SLV-LX40/LX50/LX60S/LX70S RMT-V293A/V294A

SERVICE MANUAL

Chilean Model SLV-LX50CL/LX50CS/LX70SCL/ LX70SCS

Mexican Model SLV-LX40MX/LX50MX/LX60SMX/ LX70SMX 1 4 7

2

3

5

6

8

9

Panama Model Venezuelan Model

0

SLV-LX50PA/LX50PC/LX50VZ/ LX70SPA/LX70SPC/LX70SVZ

g

S MECHANISM

SLV-LX70S

Refer to the SERVICE MANUAL of VHS MECHANICAL ADJUSTMENT for MECHANICAL ADJUSTMENTS. (9-921-748-11)

HiFi model : SLV-LX60S/LX70S Mono model: SLV-LX40/LX50

SPECIFICATIONS System Format VHS NTSC standard Video recording system Rotary head helical scanning FM system Video heads Double azimuth four heads Video signal

16 W

LINE OUT

(SLV-LX50 (CL/CS/MX/PA/PC/VZ) and

VIDEO OUT, phono jack (1) Output signal: 1 Vp-p, 75 ohms, unbalanced, sync negative AUDIO OUT, phono jacks (1 each) (SLV-LX50 and LX40), (2 each) (SLV-LX70S and LX60S) Standard output: 327 mVrms

SP: 33.35 mm/s EP: 11.11 mm/s LP: 16.67 mm/s, playback only Maximum recording/playback time 9 hrs. in EP mode (with T-180 tape) Fast-forward and rewind time Approx. 3 min. (with T-120 tape)

Tuner section Channel coverage VHF 2 to 13 UHF 14 to 69 CATV A-8 to A-1, A to W, W+1 to W+84 Antenna 75-ohm antenna terminal for VHF/UHF

Output impedance: less than 10 kilohms

LINE-1 IN and -2 IN VIDEO IN, phono jack (1 each)

Dimensions Approx. 355 x 96 x 288.8 mm (w/h/d) including projecting parts and controls

Timer section Clock Quartz locked Timer indication 12-hour cycle Timer setting 8 programs (max.) Power back-up Built-in self-charging capacitor Back-up duration: up to 8 hours at a time

General Power requirements 110 V AC to 240 V AC, 50/60 Hz (SLV-LX70S (CL/CS) and LX50 (CL/CS)) 120 V AC, 60 Hz (SLV-LX70S (MX/PA/PC/VZ), LX60S (MX), LX50 (MX/PA/PC/VZ), and LX40 (MX)) Power consumption

Input and outputs

5°C to 40°C (41°F to 104°F) Storage temperature –20°C to 60°C (–4°F to 140°F)

Load impedance: 47 kilohms

NTSC color, EIA standards Tape speed

SLV-LX40 (MX)) Operating temperature

Mass Approx. 3.6 kg

Supplied accessories Remote commander (1) Size AA (R6) batteries (2) 75-ohm coaxial cable with F-type connectors (1) Audio/video cable (1) (3-phono to 3-phono) (SLV-LX70S and LX60S only) Plug adaptor (1) (SLV-LX70S (CL/CS) and LX50 (CL/CS) only) Design and specifications are subject to change without notice

ENERGY STAR® is a U.S. registered mark. As an ENERGY STAR® Partner, Sony Corporation has determined that this product meets the ENERGY STAR®

17 W (SLV-LX70S (CL/CS/MX/PA/PC/VZ) and SLV-LX60S (MX))

VIDEO CASSETTE RECORDER

Input signal: 1 Vp-p, 75 ohms, unbalanced, sync negative AUDIO IN, phono jacks (1 each) (SLV-LX50 and LX40), (2 each) (SLV-LX70S and LX60S) Input level: 327 mVrms Input impedance: more than 47 kilohms

—1—

SERVICE NOTE 1. ERROR CODE INDICATION • Error codes are indicated using the lower 5 digits in the fluorescent display tube. “At this time, Colon “:” between character is not indicated.”

Mode code indication when the error has occurred. Error code

ERROR CODE 0 No error 1 Cam encoder error Loading direction 2 Cam encoder error Unloading direction 3 T reel error 4 S reel error 5 Capstan error 6 Drum error 7 Error on initializing 8 Cassette loading error 9 Reserve

MODE CODE 0 Power-on eject 1 Power-on initial 2 Power-off eject 3 Power-off stop 4 FF 5 REW 6 REC 7 REC- pause 8 Power-on stop 9 PB

10 11 12 13 14 15 16 17 18 19

FWD x1 FWD x2 CUE PB-pause RVS-pause RVS x1 RVS x2 REV Power-off initial Mecha. error (Power off)

—4—

20 21 22 23 24 25 26 27 28

REW play Cas. loading Tape loading Power-off loading Mecha. error (Power on) Power-on eject initial Power-off eject initial APC REC Cas. loading (No auto PB check)

SLV-LX40/LX50/LX60S/LX70S

4-1. FRAME SCHEMATIC DIAGRAM

1

2

3

4

5

6

7

8

9

10

11

12

13

14

A

B

C

D

E

F

G

H

I

J

FRAME SCHEMATIC DIAGRAM 4-3

4-4

SLV-LX40/LX50/LX60S/LX70S MA-405 (REC/PB HEAD AMP) SCHEMATIC DIAGRAM – Ref. No: MA-405 board; 1000 series – • See page 4-21 for waveforms.

