DIODE DIODE DIODE DIODE DIODE
10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3
D307 D308 D309 D310 D311
6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21
DIODE DIODE DIODE DIODE DIODE
10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3
D312 D313 D316 D321 D322
6-500-522-21 8-719-085-36 8-719-988-61 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
10EDB40-TB3 11EQS04-TB5 1SS355TE-17 1SS355TE-17 1SS355TE-17
D324 D325 D326
6-500-522-21 DIODE 10EDB40-TB3 6-500-522-21 DIODE 10EDB40-TB3 6-500-522-21 DIODE 10EDB40-TB3 < GROUND TERMINAL BOARD >
EP101 EP301
1-537-771-21 TERMINAL BOARD, GROUND 1-537-771-21 TERMINAL BOARD, GROUND
L101
1-424-849-11 COIL, OSCILLATION (BIAS) < TRANSISTOR >
Q101 Q102 Q103 Q104 Q105
8-729-120-28 6-550-580-01 6-550-889-01 6-550-889-01 8-729-120-28
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC1623-L5L6 2SA1235TP-1F 2SC5938-T112-1B 2SC5938-T112-1B 2SC1623-L5L6
Q106 Q107 Q304 Q305 Q306
8-729-120-28 8-729-120-28 8-729-120-28 6-550-580-01 6-550-889-01
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC1623-L5L6 2SC1623-L5L6 2SC1623-L5L6 2SA1235TP-1F 2SC5938-T112-1B
Q307 Q308 Q309 Q310 Q311
6-550-889-01 6-550-580-01 8-729-120-28 8-729-142-46 8-729-142-46
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC5938-T112-1B 2SA1235TP-1F 2SC1623-L5L6 2SC2001-LK 2SC2001-LK
Q312 Q313 Q314 Q315 Q321
8-729-041-19 8-729-120-28 6-550-580-01 8-729-120-28 8-729-142-46
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SA953-T-K 2SC1623-L5L6 2SA1235TP-1F 2SC1623-L5L6 2SC2001-LK
Q322 Q323 Q324 Q327 Q351
6-550-580-01 8-729-120-28 8-729-140-04 8-729-120-28 8-729-120-28
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SA1235TP-1F 2SC1623-L5L6 2SB1116A-L 2SC1623-L5L6 2SC1623-L5L6
Q352 Q361 Q362
8-729-120-28 TRANSISTOR 2SC1623-L5L6 6-550-580-01 TRANSISTOR 2SA1235TP-1F 8-729-120-28 TRANSISTOR 2SC1623-L5L6 < RESISTOR >
R101 R102 R103 R104 R105
1-216-833-11 1-216-833-11 1-216-851-11 1-216-835-11 1-216-816-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 330K 15K 390
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
65
HCD-RG333/RG441 MAIN Ref. No.
Part No.
Description
Part No.
