GSM TELEPHONE SGH-E200
GSM TELEPHONE
CONTENTS 1.
Safety Precautions
2.
Specification
3.
Operation Instruction and Installation
4.
Array course control
5.
Exploded View/Disassembly and Assembly Instructions
6.
MAIN Electrical Parts List
7.
Block Diagrams
8.
PCB Diagrams
9.
Flow Chart of Troubleshooting
10.
Reference data
1. Safety Precautions 1-1. Repair Precaution ● Repair in Shield Box, during detailed tuning. Take specially care of tuning or test, because specipicty of cellular phone is sensitive for surrounding interference(RF noise). ● Be careful to use a kind of magnetic object or tool, because performance of parts is damaged by the influence of magnetic force. ● Surely use a standard screwdriver when you disassemble this product, otherwise screw will be worn away. ● Use a thicken twisted wire when you measure level. A thicken twisted wire has low resistance, therefore error of measurement is few. ● Repair after separate Test Pack and Set because for short danger (for example an overcurrent and furious flames of parts etc) when you repair board in condition of connecting Test Pack and tuning on. ● Take specially care of soldering, because Land of PCB is small and weak in heat. ● Surely tune on/off while using AC power plug, because a repair of battery charger is dangerous when tuning ON/OFF PBA and Connector after disassembling charger. ● Don't use as you pleases after change other material than replacement registered on SEC System. Otherwise engineer in charge isn't charged with problem that you don't keep this rules.
1-1
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Safety Precautions
1-2. ESD(Electrostatically Sensitive Devices) Precaution Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD (Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below. You can prevent from ESD damage by static electricity. ● Remove static electricity remained your body before you touch semiconductor or parts with semiconductor. There are ways that you touch an earthed place or wear static electricity prevention string on wrist. ● Use earthed soldering steel when you connect or disconnect ESD. ● Use soldering removing tool to break static electricity. , otherwise ESD will be damaged by static electricity. ● Don't unpack until you set up ESD on product. Because most of ESD are packed by box and aluminum plate to have conductive power,they are prevented from static electricity. ● You must maintain electric contact between ESD and place due to be set up until ESD is connected completely to the proper place or a circuit board.
1-2
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
2. Specification 2-1. GSM General Specification G SM 90 0 Ph ase 1
EG SM 9 00 Ph ase 2
DCS1800 Ph ase 1
PCS1900
Fr eq. Band[MHz] Uplin k/Down link
8 90~915 9 35~960
8 80~915 9 25~960
17 10~178 5 18 05~188 0
185 0~1910 193 0~1990
ARF CN ra nge
1~124
0~124 & 97 5~1023
5 12~885
51 2~810
T x/Rx spacing
45MHz
45MHz
95MHz
8 0MHz
Mo d. Bit r ate/ Bit Period
270 .833kb ps 3 .692u s
270 .833kb ps 3 .692u s
270 .833kb ps 3 .692u s
270 .833kb ps 3. 692us
Ti me Slo t Pe rio d/Fr am e Per iod
5 76.9u s 4. 615ms
5 76.9u s 4. 615ms
5 76.9u s 4. 615ms
57 6.9us 4.6 15ms
Modula tion
0 .3G M SK
0 .3G MSK
0 .3G M SK
0. 3G MSK
MS Power
33d Bm~5dBm
33d Bm~5dBm
30d Bm~0dBm
30d Bm~0dBm
Powe r Class
5pcl ~ 19pcl
5pcl ~ 19pcl
0pcl ~ 15pcl
0pcl ~ 15pcl
Se nsitivity
-10 2dBm
-10 2dBm
-10 0dBm
-100 dBm
TDMA Mu x
8
8
8
8
Cell Radiu s
35Km
35Km
2Km
-
2-1
Speclflcation
2-2. GSM Tx Power Class TX Power control level
GSM900
TX Power control level
DCS1800