1

2

3

MA-405 BOARD(1/7) REC/PB HEAD AMP(RP BLOCK)

A

XX MARK:NO MOUNT

4

5

6

7

8

9

10

11

12

NO MARK:REC/PB MODE R :REC MODE P :PB MODE

13 CN270 4P JL271

5

JL272

4

JL273

C285 0.01u

JL274

IC260

B+

3

D

AUDIO CH1 H AUDIO REC

2 1

AUDIO CH2 L

3 2 1

JL266

R270 470

JL270

AUDIO CH1

C271 0.01u B

C272 0.1u B

12

H.SYNC

11

AGC DET

13

R2.5/ P0

R1.6/P2.0

IC260 AN_GND

10

ATT

VCC

R273

R3.2/ P2.5 C283 0.01u B C281 0.01u B

R4.1/ P0 R3.4/ P0.4

0.60mm

JL279

R274 3900

JL280 R267 0

JL281 JL282

C282 B 0.01u

R3.4/ P0

1k

9

AGC

AMP VCC

AN_GND

VA1

REC CURR ADJ

VA2

REC H

VA3

REC C

VA4

REC Y RF

VA5

PB RF

VS3

COMP SYNC

VA7

TRICK H

8

HA SP

7

C284 0.22u B

6

R0/P2.6

JL284

R277 22k

0.3

JL286 1.8

JL287

RS1

RF ENV

VS6

RF SWP

VS7

HA SWP

RS2

ENV SW

2 MA-405 (3/7) (SEE PAGE 4-11)

R278 22k

0 R0.2/P0.5

R279 22k

SW30

R2.0/P4.2 H

L

LA70011

C267 0.1u B

3

B+

C286 100p CH

C268 XX

SW_5V AN_GND

AUDIO CH2

1

E

1 MA-405 (2/7) (SEE PAGE 4-9)

R0/P1.6

5

15

R1.6/P2.0

JL268 JL269

16

R1.6/P2.0

JL267

JL278

4

4

JL262

4

CHECK

2

FE

4

5

R3.9/P2.0

RF SWP

1

AN_GND

5

JL263

PB OFF SW30 AMP REC SP OFF EP OFF EP TO HA H.SYNC HA ENVELOPE CONT DET

6

R2.5/ P0

C275 0.01u B

PB RF

3

R276 6800

COMP

SP CH1 F

R3.8/ P2.0

BIAS

6

JL265

C276 0.1u B

CURRENT AMP

7

R271 470

BIAS

SP CH2 S

JL264

VCC

7

JL261

VCC

8

10k

SP CH2 F

AMP

9

8

CURRENT AMP

10

EP CH1 F

17

EP CH2 S

9

PB OFF REC SP OFF EP OFF AMP 10k

SP CH1

10

JL260

20

C

11

R3.9/ P2.0

21

EP CH2 F

C278 0.022u B

22

SP CH2

R1.4/P0

18

}0.5% C279 0.1u B

CN260 11P

R4.2/ P4.9

19

R272 1800

ALL 5V

14

4.9

PB ON REC OFF

EP CH1

23

6

JL277

3

L270 100uH

C280 100u 10V

HF ADJ

2

B+

VIDEO REC/PB AMP

24

B

1

3

EP CH2

11

14

MA-405 (7/7) (SEE PAGE 4-19)

2 AU1 AUDIO CH2

LX60S/LX70S

AU2

AUDIO REC

AU3

AUDIO CH1

AN_GND

4 MA-405 (4/7) (SEE PAGE 4-13)

AU_PB_RF

VIDEO HEAD

F SIGNAL PATH VIDEO SIGNAL CHROMA

Y

Y/CHROMA

AUDIO SIGNAL

(POWER, EJECT SWITCH)

(

MA-405 VIDEO, AUDIO, SERVO/SYSTEM CONTROL, TUNER, POWER SUPPLY

)

REC PB

FJ-32 (LINE 2 IN)

DI-80 (DIAL TIMER)

REC/PB HEAD AMP 4-7

4-8

MA-405(1/7)

SLV-LX40/LX50/LX60S/LX70S MA-405 (Y/C, AUDIO PROCESSOR) SCHEMATIC DIAGRAM – Ref. No: MA-405 board; 1000 series – • See page 4-5 for printed wiring board. • See page 4-21 for waveforms.