Description
R106 R107 R108 R109 R110
1-216-851-11 1-216-835-11 1-216-816-11 1-216-853-11 1-216-851-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
330K 15K 390 470K 330K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R197 R198 R201 R202 R203
1-216-825-11 1-216-825-11 1-216-829-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 2.2K 4.7K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R111 R112 R113 R114 R115
1-216-847-11 1-216-853-11 1-216-851-11 1-216-847-11 1-216-857-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
150K 470K 330K 150K 1M
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R204 R205 R206 R207 R208
1-216-833-11 1-216-829-11 1-216-841-11 1-216-825-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 4.7K 47K 2.2K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R116 R117 R119 R120 R121
1-216-809-11 1-216-809-11 1-216-841-11 1-216-857-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 47K 1M 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R209 R210 R211 R212 R213
1-216-833-11 1-216-825-11 1-216-821-11 1-216-833-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 2.2K 1K 10K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R127 R128 R129 R131 R132
1-216-829-11 1-216-835-11 1-216-841-11 1-216-835-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 15K 47K 15K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R214 R216 R217 0 R218
1-216-821-11 1-216-806-11 1-216-806-11 1-215-891-11
METAL CHIP METAL CHIP METAL CHIP METAL OXIDE
1K 56 56 680
5% 5% 5% 5%
0 R218
1-215-916-00 METAL OXIDE
680
5%
R133 R134 R135 R136 R137
1-216-829-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 4.7K 4.7K 4.7K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
1/10W 1/10W 1/10W 2W F (RG333) 3W F (RG441)
0 R219
1-215-891-11 METAL OXIDE
680
5%
0 R219
1-215-916-00 METAL OXIDE
680
5%
R138 R139 R141 R142 R151
1-216-821-11 1-216-864-11 1-216-821-11 1-216-821-11 1-216-829-11
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
1K 0 1K 1K 4.7K
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
R220 R221 R222
1-216-837-11 METAL CHIP 1-216-837-11 METAL CHIP 1-216-830-11 METAL CHIP
22K 22K 5.6K
5% 5% 5%
2W F (RG333) 3W F (RG441) 1/10W 1/10W 1/10W
R152 R153 R154 R155 R156
1-216-833-11 1-216-833-11 1-216-833-11 1-216-829-11 1-216-853-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 4.7K 470K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R223 R225 R226 R227 R228
1-216-864-11 1-216-829-11 1-216-841-11 1-216-821-11 1-216-821-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 4.7K 47K 1K 1K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R157 R158 R159 R160 R161
1-216-841-11 1-216-825-11 1-216-833-11 1-216-821-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
47K 2.2K 10K 1K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R229 R230 R231 R232 R241
1-216-829-11 1-216-829-11 1-216-825-11 1-216-833-11 1-216-797-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 4.7K 2.2K 10K 10
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R162 R163 R164 R165 R166
1-216-825-11 1-216-833-11 1-216-821-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 10K 1K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R242 R243 R244 R245 R246
1-216-838-11 1-216-832-11 1-216-832-11 1-216-829-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
27K 8.2K 8.2K 4.7K 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R167 R168 R169 R170 R171
1-216-833-11 1-216-845-11 1-216-845-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 100K 100K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R247 R248 R249 R250 R251
1-216-833-11 1-216-833-11 1-216-841-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 47K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R172 R173 R174 R175 R176
1-216-809-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-849-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 10K 10K 10K 220K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R252 R253 R254 R262 R263
1-216-864-11 1-216-809-11 1-216-809-11 1-216-827-11 1-216-857-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 100 100 3.3K 1M
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R177 R194 R195
1-216-849-11 METAL CHIP 1-218-867-11 METAL CHIP 1-218-867-11 METAL CHIP
220K 6.8K 6.8K
5% 0.5% 0.5%
1/10W 1/10W 1/10W
R264 R265 R266 R272 R273
1-216-821-11 1-216-833-11 1-216-845-11 1-216-853-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
1K 10K 100K 470K 0
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
66
Remark
Ref. No.
Remark
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
HCD-RG333/RG441 MAIN Ref. No.
Part No.
Description
R274 R275 R281 R282 R283
1-216-864-11 1-216-864-11 1-216-825-11 1-216-825-11 1-216-825-11
SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
0 0 2.2K 2.2K 2.2K
R284 R306 R307 R308 R310
1-216-825-11 1-216-833-11 1-216-833-11 1-216-825-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
R311 R312 R313 R321 R322
1-216-829-11 1-216-837-11 1-216-829-11 1-216-829-11 1-216-837-11
R323 R324 R325 R341 R342
MOTOR (LD) Part No.
MOTOR (TB)
PANEL
Remark
Ref. No.