TX Power control level
PCS1800
5
33±2 dBm
0
30±3 dBm
0
30±3 dBm
6
31±2 dBm
1
28±3 dBm
1
28±3 dBm
7
29±2 dBm
2
26±3 dBm
2
26±3 dBm
3
24±3 dBm
8
27±2 dBm
3
24±3 dBm
4
22±3 dBm
4
22±3 dBm
9
25±2 dBm 5
20±3 dBm
5
20±3 dBm
10
23±2 dBm 6
18±3 dBm
6
18±3 dBm
11
21±2 dBm 7
16±3 dBm
7
16±3 dBm
8
14±3 dBm
8
14±3 dBm
9
12±4 dBm
9
12±4 dBm
10
10±4 dBm
10
10±4 dBm
11
8±4dBm
11
8±4dBm
12
6±4 dBm
12
6±4 dBm
13
4±4 dBm
13
4±4 dBm
12
13
14
15
19±2 dBm
17±2 dBm
15±2 dBm
13±2 dBm
16
11±3 dBm
17
9±3dBm
18
7±3 dBm
14
2±5 dBm
14
2±5 dBm
19
5±3 dBm
15
0±5 dBm
15
0±5 dBm
2-2
3. Operation Instruction and Installation Main Function -1.3M Camera -1.8", QCIF, 65K colors -Video Recording & Messaging -Music Player(MP3/AAC/AAC+) -Multimedia Message Service (MMS) -Bluetooth Wireless Technology -E-mail -Voice recorder -Java / WAP2.0 -Tri-band(900/1800/1900MHz)
3-1
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Operation Instruction and Installation
3-2
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
4. Array course control 4-1. Software Adjustments
Test Jig (GH80-03306A)
Test Cable(GH39-00499B)
Serial Cable(CSA LL64151-A)
Power Supply Cable
4-1
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Array course control
4-2. Software Downloading 4-2-1. Pre-requsite for Downloading • Downloader Program(OneNAND_Downloader_v12_for_PNX5230) • E200Mobile Phone • Data Cable • Binary file, TFS file 4-2-2. S/W Downloader Program ■ Load the binary download program by executing the “OneNAND_Downloader_v12_for_PNX5230”
1. Select the connected serial port and the rate of speed 2. Select the check box, the mode you want to download. - if the binary file wanted, check only 'BIN' - if the tfs file wanted, check only 'TFS' - if all the files wanted, check 'BIN+TFS'
1
2
4-2
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Array course control
3. Select the file(s) what you want to download
4-3
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Array course control
4-4
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
5. Exploded View/Disassembly&Assembly Instructions 5-1. Cellular phone Exploded View QMW01
QFR01
QKP01
QME01 QMI01
QLC01
QSH01 QCA01 QMO01 QAN03
QSP01
QMP01 QVK01
QAN01
QCR58 QSD01 QRF03
QRE01
QVO01 QCW01
QCR04 QBA01
QBA00
5-3
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-2. Cellular phone Parts list Design LOC
Description
Sec Code
QAN01
ANTENNA
GH42-01116A
QAN03
FPCB ANTENNA CHIP-SGH E200
GH42-01099A
QBA01
INNER BATTERY PACK-800MAH , BL
GH43-02790A
QBA00
PMO-COVER BATT
GH72-36417A
QCA01
UNIT-CAMERA MODULE
GH59-03978A
QCR04
SCREW-MACHINE
6001-001479
QCR58
SCREW-MACHINE
6001-001870
QCW01
PCT-COVER CAMERA WINDOW
GH72-36429A
QFR01
ASSY CASE-FRONT
GH98-03281A
QKP01
ASSY KEYPAD-(SER/BLK)
GH98-03859A
QLC01
LCD-SGH E200 MODULE
GH07-01054A
QMO01
MOTOR DC-SGH E200
GH31-00301A
QMP01
PBA MAIN-SGHE200
GH92-03601A
QMW01
ASSY COVER-MAIN WINDOW
GH98-03886A
QSH01
ASSY BRACKET-SHIELD
GH98-03284A
QSP01
SPEAKER
3001-002124
QVK01
UNIT-VOLUME KEY
GH59-04001A
QVO01
ASSY KEY-VOLUME
GH98-04936A
QRE01
ASSY CASE-REAR
GH98-03282A
QRF03
PMO-COVER EAR
GH72-36422A
QSD01
PMO-COVER MICRO SD
GH72-36423A
UNIT-KEY FPCB
GH59-04005A
AS-MIC SVC
GH81-05445A
QME01 QMI01
5-2
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
Description
Sec Code
BAG PE
6902-000634
CBF INTERFACE-DATA LINK CABLE
GH39-00444A
ADAPTOR-SGHE690,BLK,EU,A_TYPE
GH44-01361A
S/W CD-SGHE200 PC LINK CD
GH46-00407A
UNIT-20P,EARPHONE,BLK,B-TYPE
GH59-04029A
MANUAL-SFC
GH68-04336A
LABEL(P)-BARCODE RUSSIA
GH68-08494A
LABEL(R)-WATER SOAK
GH68-09361A
LABEL(R)-MAIN(SER)
GH68-14021C