2

3

MA-405 BOARD(2/7) Y/C, AUDIO PROCESSOR (VA BLOCK)

6

7

8

9

10

B+

C242 0.01u B

58

INV AMP

P

84

OSD V OUT

C204 C205 1u 0.01u B B

C202 0.01u B

3.7 1.3

R203 330

Q201 2SC2712Y-TE85L BUFFER

D7 D8

R204 8200 R210 1500

C5

H C574 10u 16V

1.8

R206 XX

5.0

16

15

14

13

12

11

REG

GND

SUB

SUB

SUB

SUB

35 34 33

JL209

32

3.0

C222 10u 16V

R576 100k

JS323 0.60mm

HV1 NORMAL_OUT

E7

9

24

25

26

27

R222 XX

R221 R220 0 0

C219 XX

C213 390p

28

29

HV2 NORMAL_IN

R219 100

AUDIO_R_OUT

30 3.4

23

0.3

22

1.8

21

0

20

HV4 AUDIO_L_OUT HV5

11

L1_AUDIO_R HV6

MAIN OFF

C576 100u 10V

JS324 0

C221 1u B

D8

HT3

E8

C3 C217 0.022u B

R211 4700 C216 1u 50V

R212 560

C2

C252 0.01u

C6 C4 C5

R2.4/ P2.1 C1

Y/C, AUDIO PROCESS 4-9

HM4 L2_AUDIO_L RF_AUDIO_OUT

VS1

AUDIO_MUTE

VA1

REC CURR ADJ

VA2

REC H

VA3

REC C

VA4

REC Y RF

VA5

PB RF

R209 5600

R208 0

JL220

D7

HM5 JS325 0

FSC_FOR_ADJ

PB

JL217

9 MA-405(4/7) (SEE PAGE 4-13)

L2_AUDIO_R C220 0.01u B

REC

JL218

L1_AUDIO_L

LX40/LX50

JL219 C575 0.01u B

8 MA-405 (5/7) (SEE PAGE 4-15)

HF_GND

E5

JL222 C573 0.33u B

TU AU MONO

LX40/LX50

31

VIDEO AGC

5.0

R571 R572 470 470

TU VIDEO IN

HT1

HT3 RF AUDIO

JS327 xx

VIDEO SIGNAL

10

VT2

JL368 E3

SIGNAL PATH

DATA

CLK

MONI 2

9 JL572 5.0

8 JL571

7

R570 10k

C572 4.7u 50V L570 100uH

MONI 1

FIL ADJ

6 1.1

5 4.9

4 1.8

2.3

2.9

3

VCC

Y OUT

C OUT

IC570

JL570

2

JS321 xx

AN_GND

R1.8/ P1.4

IN

VS15 RF VIDEO

E1

C223 22u 16V

1.5

CHROMA

1

MA-405(2/7)

JL207

C224 0.1u B

R1.7/ P0

AFC FILT

R0.1/P1.5

19

2.3

18

JL208

41 40 39

C225 1u 50V

10

4.6

17

SW GND

OUT

C226 0.1u B

R2.1/ P0

HV3

4.6

16

AGC TC2

R

2.1

2.6

17

ARC

B+

2.4

1.9

1.8

2.8

4.1

18 Y IN

2.6

IC570

19

C IN

LA7277M-TLM

20

C228 C227 47u 16V 0.1u

C578 R574 0.01u 1k R573 B 8200 C577 0.01u B

R575 4700

1.8

C571 1u B

C570 0.01u B

I

Q202 2SC2712Y-TE85L BUFFER

L203 10uH

B+

R

P

15

R207 XX

VS15

J

14

C210 0.1u B C251 0.1u C212 XX B

VS13

CTL_Y

B

L

LX60S/LX70S AUDIO

C231 47u 16V

JL206

C209 47u 16V

13

PB-H

3.0-3.7

12

3.1

11

C215 10p

CTL_X

C229 0.1u B

R3.2/ P1.3

VIDEO

R2.2/P0.3

SYNC DET

JL204

10

Y GND

R3.1/ P2.5

VIDEO PEAKING

9

R2.4/ P1.6

8

2.2

7

2.0

R201 330 C206 0.1u B

R223 680

6

M-Em FIL

R2.4/P1.6 JL203

5

1.1

4

C4

VIDEO OUT

3

Y-Vcc

N.L FILT

2 3

1

6dB AMP

R

SERIAL DECODER

CLAMP EQ CTL

CLAMP

L204 100uH

D2

VS12

CLAMP

N.L De-EM

DHP NC

D4

VS11

FMAGC DET

R0.8/P1.8

R0/ P2.5

2

Chara INS.

CLAMP

P

SUB LPF

D5

ARC CLK ARC DATA

CNJ562

C3

VS8

Y/C MIX

DETAIL ENH

DEMOD

R205 100k }0.5%

VS6

C ROT

R

SYNC SEP

L202 100uH

1

C253 39p

R231 47k R224 47k

D5 RF SW P

REG

R213 1k C230 0.1u F

4.1 R

P P

8

C211 33p

BAL TC1

R202

I2C DATA(VIDEO) HS3

DOUBLE LIM

PB EQ

C6

6

S

5.0

ACC DET FILT

L207 220uH D4

CLAMP

FBC

KIL B.D.