5% 5% 5%
1/10W 1/10W 1/10W
R392 1-216-821-11 METAL CHIP 1K 5% 1/10W R393 1-216-833-11 METAL CHIP 10K 5% 1/10W R394 1-216-821-11 METAL CHIP 1K 5% 1/10W R395 1-216-837-11 METAL CHIP 22K 5% 1/10W *************************************************************
Description
Remark
2.2K 10K 10K 2.2K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 22K 4.7K 4.7K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
1-216-829-11 1-216-833-11 1-216-829-11 1-216-833-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 10K 4.7K 10K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R343 R344 R345 R346 R347
1-216-837-11 1-216-837-11 1-216-833-11 1-216-821-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 22K 10K 1K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C601 C602 C603 C604 C605
1-162-919-11 1-162-919-11 1-162-919-11 1-164-156-11 1-126-163-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
22PF 22PF 22PF 0.1uF 4.7uF
R348 R351 R352 R353 R354
1-216-837-11 1-216-835-11 1-216-845-11 1-216-841-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 15K 100K 47K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C606 C607 C608 C609 C610
1-115-156-11 1-162-964-11 1-162-970-11 1-115-156-11 1-126-916-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
1uF 0.001uF 0.01uF 1uF 1000uF
R356 R357 R358 R361 R362
1-216-817-11 1-216-825-11 1-216-809-11 1-216-833-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 2.2K 100 10K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C611 C612 C613 C614 C615
1-164-156-11 1-126-157-11 1-164-156-11 1-164-156-11 1-124-257-00
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT
0.1uF 10uF 0.1uF 0.1uF 2.2uF
R363 R364 R371 R372 R373
1-216-829-11 1-216-829-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 4.7K 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C617 C618 C619 C620 C621
1-162-964-11 1-162-964-11 1-124-589-11 1-119-772-91 1-162-995-11
CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP
0.001uF 0.001uF 47uF 47uF 0.022uF
10% 10% 20% 20%
50V 50V 16V 35V 50V
R374 R375 R376 R377 R378
1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C622 C623 C624 C625 C626
1-126-163-11 1-126-163-11 1-162-918-11 1-162-919-11 1-164-156-11
ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
4.7uF 4.7uF 18PF 22PF 0.1uF
20% 20% 5% 5%
50V 50V 50V 50V 25V
R379 R380 R381 R382 R383
1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C628 C629 C630 C631 C632
1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100PF 100PF 100PF 100PF 100PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
R384 R385 R386 R387 R388
1-216-833-11 1-216-829-11 1-216-837-11 1-216-829-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 4.7K 22K 4.7K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C633 C634 C635 C636 C637
1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100PF 100PF 100PF 100PF 100PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
R389 R390 R391
1-216-829-11 METAL CHIP 1-216-837-11 METAL CHIP 1-216-833-11 METAL CHIP
4.7K 22K 10K
5% 5% 5%
1/10W 1/10W 1/10W
C638 C639 C640
1-162-927-11 CERAMIC CHIP 1-162-927-11 CERAMIC CHIP 1-162-927-11 CERAMIC CHIP
100PF 100PF 100PF
5% 5% 5%
50V 50V 50V
1-687-133-12 MOTOR (LD) BOARD ***************** ************************************************************* 1-687-134-12 MOTOR (TB) BOARD ***************** < CONNECTOR > CN742 1-784-727-11 CONNECTOR, FFC 5P ************************************************************* A-4751-547-A PANEL BOARD, COMPLETE (RG333) A-4751-553-A PANEL BOARD, COMPLETE (RG441) ********************** < CAPACITOR > 5% 5% 5% 20%
10% 10% 20%
20%
20%
50V 50V 50V 25V 50V 10V 50V 25V 10V 6.3V 25V 16V 25V 25V 50V
67
HCD-RG333/RG441 PANEL Ref. No.
Part No.