MANUAL USERS-EU RUSSIAN
GH68-14288A
BOX-UNIT BOX(SER)
GH69-05106B
CUSHION-CASE(EU)
GH69-05109A
MPR-INSU TAPE
GH74-29553A
MPR-INSU TAPE
GH74-30538A
MPR-TAPE SHEET LABEL
GH74-31820A
MPR-TAPE MAIN WINDOW V2
GH74-32035A
VINYL-BOHO CAMERA WINDOW
GH74-32399A
VINYL-BOHO MAIN WINDOW
GH74-32939A
5-3
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-3. Disassembly and Assembly Instruction 5-3-1. Disassembly
1
2
Unscrew 4 screws in rear cover
Separate the rear cover
3
Unscrew marked
2
1
4 points
From the bottom part separte the rear cover
1) Be careful of the damage of cover and scratch.
3
1) Be careful of the damage of cover and scratch.
4
Remove the Volume key and separate
Separate the Camera Connector, Main key PBA Connector and LCD
the Volume key PBA from case.
Connector from Main PBA
Use pinset for separate the LCD connector
1) Be careful of the damage on key PBA
5-4
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5
Separate the PBA ASSY from upper
6
Unscrew 3 screws in PBA ASSY
case
Unscrew marked 3 points
7
Separate the PBA from
8
PBA ASSY Bracket
1) Speaker, camera, motor is attached by adhensive tape. Thus be careful when disassemble.
Separate the LCD from Bracket.
1) Adhesive tape is attached on back side of LCD. Thus be careful when disassemble.
5-5
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-3-2. Assembly
1
Insert LCD to Bracket(front side).
2
Insert PBA to bracket(back side)
1) Adhesive tape is attached on back side of Speaker, motor, camer. Thus be careful when assemble.
3
4
Screw to the PBA ASSY
Assemble the PBA ASSY with the front case
Screwing 3 points
.
. 5-6
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5
6
Insert the connector and fpcb to
Attach the Volume key PBA on case and locate the Volume key .
market socket.
Use pinset for insert the LCD connector
7
8
Assemble the Rear Case
Screw the rear cover
Screw marked 4 points
1
2
3
.
. 5-7
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-8
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-8
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
6. MAIN Electrical Parts List Design LOC
Description
SEC Code
STATUS
BAT400 BTC600 C101 C102 C103 C104 C105 C106 C107 C108 C109 C111 C112 C114 C115 C116 C117 C118 C119 C122 C123 C125 C126 C131 C132 C201 C202 C203 C204 C205 C206 C208 C209 C210 C211 C212 C213 C214 C215 C216 C221 C222 C301 C302 C303 C304 C305 C306 C307 C308
BATTERY-LI(2ND) CONNECTOR-BATTERY C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP
4302-001181 3711-006003 2203-005234 2203-000696 2203-000812 2203-005234 2203-005234 2203-000233 2203-000233 2203-005234 2203-005234 2203-005382 2203-005281 2203-000233 2203-000233 2203-000233 2203-000278 2203-005482 2203-000812 2203-002709 2203-002709 2203-001221 2203-002709 2203-000233 2203-005736 2203-005482 2203-000812 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-005482 2203-006562 2203-000254 2203-005482 2203-000812 2203-005482 2203-000425 2203-006824 2203-005482 2203-000425 2203-006423 2203-006423 2203-005482 2203-005482 2203-005482 2203-005482 2203-006423 2203-000696
SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA
6-1
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
C309 C310 C315 C316 C317 C318 C319 C321 C322 C323 C324 C325 C326 C400 C401 C402 C403 C404 C405 C407 C409 C410 C411 C412 C413 C414 C415 C416 C417 C420 C421 C422 C425 C426 C430 C431 C432 C501 C502 C503 C504 C505 C506 C507 C508 C509 C511 C512 C513 C514
C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP
2203-000995 2203-000233 2203-006562 2203-006562 2203-006423 2203-006562 2203-006838 2203-006838 2203-006305 2203-000233 2203-006842 2203-000278 2203-000278 2203-006257 2203-006562 2203-006562 2203-006257 2203-006824 2203-006257 2203-006257 2203-006824 2203-006824 2203-006257 2203-005736 2203-006257 2203-006562 2203-006562 2203-000550 2203-000550 2203-006257 2203-006324 2203-006423 2203-006361 2203-006474 2203-006562 2203-006348 2203-006825 2203-006194 2203-005482 2203-005496 2203-005483 2203-005496 2203-005483 2203-005482 2203-000233 2203-000643 2203-005395 2203-005395 2203-005482 2203-005482
SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA
6-2
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
C515 C516 C517 C518 C519 C520 C521 C522 C523 C524 C525 C526 C540 C542 C543 C544 C546 C548 C549 C551 C552 C553 C554 C602 C605 C606 C607 C608 C609 C610 C611 C614 C615 C616 C617 C700 C701 C702 C703 C704 C705 C716 C717 D600 F100 F300 F500 F704 F705 F706
C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP DIODE-SWITCHING DUPLEXER-FEM FILTER-LC FILTER-EMI/ESD FILTER-EMI/ESD FILTER-EMI/ESD FILTER-EMI/ESD
2203-000679 2203-000679 2203-000330 2203-000330 2203-005482 2203-005482 2203-005395 2203-005395 2203-006260 2203-006260 2203-005482 2203-006137 2203-000278 2203-005050 2203-003054 2203-000278 2203-000278 2203-001259 2203-005050 2203-000278 2203-000386 2203-000386 2203-000386 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006048 2203-006824 2203-005482 2203-000425 2203-006423 2203-000812 2203-006562 2203-005682 2203-005682 2203-006562 2203-006562 2203-006562 2203-006562 2203-006423 2203-006423 0401-001141 2911-000072 2909-001279 2901-001376 2901-001319 2901-001319 2901-001319
SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA
6-3
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
F707 F708 HDC601 HDC602 IFC500 L101 L102 L103 L104 L105 L106 L108 L303 L400 L500 L501 L502 L503 L504 L505 OSC100 OSC300 OSC400 PAM100 R101 R102 R104 R107 R204 R205 R206 R208 R209 R210 R211 R212 R213 R214 R215 R217 R218 R221 R223 R225 R226 R227 R301 R302 R303 R306
FILTER-EMI/ESD FILTER-EMI/ESD HEADER-BOARD TO BOARD HEADER-BOARD TO BOARD SOCKET-INTERFACE INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD BEAD-SMD INDUCTOR-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD INDUCTOR-SMD BEAD-SMD CRYSTAL-SMD CRYSTAL-SMD CRYSTAL-SMD IC-POWER AMP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP
2901-001319 2901-001319 3711-005659 3711-005659 3710-002442 2703-002612 2703-002544 2703-002586 2703-002608 2703-002558 2703-002155 2703-002586 3301-001659 2703-003113 3301-001729 3301-001729 3301-001876 3301-001876 2703-002313 3301-001876 2801-004587 2801-004560 2801-004466 1201-002423 2007-001313 2007-000143 2007-000171 2007-008419 2007-000148 2007-000148 2007-002796 2007-000148 2007-000140 2007-000171 2007-000148 2007-000170 2007-000148 2007-000170 2007-001319 2007-001319 2007-000758 2007-000171 2007-000758 2007-000171 2007-000171 2007-000171 2007-000162 2007-008055 2007-000171 2007-000141
SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA
6-4
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
R307 R308 R309 R310 R311 R312 R313 R319 R322 R400 R401 R402 R403 R405 R407 R408 R409 R410 R411 R412 R413 R414 R416 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R513 R514 R516 R517 R518 R519 R521 R522 R600 R601 R603 R604 R605 R606 R607
R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP
2007-000141 2007-001303 2007-007014 2007-000162 2007-007014 2007-000170 2007-007489 2007-000170 2007-000148 2007-007573 2007-008354 2007-000162 2007-009168 2007-008542 2007-009157 2007-008542 2007-008542 2007-007100 2007-007311 2007-008542 2007-007317 2007-008542 2007-009314 2007-009112 2007-009155 2007-009155 2007-009112 2007-007741 2007-000172 2007-002796 2007-002796 2007-000172 2007-009112 2007-007528 2007-007014 2007-007014 2007-000162 2007-007528 2007-008542 2007-007528 2007-007528 2007-008785 2007-008785 2007-000162 2007-008055 2007-007142 2007-008419 2007-000162 2007-000162 2007-000159
SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SNA SNA SNA SA SA SA SA SA SNA SA SA SA SA SA SA SA SA SNA SNA SA SA SA SA SA SA SA
6-5
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
R608 R609 R610 R611 R612 R613 R614 R615 R701 R703 RFS100 RFS101 SIM600 SLC700 TA100 TA400 TA500 TA501 TA502 TA503 TA504 TA600 TA601 TR600 U102 U202 U301 U302 U303 U304 U400 U401 U402 U500 U501 U502 U503 U600 U601 U700 UCP200 UME300 VR600 VR604 VR701 ZD400 ZD500 ZD501 ZD502 ZD503
R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP CONNECTOR-COAXIAL CONNECTOR-COAXIAL CONNECTOR-CARD EDGE CONNECTOR-FPC/FFC/PIC C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP FET-SILICON IC-TRANSCEIVER FILTER-EMI SMD IC-CMOS LOGIC IC-CMOS LOGIC IC ASIC-SGHE490 IC-TRANSCEIVER IC-POWER SUPERVISOR IC-POSI.FIXED REG. IC-POSI.FIXED REG. IC-AUDIO AMP IC-TUNER IC-CMOS LOGIC IC-ANALOG MULTIPLEX IC-POSI.FIXED REG. IC-MULTI REG. IC-DC/DC CONVERTER IC-COMM. CONTROLLER IC-MCP THERMISTOR-NTC VARISTOR VARISTOR DIODE-ZENER DIODE-TVS DIODE-TVS DIODE-TVS DIODE-ZENER
2007-000162 2007-009314 2007-008516 2007-007107 2007-000152 2007-009112 2007-009168 2007-009168 2007-000162 2007-009168 3705-001358 3705-001448 3709-001453 3708-002202 2404-001474 2404-001430 2404-001377 2404-001377 2404-001381 2404-001226 2404-001474 2404-001268 2404-001381 0505-002111 1205-003093 2901-001316 0801-002237 0801-002237 GH13-00044A 1205-002942 1203-004382 1203-003737 1203-003737 1201-002356 1204-002700 0801-003025 1001-001428 1203-003737 1203-004291 1203-003708 1205-003082 1108-000104 1404-001221 1405-001082 1405-001082 0403-001547 0406-001215 0406-001254 0406-001254 0403-001547
SA SA SA SA SA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA
6-6
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
ZD600 ZD602 ZD603 ZD604 ZD605 ZD606 ZD703
DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS
0406-001201 0406-001200 0406-001215 0406-001215 0406-001254 0406-001254 0406-001215
SA SA SA SA SA SA SA
6-7
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Main Electrical Parts List
6-8
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
7. Block Diagrams 7-1. RF Solution Block Diagram
7-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Block Diagrams
7-2. Base Band Solution Block Diagram
7-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
8. PCB Diagrams Top
8-1
PCB Diagrams
Bottom
8-2
9. Flow Chart of Troubleshooting 9-1. Power On ' Power On ' does not work Yes
No
Check the Battery Voltage
Change the Battery
is more than 3.4V
Yes
No C420(VISA) = 2.7V?
Check the PMU related to VISA
Yes
No
Check the Clock at
Resolder OSC400
R410=32KHZ
Yes
No
C400(+VDD_IO_LOW) & C405(+VDD_IO_HIGH) = "H"?
Check the related circuit
Yes
No
C426+VDD_GSM_CORE)
Check the +VDD_GSM_CORE circuit
= 1.2V?
Yes
No
Check for the clock at C310
Check the clock generation circuit (related to OSC300)
= 26MHz
Yes
Check the initial operation
Yes END
9-1
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-2
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-2. Initial
Initial Failure Yes
No U400 pin 7 (RSTON) ="H"?
Check the circuit related to reset
Yes
No
Is U301 pin 4
Check the U301
OK?