N.L EMPH

Main EMPH

N

D2

JL215

R

P

PIC CONT

SQPB EQ

FM AGC

JL213

I2C CLOCK(VIDEO) HS4

FM MOD

R2.4/P2.0

TRICK-H

7

JL214

P

C232 1u B

5.0

1.8

REC EQ

JL201

VS2

SW-Vcc

38

90 91

RF SWP

Q203 2SA1162Y-TE85L BUFFER

C233 10u 16V

3.0

13

HASW

15 Q VD

R

FBC

IC201 LA71053M-MPB

VS1

P

ACC AMP

92

C.ROT

12

A MUTE

B-UP AMP

1/2

C214 180p

C201 0.047u B

CLAMP

KIL

C208 0.01u B

R1.6/ P2.0

1

43

85 86 89

0.8 C1 4.2

F

VCA

R

L201 39uH

2

1.9 LPF

A MUTE

3.1

3

CTL (Y)

P R

C-LPF

2.0

4

GND (AU)

CTL (X)

JL321

YNR

JL560

R P

P

JL202

5

N.C

B+

C234 1u B 2.1

4.9

REC BGA

Main CONV

Sub BPF

C207 39p

A HEAD PB

60/50

R

2.0

A HEAD REC

BPF1

D561 RD8.2ES-T1B

1.4

C563 470u 10V

C564 XX

D562 XX

2.2

R564 68

R565 75

D563 XX

1.4 1H D.L

R

R

REC-H

B

C235 0.1u B

9.0

2.0 0.8

R3.3/ P0.2

C363 4.7u 50V

JL322

Sub COVN

R1.6/P1.7

6

C2

P

R

PB-LP.SP

820

7

GND (AU)

HEAD SWITCH

Y/C PROCESSOR AUDIO PROCESSOR

C562 47u 25V

C561 0.01u B

C236 0.01u

2.0

P

2.3

AERASE HEAD

JL323

JL305 R4.1/P0

P

PB BGA-A

R561 330

3.1 EQ AMP

2.6

ACE HEAD

0

R371 18k

IC350

REC

R2.4/ P0.3

CN350 7P

AU_GND

E

P

93

R367 R364 R365 5600 2.3 270 330k C368 R366 R3.1/ 0.01u 8200 P2.3 B R369 C366 2.3 820 1u 50V

94

5

2.4

95

C362 47u 16V

R0.8/ P0

C365 0.01u B

96

C364 10u 16V

97

6

ACC AMP

PB BGA-B

BPF2

98

7

4

2.4

8

3

AUTO BIAS

2.4

99

2

R0.8/P0

B

REC REC-EP.LP PB-EP

100

BA7755AF-E2

1

Q350 2SC1815GR-TPE2 BIAS SWITCH

IC350

1

C361 XX R1.6/ P5.0

CLK IN

LPF RA

Vref

R0.6/P0

R1.6/P5.0 87

JL306 5.0

2 FE HEAD

C359 0.001u

R3.3/ P0.2

3

C360 2700p

R363 18k

R370 12k

0

GND (AU)

2.4

3.2 C237 0.01u B

IC201

TH

88

C370 XX CN351 3P

JL307

R362 1200

R563 R562 180 150 1/4W 1/4W

51 4Fsc

0.8

2.4

B+

52

1H/2H D.L

D.L EQ

REC APC

53

49

REC APC

54

R577 100k

ALC

R

LINE AMP

A-GND

REC APC

55

2.6

VCO

MUTE

2.5

2.5

56

48

VXO1

57

BUFFER

59

4.9

3.4

60

Q561 2SB709A-QRS-TX

61

4.9

C243 0.01u 3.3

3.3

62

50

63

N.C

47

64

3.3

3.4

65

4.9

C248 0.047u B

JL210 X201 3.579545MHz

66

L561 100uH

46

VXO2

KIL DET

67

45

L1

68

L2(R)

HM5 C255 0.1u B

44

69 N.C

AU_GND AU_GND

42

70 N.C

TU

REC AMP

82 83

C358 1u 50V

71

MA-405(6/7) (SEE PAGE 4-17)

B+

SLD

2.3

R359 4700

72

7

L2(L)