Description
C641 C642 C643 C644 C646
1-164-156-11 1-164-156-11 1-164-156-11 1-126-157-11 1-124-234-00
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT
0.1uF 0.1uF 0.1uF 10uF 22uF
Remark
C647 C648 C649 C653 C654
1-124-589-11 1-124-234-00 1-164-156-11 1-162-959-11 1-164-156-11
ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
47uF 22uF 0.1uF 330PF 0.1uF
C655 C656
1-164-156-11 CERAMIC CHIP 1-162-927-11 CERAMIC CHIP
0.1uF 100PF
20% 20% 20% 20% 5%
5%
25V 25V 25V 16V 16V 16V 16V 25V 50V 25V 25V 50V
Ref. No.
Part No.
Description
Remark
< JUMPER RESISTOR > JR607 JR608 JR609 JR611 JR612
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 (RG441) 0 (RG441)
JR614 JR617 JR621 JR622 JR623
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
< DIODE > < CONNECTOR > LED601 6-500-809-01 LED SELU5223C-STP15 (?/1) CN601 CN601 CN602 CN603 * CN604 CN605 CN608
1-784-751-11 1-784-753-11 1-784-774-11 1-784-778-11 1-564-708-11
CONNECTOR, FFC 29P (RG441) CONNECTOR, FFC 31P (RG333) CONNECTOR, FFC 13P CONNECTOR, FFC 17P PIN, CONNECTOR (SMALL TYPE) 6P
1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P 1-818-282-11 PIN, CONNECTOR 3P < DIODE >
D603 D604 D605 * D606 D607
8-719-988-61 8-719-988-61 8-719-988-61 6-500-486-01 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 1SS355TE-17 1SS355TE-17 PTZ-TE25-11B (RG441) 1SS355TE-17
D608 D609 D610 D611 D613
8-719-988-61 8-719-988-61 8-719-056-78 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 1SS355TE-17 UDZ-TE-17-4.3B 1SS355TE-17 1SS355TE-17
D614 D615 D616 D620 D621
8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17
D622 D623 D625 D626 D630
8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 (RG333) 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17
D631 D632 D633
8-719-978-33 DIODE DTZ-TT11-6.8B 8-719-083-57 DIODE UDZSTE-173.6B 8-719-988-61 DIODE 1SS355TE-17 < FLUORESCENT INDICATOR >
FL601
1-518-976-11 INDICATOR TUBE, FLUORESCENT
< TRANSISTOR > Q601 Q602 Q603 Q604 Q605
8-729-116-57 8-729-140-04 8-729-140-04 8-729-119-76 8-729-120-28
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SB1068-K 2SB1116A-L 2SB1116A-L 2SA1175-HFE 2SC1623-L5L6
Q610 Q611 Q612 Q613 Q614
8-729-027-55 8-729-027-55 8-729-027-55 8-729-027-55 8-729-027-55
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC143EKA-T146 DTC143EKA-T146 DTC143EKA-T146 DTC143EKA-T146 DTC143EKA-T146
Q615 Q616
8-729-027-55 TRANSISTOR DTC143EKA-T146 8-729-027-55 TRANSISTOR DTC143EKA-T146 < RESISTOR >
R601 R602 R603 R604 R605
1-216-829-11 1-216-829-11 1-216-829-11 1-216-841-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 4.7K 4.7K 47K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R606 R607 R608 R609 R610
1-216-829-11 1-216-841-11 1-216-829-11 1-216-837-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 47K 4.7K 22K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R611 R612 R613 R614 R615
1-216-837-11 1-216-833-11 1-216-837-11 1-216-837-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 10K 22K 22K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R616 R617 R618 R619 R620
1-216-833-11 1-216-837-11 1-216-833-11 1-216-837-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 22K 10K 22K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R621 R622 R623 R624 R625
1-216-833-11 1-216-049-11 1-216-833-11 1-216-049-11 1-216-833-11
METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP
10K 1K 10K 1K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R626 R627
1-216-049-11 RES-CHIP 1-216-833-11 METAL CHIP
1K 10K
5% 5%
1/10W 1/10W
< IC > IC601 IC602 IC603 IC604
68
6-804-440-01 6-704-046-01 6-704-045-01 8-759-533-04
IC IC IC IC
LC876996A-53H2-E BU2099FV MM1574ANLE M62703ML-E1
HCD-RG333/RG441 PANEL Ref. No.