Yes Check the 16bit data signal & memory CE Yes END
9-3
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-4
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-3. Charging Part
Abnormal charging part Yes
No
Check the C431 > 4.9V
Check the circuit related to
V_EXT_CHARGE
Yes
No Resolder or replace U400
U400 pin 36 = "L"?
Yes
No
Check the circuit related to
U400 pin 34 = "L"? AUX_ON signal
Yes
END
9-5
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-6
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-4. Sim Part
Phone can't access SIM Card
Yes
No C610, C611
= "H"?
Resolder or replace U400
Yes
No
After Power ON,
Check the Clock
Check SIMCLK Signal on pin15 of SIM600 in a few second
Yes
No After SIM card insert, Replace PBA
SIM600 pin 13 = "H(SIM_RST)"?
Yes
Check the SIM Card
Yes
END
9-7
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-8
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-5. Microphone Part
Microphone does not work
Yes No Check the connection
Resolder MIC
from MIC
Yes
Check the circuit
No Resolder the C548, C546, C551, C514, C516, C520, C512, C518, C522, R516, R519, R508
from UCP200 to MIC
Yes
Check the MIC
No
Replace the MIC
Yes
END
9-9
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-10
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-6. Speaker Part(Melody)
Speaker does not work Yes No U500 pin 7 = 2.9V?
Resolder or replace U500
Yes
No
Check the signal at Pin 8, 9 of U500
Resolder the C503, C505
> 1.3V
Yes
No
Check the signal at
Resolder or replace U500
Pin 15, 17 of U500
Yes No Is Speaker working?
Change the Speaker
Yes END
9-11
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-12
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-7. Key Data Input
Check Initial Operation
Yes
When one of the keys is
No Check the Dome sheet & Key Pad
pushed, is it displayed on LCD?
Yes
When one of the keys is
No Replace the PBA
pushed, KBIO signal is OK?
Yes
END
9-13
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-8. Receiver Part
Receiver does not work Yes No Resolder UCP200 or change PBA
Is Receiver working?
Yes No Replace the Receiver
Is Receiver working?
Yes
END
9-14
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-9. Back Light (for Color Main LCD)
Backlight does not work Yes No Is LCD Contrast set on high
Set LCD Contrast on high level
level in the Menu?
Yes
No U700 PIN 3 = H ?
Check the inserting condition of slide FPCB Resolder UCP200 or change PBA
Yes
No Check the U700 & the related circuit
U700 PIN 1 = H ?
Yes
Replace the LCD Module
Yes END
9-15
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-16
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-10. Key Back Light
Main Key LED does not work Yes No Check the UCP200 related to "MAIN_LED_ON"
U401 pin1 = H ?
Yes
END
9-17
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-11. Camera part "Camera" function does not work Yes
No Check the Camera connector
Reconnect the camera module
Yes No U601 pin 6 = H ?
Resold or replace U601
Yes No Check U302(pin2, pin4) related to 26Mhz and R308
C310 = 26MHz?
Yes
Is there another problem?
Yes
Replace the camera module
END
9-18
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-19
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-12. GSM Receiver
RX ON RF input : 62CH center freq : 947.4MHz Amp : -50dBm
Yes No
F100 Pin13 >= -65dBm
Resolder RFS100, C103, L106
Yes No
F100 pin1,2 >= -68dBm
No
Check F100 pin9,pin11 = L
Check ANT Switch control circuit
Yes Resolder F100
Yes No U101 pin 24 >= -70dBm pin 25 >= -70dBm
Resolder C108, C109, L105
Yes
U101 pin 4,5,6,7 >= 1V
No
No U101 pin 11,12 16,17,32,33>=2.8V
Yes
Check U101, OSC100 RF26MHz, RF PSU Part
Yes Resolder U101
Check UCP200
END
9-20
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-13. GSM Transmitter
TX ON (5Level)
Yes No
F100 Pin13 >= 20dBm
Resolder RFS100,C103,L106
Yes No