HM4

R225 680

37

R358 1800

73 N.C

L2

Vref

0

74

L2_VIDEO

L2_V

1.6

LX40/LX50

36

LX40/LX50

75 A-Vcc

E1

2.3

Q204 2SD601A-QRS-TX

C203 0.001u CH

JL205

C380 0.047u PET

76

C238 47u 16V

CCD GND

C

77 ALC DET

R357 8200

C371 560p

78

5.0

C239 0.01u B

C240 47u 16V

C246 0.01u

R214 1500

C254 1u B

LX60S/LX70S

AN_GND AN_GND

C245 1u B

NTSC:H

BIAS OSCILLATOR TRANSFORMER R383 180

79

LX40/LX50

L205 100uH

L206 100uH

CCD VCC

80

R352 68k 1/4W C350 1u 50V

C241 0.01u B

C-Vcc

T380

C353 1u

3.8

C357 4.7u 50V

81

4

5

6

R372 560

MUTE SWITCH

C355 1u

2.5

Q351 2SC2712Y-TE85L

16

2.2

8

7

C356 33u 25V

C250 0.047u B

R215 8200

C247 0.022u B

2.1

1/10W

C384 XX

0.60mm JS303

R216 1800

JL211

R356 5600

R355 68k 1/4W

D352 1SS119-25TD

E3

E5

R354 2.2M

LX40/LX50

C249 1u B

C-GND

1

D351 1SS119-25TD

1.9

C369 4.7u C579 XX

14

C351 R351 47u 5600 R353 25V R350 5600 68k

JL301

B+

JL320

C383 47u 16V

JS301 0.60mm

C244 1u B

JL304

L380 100uH

C354 10u 16V

5.0

R380 47

R373 1k 1/4W

C352 0.1u

LX40/LX50

2.3

R381 3900

C382 0.01u

L350 XX

B+

2.3

C381 0.01u

JL302

R4.7/P5.0 R1.8 /P5.0

JL303

JL308

Q380 2SD1620-TD BIAS OSC

3

B+

E7

E8

B

FE HEAD

14

R :REC MODE P :PB MODE

B+ R1.7/P5.0

MA-405 (3/7) (SEE PAGE 4-11)

13

B+

R382 1

G

12

B+

SW_5V AU_GND SW_12V

D

11

AN_GND

AN_GND

5 MA-405 (7/7) (SEE PAGE 4-19)

5

XX MARK:NO MOUNT NO MARK:REC/PB MODE

2

A

4

HF_GND

1

4-10

Y

Y/CHROMA

AUDIO SIGNAL

VS3

COMP SYNC

VA7

TRICK-H

1 MA-405 (1/7) (SEE PAGE 4-7)

SLV-LX40/LX50/LX60S/LX70S MA-405 (SERVO/SYSTEM CONTROL) SCHEMATIC DIAGRAM – Ref. No: MA-405 board; 1000 series – • See page 4-5 for printed wiring board. • See page 4-21 for waveforms.

1

2

3

MA-405 BOARD(3/7) SERVO/SYSTEM CONTROL (SS BLOCK)

A

4

5

XX MARK:NO MOUNT NO MARK:REC/PB MODE

6

7

8

9

10

11

12

13

14

R :REC MODE P :PB MODE

OSD_VCC

JL110

D_GND MTR_GND

10

AN_GND

MA-405 (7/7) (SEE PAGE 4-19)

B+ B+ B+ B+

B+ B+ B+ B+

SW_5V D_6V SW_12V MTR_12V

JL114 C146 2200p B

R143 4700

JL111

CTL

P CONT M12 PS1

CTL_Y

6

CTL_X

MA-405 (2/7) (SEE PAGE 4-9)

JL112

JS101 0.60mm M2

M1

M7

B

M6

P CONT SW12 PS2 D109

D163 XX

MPG06D-6052PKG3

JS522 0.60mm REMOCON MS1 M1

FUNC KEY1 MS2

S102

M2

FUNC KEY2 MS3 S CLK0 MS4

MA-405 (6/7) (SEE PAGE 4-17) S OUT0 MS6

B+ C143 22u 50V

M6 C142 0.022u B

MODE2

JL116

MODE1

C186 XX

JL117

GND

C185 1u S6

JL118

S7

JL120

29 R170

C164 C165 C168 24p 24p 100u 10V

B+

IN 2

VCL

VCH

V REF

VCC 1

VCC 2

CAM(+)

4

5

6

7

8

9

10

JS103 XX

JL123 JL106

SW 5V

1

2

CAP RVS

2

3

CAP FG

3

4

CTL-REF

4

5

CAP VS

5

6

LIMITER

JL104

6

7

MTR 12V

7

JL125

8

MTR_GND

8

9

AN_GND

9

1

CAM(-)

1

2

CAM(+)

2

3

CAM(+)

3

M M902 CAPSTAN MOTOR

L101 2.2uH T3

0

T2

R507 470

JL501

L501 100uH

R102 15k PH102 GP3S120S T.REEL FG D101 XX

C102 0.001u B

C510 0.1u B

PH101 GP3S120S S.REEL FG

C513 Q502 0.001u 2SA1162Y-TE85L B BUFFER 1.8 2.5 R513 470 1/4W R512 0

C101 0.001u B

R103 15k

R104 22k

4.9 C103 0.001u B

13.5

REC PROOF

MA-405 (7/7) (SEE PAGE 4-19)