Part No.
Description
Remark
R628 R629 R630
1-216-833-11 METAL CHIP 1-216-150-91 RES-CHIP 1-216-809-11 METAL CHIP
10K 10 100
5% 5% 5%
R631
1-216-809-11 METAL CHIP
100
5%
R632
1-216-809-11 METAL CHIP
100
5%
1/10W 1/8W 1/10W (RG333) 1/10W (RG333) 1/10W
R633 R634 R635 R636 R637
1-216-809-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R638 R639 R640 R641 R642
1-216-809-11 1-216-829-11 1-216-834-11 1-216-849-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 4.7K 12K 220K 470
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R643 R644 R645 R646 R647
1-216-819-11 1-216-821-11 1-216-823-11 1-216-823-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
680 1K 1.5K 1.5K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R648 R649 R650 R651 R652
1-216-827-11 1-216-829-11 1-218-867-11 1-216-833-11 1-216-835-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3K 4.7K 6.8K 10K 15K
5% 5% 0.5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R653 R654 R655 R656 R657
1-216-817-11 1-216-819-11 1-216-821-11 1-216-823-11 1-216-823-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 680 1K 1.5K 1.5K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R658 R659 R660 R661 R662
1-216-825-11 1-216-827-11 1-216-829-11 1-218-867-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 3.3K 4.7K 6.8K 10K
5% 5% 5% 0.5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R663 R664 R665 R666 R667
1-216-837-11 1-216-817-11 1-216-819-11 1-216-821-11 1-216-823-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 470 680 1K 1.5K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R668 R669 R670 R671 R672
1-216-823-11 1-216-825-11 1-216-827-11 1-216-829-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1.5K 2.2K 3.3K 4.7K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R674 R675 R676 R677 R678
1-216-835-11 1-216-835-11 1-216-835-11 1-216-864-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP
15K 15K 15K 0 100K
5% 5% 5%
1/10W 1/10W 1/10W
5%
1/10W
R679 R680 R681 R682 R683
1-216-172-00 1-216-838-11 1-216-849-11 1-216-833-11 1-216-849-11
RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
82 27K 220K 10K 220K
5% 5% 5% 5% 5%
1/8W 1/10W 1/10W 1/10W 1/10W
R684
1-216-821-11 METAL CHIP
1K
5%
1/10W
Ref. No.
Part No.
Description
R685 R686 R687 R688 R689
1-216-841-11 1-216-841-11 1-216-833-11 1-216-817-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
47K 47K 10K 470 4.7K
5% 5% 5% 5% 5%
Remark 1/10W 1/10W 1/10W 1/10W 1/10W
R690 R691 R692 R693 R694
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R695 R696 R697 R698 R700
1-216-809-11 1-216-809-11 1-216-809-11 1-216-182-00 1-216-182-00
METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP
100 100 100 220 220
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/8W 1/8W
R702 R704 R706 R708 R710
1-216-182-00 1-216-182-00 1-216-182-00 1-216-182-00 1-216-833-11
RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP
220 220 220 220 10K
5% 5% 5% 5% 5%
1/8W 1/8W 1/8W 1/8W 1/10W
R711 R712 R713 R714 R715
1-216-833-11 1-216-797-11 1-216-797-11 1-216-809-11 1-216-805-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10 10 100 47
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R716 R717 R718 R719 R720
1-216-837-11 1-216-827-11 1-216-837-11 1-216-827-11 1-218-867-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 3.3K 22K 3.3K 6.8K
5% 5% 5% 5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R721 R722 R723 R725 R727
1-216-833-11 1-216-835-11 1-216-809-11 1-216-809-11 1-220-397-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 15K 100 100 4.7M
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R728 R729 R730 R731 R732
1-220-397-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-853-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7M 100 100 100 470K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R733 R734 R735 R736 R737
1-216-809-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 1K 1K 1K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R738 R739 R740 R741 R742
1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 100K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R743 R744 R745 R746 R747
1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 100K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R748 R749 R750
1-216-845-11 METAL CHIP 1-216-845-11 METAL CHIP 1-216-845-11 METAL CHIP
100K 100K 100K
5% 5% 5%
1/10W 1/10W 1/10W
69
HCD-RG333/RG441 PANEL Ref. No.