F100 pin10 >= 18dBm
Check F100 pin9=L, pin11=H(2.6V)
No Check ANT Switch control circuit
Yes
Yes No
PAM100 pin12 >= 18dBm
Change or Resolder L101,C111,C121
Resolder or Change PAM100
Yes No
PAM100 pin18 = 1V
U101 pin 11,12 16,17,32,33>=2.8V
No
Check & Resolder RFOLP signal, RF13MHz, RF PSU Part
Yes Yes Check UCP200
END
9-21
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Resolder U101
Flow Chart of Troubleshooting
9-14. DCS Receiver
RX ON RF input : 698CH center freq : 1842.4MHz Amp : -50dBm
Yes No
F100 Pin13 >= -65dBm
Resolder RFS100,C103,L106
Yes No
F100 pin3,4 >= -68dBm
Check F100 pin9,pin11 = L
No
Check ANT Switch control circuit
Yes Yes
Resolder F100 No
U101 pin 22 >= -70dBm pin 23 >= -70dBm
Resolder C104, C105, L104
Yes
U101 pin 4,5,6,7 >= 1V
No
No U101 pin 11,12 16,17,32,33>=2.8V
Yes
Check U101, OSC100 RF26MHz, RF PSU Part
Yes Resolder U101
Check UCP200
END
9-22
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-15. DCS Transmitter
TX ON (5Level)
Yes No
F100 Pin13 >= 20dBm
Resolder RFS100,C103,L106
Yes No
F100 pin8 >= 18dBm
Check F100 pin9 = H (2.6V), pin11 = L
No Check ANT Switch control circuit
Yes
Yes No
PAM100 pin18 >= 18dBm
Change or Resolder C115,C116,C131
Resolder or Change PAM100
Yes No
PAM100 pin1 = 1V
U101 pin 11,12 16,17,32,33>=2.8V
No
Check & Resolder RFOHP signal, RF13MHz, RF PSU Part
Yes Yes Check UCP200
END
9-23
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Resolder U101
Flow Chart of Troubleshooting
9-16. PCS Receiver
RX ON RF input : 660CH center freq : 1959.8MHz Amp : -50dBm
Yes No
F100 Pin13 >= -65dBm
Resolder RFS100,C103,L106
Yes No
F100 pin5,6 >= -68dBm
Check F100 pin9,pin11 = L
Yes
No
Check ANT Switch control circuit
Yes Resolder F100
No U101 pin 21 >= -70dBm pin 20 >= -70dBm
Resolder C101, C102, L103
Yes
U101 pin 4,5,6,7 >= 1V
No
No U101 pin 11,12 16,17,32,33>=2.8V
Yes
Check U101, OSC100 RF26MHz, RF PSU Part
Yes Resolder U101
Check UCP200
END
9-24
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-17. PCS Transmitter
TX ON (5Level)
Yes No
F100 Pin13 >= 20dBm
Resolder RFS100,C103,L106
Yes No
F100 pin8 >= 18dBm
Check F100 pin9=H (2.6V), pin11=L
No Check ANT Switch control circuit
Yes
Yes No
PAM100 pin18 >= 18dBm
Change or Resolder C115,C116,C131
Resolder or Change PAM100
Yes No
PAM100 pin1 = 1V
U101 pin 11,12 16,17,32,33>=2.8V
No
Check & Resolder RFOHP signal, RF13MHz, RF PSU Part
Yes Yes Check UCP200
END
9-25
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Resolder U101
Flow Chart of Troubleshooting
9-26
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-27
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-28
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
10. Reference data Reference Abbreviate - AAC: Advanced Audio Coding. - AVC : Advanced Video Coding. - BER : Bit Error Rate - BPSK: Binary Phase Shift Keying - CA : Conditional Access - CDM : Code Division Multiplexing - C/I : Carrier to Interference - DMB : Digital Multimedia Broadcasting - EN : European Standard - ES : Elementary Stream - ETSI: European Telecommunications Standards Institute - MPEG: Moving Picture Experts Group - PN : Pseudo-random Noise - PS : Pilot Symbol - QPSK: Quadrature Phase Shift Keying - RS : Reed-Solomon - SI
: Service Information
- TDM : Time Division Multiplexing - TS : Transport Stream
10-1
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
Reference data
10-2
SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization
GSPN (Global Service Partner Network) Country North America Latin America CIS Europe China Asia Mideast & Africa
Web Site service.samsungportal.com latin.samsungportal.com cis.samsungportal.com europe.samsungportal.com china.samsungportal.com asia.samsungportal.com mea.samsungportal.com
This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable International and/or domestic law.
ⓒ Samsung Electronics Co.,Ltd. 2007. 04. Rev.1.0