S13

S15

R105 22k 1/4W

JL132

R101 470 1/4W

S16

B+

B+ C509 3900p B

JL128

MTR_GND2 S101

JS161 0.60mm

5.0 1.8

10

MTR_GND2

S14

C508 1u B

R508 1500

2.0

M M903 LOADING MOTOR

R509 1M

C507 680p CH

JL101

C109 0.1u B

C108 0.1u B

S18

21 C504 0.001u CH

C107 1u F

C106 47u 16V

T4 0

CN103 3P

JL102 C110 XX

JL134

R502 0

M M901 DRUM MOTOR

CN102 9P 1

S11

R118 R119 47k 15k

B+

V1

4.9

2.6

13.5

4.8

2.2

R121 470

M3

R187 0

2.0-3.1 JL130 4.9

1.9

1

0.2

IN 1

3

6.3

CAM(-)

2 0.2

1

JL142

0

MTR 12V

C189 XX

MTR GND

R188 6800 R189 3300

R192 1k

JL141 R185 0

R191 1k

JL140

0

2

1

LB1943N

3.1-3.9 R183 4.6 0

4.9

JL107

JL124 C192 XX

LOADING MOTOR DRIVE

C514 0.001u B C511 0.1u F C512 100u 10V

OSD GND

S9 R112 4700

R117 470

JL170

4.9

D VS

JL109 JL108

IC101

S10 JL139

4.9

3

2

R106 39 1/4W R107 39 1/4W

4.9 C104 0.001u B

1.6

C105 330u 6.3V

D102 XX

D103 GL528V1 T/S.LED 0.4 R111 2200

R120 1k 1/4W

Q103 2SC1815GR-TPE2 LED DRIVER

C502 0.01u B C500 C501 15p 15p

JS520 XX

C171 0.33 5.5V

JL500

B+

I

6 MA-405 (2/7) (SEE PAGE 4-9)

L162 22uH

B+

ARC CLK VS11

C174 XX

JL129

SIGNAL PATH REC

REC/PB

PB

DRUM SPEED SERVO

ARC DATA VS12 D161 MPG06D-6052PKG3 L161 22uH MM1256XF-BE

4

1

6

3

2

VCC 1

WP

2

3

OUT 2

1

4

VCC 2

5.0

8

5

OUT 1

CLK

7

R178 220k

DATA

4.8

5.0

4.9

R504 1k

5

5.0

5.0 C162 0.1u F

IC161 EEPROM

C505 10p CH

R505 680

B+

DRUM PHASE SERVO DRUM SERVO (SPEED AND PHASE) CAPSTAN SPEED SERVO

R179 470k

4.8

JL186 C175 XX

R503 1k

6

JL185

JS163 0.60mm

M24C04-WMN6T JL162

7

Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

8

J

D162 MPG06D-6052PKG3

V7

V6

S11

3300

2.6

4

D PG

C187 1u F

C188 1u B

R109 47k

B+

2.7

5

D FG

3

S10

S5

19

OSD V IN 1.8

SP

LPF

NUB

OSC OUT

OSC IN

I2C CLK EEP

JL169

R195 0.60mm

S17

4.8

R123 XX

R110 47k

R190 0.60mm

0

31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

R194 10k

0.1-4.9 JL126 0.1-4.9

JL122

MTR GND

4

C191 XX

C114 XX

S8

JL131 Q102 PT380F3 SUPPLY END SENSOR

WHITE LEVEL/ LECHA

REC PRF

51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80

DMS -

DMS +

1.4

2.3

2.3

5.0

4.9

5.0

OSD V OUT

MODE1

R193 0

H

OSD Vcc

C112 0.01u B

S17

JL136

JL138

JL137

5.0 F MONO

MAIN/SAP

SAP

CAP FG

STEREO

AMP Vss

DRUM FG

DRUM PG

RC CHECK

AMP Vref IN

AMP Vref OUT

HLF

MODE2

R500 1k

4

VHOLD

MODE3

C503 4700p B

RESET

C VIDEO IN

R114 10k R113 10k

S18

5

B+

PS101 ICP-N5

JL127

CN101 5P

JL119

C190 47u 16V

B+

Q101 PT380F3 TAKE END SENSOR

R177 470 1/4W JL135 5.0

2.3

1/4W 470 R175

R176 470 1/4W 2.8

2.4

22u C144 50V

R2.8/P2.4

MODE4

JL166

JL161

18 20

2.2uH

3

NUA

17

N.C

L500

2

CTL - IN

CAP RVS

R172 10k

1

S-CLK

CTL + IN

N.C

N.C

C163 0.047u B

D_GND

AMP C

AVcc

PLL CLK

5.0

S-DATA

AMP Vcc

AF REC P

CLK SEL

5.0

PLL DATA

R180 JL133 3300

S14

PLL ENABLE

ANT SEL

ARC DATA

0

S4

END LED

ARC CLK

G

NC

C169 0.1u F

0

AF SWP

2.2

0

S3

A MUTE

2.1

S2

P CONT M12

RF SWP

Vss

T5

ENV SW

4fsc(out)

S1

FLD CS P CONT SW12

SERVO SYSTEM CONTROL

4fsc(in)