REM
SENSOR
Part No.
Description
Part No.
Description
R751 R752 R753 R754 R755
1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 100K 100K
5% 5% 5% 5% 5%
Remark 1/10W 1/10W 1/10W 1/10W 1/10W
S606 S607 S608 S610 S611
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (DISC 3) SWITCH, KEYBOARD (DISC SKIP/EX-CHANGE) SWITCH, KEYBOARD (Z) SWITCH, KEYBOARD (P FILE) SWITCH, KEYBOARD (PRESET EQ)
R756 R757 R758 R759 R760
1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 100K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
S612 S621 S622 S623 S624
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (ENTER) SWITCH, KEYBOARD (CD) SWITCH, KEYBOARD (TUNER/BAND) SWITCH, KEYBOARD (TAPE A/B) SWITCH, KEYBOARD (GAME)
R761 R762 R763 R764 R765
1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 100K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
S626 S627 S628 S629 S630
1-762-875-21 SWITCH, KEYBOARD (ILLUMINATION) 1-762-875-21 SWITCH, KEYBOARD (PLAY MODE/TUNING MODE) 1-762-875-21 SWITCH, KEYBOARD (GAME MIXING) 1-762-875-21 SWITCH, KEYBOARD (CD SYNC) 1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)
R766 R767 R768 R769 R770
1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 100K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
S641 S642 S643 S644 S645
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (GROOVE) SWITCH, KEYBOARD (SURROUND) SWITCH, KEYBOARD (EFFECT ON/OFF) SWITCH, KEYBOARD (TUNING +) SWITCH, KEYBOARD (G)
R771 R772 R773 R774 R775
1-216-841-11 1-216-821-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
47K 1K 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
S646 S647 S648 S649 S650
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (M ALBUM +) SWITCH, KEYBOARD (m ALBUM –) SWITCH, KEYBOARD (X) SWITCH, KEYBOARD (x) SWITCH, KEYBOARD (TUNING –)
R776 R777 R778 R779 R780
1-216-817-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 100 100 100 470
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R781 R782 R783 R784 R785
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R786 R787 R788 R789 R790
1-216-833-11 1-216-809-11 1-216-809-11 1-216-841-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 100 100 47K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R791 R792 R793 R794 R795
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R796 R797 R798 R799 R854
1-216-809-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-813-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 1K 1K 1K 220
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R863
1-216-170-00 RES-CHIP
68
5%
1/8W
< SWITCH > S601 S602 S603 S604 S605
70
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (?/1) SWITCH, KEYBOARD (DISPLAY) SWITCH, KEYBOARD (EQ BAND) SWITCH, KEYBOARD (DISC 1) SWITCH, KEYBOARD (DISC 2)
Ref. No.
Remark
< VIBRATOR > X601 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz) X602 1-795-004-21 VIBRATOR, CERAMIC (10MHz) ************************************************************* REM BOARD *********** < CONNECTOR > CN610
1-816-423-11 SOCKET, CONNECTOR 3P < IC >
IC610
6-600-174-01 IC RPM7240-H4 (IR) < JUMPER RESISTOR >
JR624 1-216-296-11 SHORT CHIP 0 ************************************************************* 1-687-132-12 SENSOR BOARD ************** < CONNECTOR > CN731
1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P < IC >
IC731 6-600-022-01 IC RPI-576 *************************************************************
HCD-RG333/RG441 SUB TRANS Ref. No.
Part No.
SW
Description
TRANS
Remark
X-4956-293-1 SUB TRANS BOARD, COMPLETE (RG333) X-4956-294-1 SUB TRANS BOARD, COMPLETE (RG441:E2,E51,AR) X-4956-322-1 SUB TRANS BOARD, COMPLETE (RG441:MX) ************************** < CONNECTOR > CN901
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P < DIODE >
D901 D902 D903 D904 D905
8-719-991-33 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21
DIODE DIODE DIODE DIODE DIODE
1SS133T-77 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3
Ref. No.
VIDEO OUT Part No.
6 STREAM LED
Description
Remark
< CONNECTOR > CN904
CN905 * CN905 * CN906
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P (RG333,RG441:AR,MX) 1-568-106-11 PIN, CONNECTOR (3.96mm PITCH) 4P (RG441:E2,E51) 1-564-506-11 PLUG, CONNECTOR 3P (RG333) 1-564-508-11 PLUG, CONNECTOR 5P (RG441) 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P
* CN907
1-764-333-11 PLUG, CONNECTOR 10P
CN904
< DIODE > D906 D908
8-719-983-79 DIODE MTZJ-T-72-27D 6-500-522-21 DIODE 10EDB40-TB3 < TRANSISTOR >
< TRANSFORMER > Q902 0 PT902 0 PT902 0 PT902
< RESISTOR > R903 1-249-430-11 CARBON 12K 5% 1/4W R904 1-247-831-91 CARBON 1K 5% 1/4W 0 R908 1-202-972-61 FUSIBLE 1 5% 1/4W F *************************************************************
< RELAY > 0 RY901
8-729-048-52 TRANSISTOR 2SA1932 (TP)
1-439-735-11 TRANSFORMER, POWER (RG333) 1-443-080-11 TRANSFORMER, POWER (RG441:MX) 1-443-239-11 TRANSFORMER, POWER (RG441:E2,E51,AR)
1-755-276-11 RELAY, POWER < VOLTAGE SELECTOR >
VIDEO OUT BOARD ****************
0 S901
1-786-055-21 SELECTOR, VOLTAGE (VOLTAGE SELECTOR) (RG441:E2,E51) *************************************************************
< CONNECTOR > * CN805
1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P
1-687-669-12 SW BOARD **********
< JACK >
< SWITCH >
J803 1-774-227-11 JACK, PIN 1P (VIDEO OUT) *************************************************************
S751 1-786-514-11 SWITCH, LEVER (SLIDE) (OPEN) ************************************************************* A-4750-766-A A-4751-524-A A-4752-191-A A-4752-196-A
TRANS BOARD, COMPLETE (RG333) TRANS BOARD, COMPLETE (RG441:E2,E51) TRANS BOARD, COMPLETE (RG441:MX) TRANS BOARD, COMPLETE (RG441:AR) **********************
1-533-233-11 HOLDER, FUSE
6 STREAM LED BOARD ******************* < DIODE > LED610 LED611 LED612 LED613 LED614
6-500-809-01 6-500-809-01 6-500-809-01 6-500-809-01 6-500-809-01
LED LED LED LED LED
SELU5223C-STP15 (ILLUMINATION) SELU5223C-STP15 (ILLUMINATION) SELU5223C-STP15 (ILLUMINATION) SELU5223C-STP15 (ILLUMINATION) SELU5223C-STP15 (ILLUMINATION)
< CAPACITOR > LED615 6-500-809-01 LED SELU5223C-STP15 (ILLUMINATION) C906 C908 C909 C910 C911
1-164-159-11 1-128-553-11 1-126-964-11 1-126-968-11 1-126-942-61
CERAMIC ELECT ELECT ELECT ELECT
0.1uF 220uF 10uF 100uF 1000uF
20% 20% 20% 20%
50V 63V 50V 50V 25V
C920 C921 C922 C923 C924
1-131-679-31 1-131-679-31 1-131-679-31 1-131-679-31 1-136-165-00
FILM FILM FILM FILM FILM
0.01uF 0.01uF 0.01uF 0.01uF 0.1uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C925 C926
1-136-165-00 FILM 1-164-159-11 CERAMIC
0.1uF 0.1uF
5%
50V 50V
< RESISTOR > R673 R699 R701 R703 R705
1-216-837-11 1-216-182-00 1-216-182-00 1-216-182-00 1-216-182-00
METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP
R707 R709
1-216-182-00 RES-CHIP 1-216-182-00 RES-CHIP
22K 220 220 220 220
5% 5% 5% 5% 5%
1/10W 1/8W 1/8W 1/8W 1/8W
220 220
5% 5%
1/8W 1/8W
< ROTARY ENCODER > S660
1-418-632-11 ENCODER, ROTARY (MASTER VOLUME)
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
71
HCD-RG333/RG441 6 STREAM LED Ref. No.