5.0

T4

HA SWP

JL164

S8

T3

IC160

C ROT

R174 C167 390 18p R510 0.60mm R511 0.60mm

T2

V-SET CS

REMOCON

5.0

R0/P5.0

S IN0 S OUT0

QVD

1.4

2.5

S CLK0

KKP -

Vcc

2.5

5.0

(OPEN)

CAP ERR

KKP +

C166 15p

S13

T1

CN104

DRUM ERR

I2C CLK

32kHz(out)

V11

4P

P FAIL

26

X161 32.768kHz X160 14.31818MHz

RS2

TS5

S REEL

CBC ON

1.5

ENV SW

TS4

T REEL

I2C DATA

32kHz(in)

2.5

TU AFT

24

CBC SIRCS OUT

JL163

VS7

PLL ENABLE

2.4

4.8

V11

HA SWP

TS3

AF ENV

4.8

0 0.6

TS2

V RF ENV

2.2

2.5

VS6

PLL DATA

JL115

S4

C116 0.01u B

C115 0.01u B

22

23

CLKOUT

RESET

V9

4.9

V4

RS1

PLL CLOCK

T SENS

CAM

0

RF ENV

TS1

S3

JL121

C111 0.01u B

NICOLE

5.0

4.9 R0/ P5.0

RF SWP

TV/VTR

S9

25

28

5.0

LX60S/LX70S V2

T1

13

S SENS

I2C DATA EEP

R164 47k R165 47k

V7

R167 15k 1/4W

MA-405 (5/7) (SEE PAGE 4-17)

FUNC KEY1

4.9

R0.1/P3.2

R166 10k

2

C170 680p CH

R0/P2.5 R160 1k

V6

VIDEO OUT VS13 OSD V OUT VS15

MA-405 (1/7) (SEE PAGE 4-7)

4.9

V4

C ROT VS8

F

S16 V9

R159 100k

V2

Q VD VS2

4.9 7

V1

A MUTE VS1

S15

8

6

C161 0.047u B

9

C113 0.1u B

RF SWP VS6

MA-405 (2/7) (SEE PAGE 4-9)

S6

27

TU AFT FUNC KEY2

4.9

I2C CLK HS4 I2C DATA HS3

CTL AMP OUT

V-SET RESET

4.7

E

MPX MODE

3

T5

DEST

0

C160 0.047u B

MPX MODE HS7

1

LX60S/LX70S

2

R162 1500 1/4W

4

HS5

30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10

AF ENV

R161 10k

5

HS4

MODE3

R115 47k

100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81

6

I2C CLK

JS521 0

R169 10k

HS3

B+

I2C DATA

R116 47k

LX40/LX50

JL160

MA-405 (4/7) (SEE PAGE 4-13)

HS2

R168 10k

12

HS1

AF SWP

2.4

R171 47k R142 1200

L163 22uH

S5 S7

4.8

C141 0.1u F

C145 470u 10V

R2.0/P2.4

C140 100u 10V

C176 0.1u B

AF REC P

MODE4

JL105

R173 XX AN_GND

0.2

M7

4.8

KKP + MS11

2.4

D5V MS10

KKP - MS12

D

JL103

M3

FLD CS MS7

C

S1 S2

MTR_GND

11

C172 0.01u B D_GND

C173 0.01u B

C515 XX

2.5 1.5

CAPSTAN SERVO (SPEED AND PHASE)

Q500 2SB709A-QRS-TX

SERVO REF SIGNAL

IC162 POWER FAIL DET RESET PULSE GEN

SERVO/SYSTEM CONTROL 4-11

4-12

MA-405(3/7)

SLV-LX40/LX50/LX60S/LX70S MA-405 (AUDIO PROCESS) SCHEMATIC DIAGRAM – Ref. No: MA-405 board; 1000 series – • See page 4-5 for printed wiring board.

1

2

3

4

5

6

7

8

9

10

11

12

13

14

MA-405 BOARD(4/7) AUDIO PROCESS (AU BLOCK)

A

XX MARK:NO MOUNT NO MARK:REC/PB MODE R :REC MODE P :PB MODE

LX60S/LX70S JL331

14

SIF

MA-405 (6/7) (SEE PAGE 4-17)

AN_GND JS302

B

JL325 JL326 JL327

SW_5V

B+

XX

B+

2.5

2.5

0.4-0.7

HF_GND 1.7

GND R

N.C.