Part No.
Description
Remark
< SWITCH > SW601 1-786-289-11 SWITCH, DETECTION (l – EQ + L) ************************************************************* MISCELLANEOUS *************** 6 7 7 52 53
1-400-285-11 1-769-940-11 1-777-353-11 1-796-485-51 1-769-975-11
F-BEAD, E2515MRT WIRE (FLAT TYPE) (11 CORE) (RG441) WIRE (FLAT TYPE) (15 CORE) (RG333) DECK, MECHANICAL WIRE (FLAT TYPE) (13 CORE)
54 56 0 206 0 206 0 206
1-773-048-11 1-773-317-11 1-777-071-83 1-783-941-22 1-827-226-11
WIRE (FLAT TYPE) (17 CORE) WIRE (FLAT TYPE) (31 CORE) (RG333) CORD, POWER (RG333,RG441:E51) CORD, POWER (RG441:AR) CORD, POWER (RG441:E2,MX)
252 301 0 328 329 330
1-776-182-11 1-471-035-11 8-820-244-01 1-827-992-11 1-775-251-11
WIRE (FLAT TYPE) (5 CORE) MAGNET ASSY OPTICAL PICK-UP (KSM-215DCP/C2RP) WIRE (FLAT TYPE) (16 CORE) WIRE (FLAT TYPE) (27 CORE)
0 F904
1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V) (RG441) 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG333) 1-533-473-12 FUSE, GLASS TUBE (DIA.5) (T6.3AL/250V) (RG441) 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG333) 1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V)
0 F904 0 F905 0 F905 0 F906 0 F907 0 F908
1-533-470-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/250V) 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG441) 0 F909 1-576-655-12 FUSE, GLASS TUBE (DIA.5) (T8AL/250V) (RG441) FAN901 1-763-117-13 FAN, DC FC901 1-469-854-11 CORE, FERRITE M741 M751 0 PT901 0 PT901 0 PT901
A-4723-963-A A-4736-655-A 1-443-234-11 1-443-255-11 1-443-294-11
MOTOR ASSY, TABLE (TBL) MOTOR ASSY, LOADING (LOADING) TRANSFORMER, POWER (RG333) TRANSFORMER, POWER (RG441:E2,E51,AR) TRANSFORMER, POWER (RG441:MX)
RE701 S101 TM901 TM901
1-477-680-12 1-771-853-11 1-693-615-11 1-693-616-11
ENCODER, ROTARY SWITCH, DETECTION (LIMIT) TUNER PACK (FM/AM) (ANTENNA) (RG441) TUNER PACK (FM/AM) (ANTENNA) (RG333)
72
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
HCD-RG333/RG441
MEMO
73
HCD-RG333/RG441
REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. 1.0
74
Date 2004. 04
Description of Revision New