VCC5V

REC ADJ

5.0

0-5

0-5 SCL

32 31 29

30

C334 0.22u

C335 XX B

28

L

H

ENV DET

0-5 SWP

58

VCC12V RFC OUT

2.1

RPVCC5V

25

56 57

OUT L

OFF PB IN1 INSW MUTE

C337 0.01u

5.0 PNR Lch

EE moniter

C336 0.1u

26

VCO L

MPX MODE

27

OUT SEL

R2.1/P0.7

ON R/P GND PB IN2

C338 0.01u

60

NA OUT

61

R2.1/P0.7 2.6

RFC AGC

REC OUT

R2.1/P0 20

C339 0.1u AU_PB_RF C340 0.015u

19

IN SEL

C341 10u 16V

0.4-0.7

2

VS1 HF_GND

IC301

H

AUDIO_REC

AU1

3

4

5

7

AFM AUDIO PROCESS ONLY LX60S/LX70S

8

9

10

11

12

R312 XX

13

R315 XX

14

15

R317 XX

4 MA-405 (1/7) (SEE PAGE 4-7)

AUDIO_CH2 AN_GND

C342 10u 16V

JS304

16 2.5

1

L2 L

}10%

JL324

L1 L

*C316 3.3u 50V

0

JL319

C306 0.022u

0

R307 XX

JL318

GND L

6

JL316

INREF L

JL315

JL317

AUDIO_CH1

AU2 AN_GND

17

0.3

JL314

64

2.5

JL313

AU3

2.5 2.5

18

JL312

dbx NR.

NA IN

63

R308 56k

C303 0.1u

62

2.5

2.2

AUDIO MUTE

+

ON

6

XX

24

GND

L2 R

HM4

2.2

49 51

{ L+R REF

R334

5.0

L1 R

L2_AUDIO_L

R322 XX

FM LIMITER

0

HM5

6

HS2 AF_SWP

33

NOISE DET

0

L2_AUDIO_R

34

23

2.2

INREF R

HV6

35

1.8

BPF

2.2

HV5

L1-AUDIO_L

36

OUT R

VREF

L1_AUDIO_R

37

ON

INSW MUTE

(L-R)/SAP Switch

2.5

HV2

38

R2.1/P0

JL311

HV1

39

VCO R 6

12

FSC_FOR_ADJ

NORMAL_IN

40

HS5 AF_ENV

JL330

R323 0

VCC5V

59

C312 10u 50V

R306 220

JL310

NORMAL_OUT

41

22

R305 220

F

MA-405 (2/7) (SEE PAGE 4-9)

12 MA-405 (3/7) (SEE PAGE 4-11)

21

C310 10u 50V C311 2.2u 50V

C313 10u 50V C315 10u 50V C314 10u 50V

HT3

42

SDA

2.2

C305 47u 25V

Q303 2SC2712Y-TE85L MUTE

HV4

43

OFF

0.66

RF_AUDIO_OUT

44

OFF

52

C309 0.1u

R303 1k

AUDIO_L_OUT

45

PNR Rch 5

0.66

HV3

I2C_CLOCK

C333 0.1u

SAP DEMOD

50

C302 0.01u HF_GND

53

E

R302 1k

Q302 2SC2712Y-TE85L MUTE

46

C330 0.015u

0

54

1.5

D302 1SS119-25TD

Q301 2SA1162Y-TE85L POWER MUTE

AUDIO_R_OUT

I2C_DATA

HS4

HS1 AF_REC

C332 47u 16V

DEM/FILTER

C308 1u

0.66

47

SIF

50V 2.2u C307

R301 1k 1.5

48

IC301 AN3668FBPEBV

55

JS311

D

R321 3300

C326 C328 C329 33u 10u 10u 25V 16V 16V

2.5

C317 0.1u

C343 0.22u

L301 XX

C345 0.01u

R316 33k }5%

L302 XX

C304 47u 25V

C320 R310 R311 4.7u 0 0 50V

C318 C319 3.3u 0.1u 50V

0

C301 0.1u

G

L303 100uH

JL328

MPX_MODE

HS3

JL329

C

9

D301 1SS119-25TD

HF_GND

FSC

MA-405 (7/7) (SEE PAGE 4-19)

SW_12V

JS313

JS312

15

B+

HS7

R320 XX C331 33u 25V

C325 C327 4.7u 1u 50V 50V

C321 C322 C323 C324 0.1u 10u 4.7u 10u B 16V 50V 16V }10%

R313* R314 47k 47k 1/4W 1/10W

R318 R319 47k 47k

I SIGNAL PATH AUDIO SIGNAL REC

J

PB

AUDIO PROCESS MA-405(4/7)

4-13

4-14

SLV-LX40/LX50/LX60S/LX70S MA-405 (TUNER) SCHEMATIC DIAGRAM – Ref. No: MA-405 board; 1000 series – • See page 4-5 for printed wiring board.

1

2

3

4

5

6

7

8

9

10

11

12

13

14

MA-405 BOARD(5/7) TUNER (TU BLOCK) XX MARK:NO MOUNT

DET OUT

AFT

AUDIO OUT

SIF

IF

IF

B+

R704 560

C701 47u 25V JL717

JL715

JL716

VS15

RF V OUT

8

21 22 23 24

JS753

B+

B+

A5

R703 390 1/4W

NC

10 11 12 13 14 15 16 17 18

B+

C

30V

NC

5V

NC

DATA

CLOCK

6

ENABLE

5

A2

VIDEO IN

4

A3

CONT

3

A4

5V

2

A1

B

CH SW

TU701

AUDIO IN

A

TU VIDEO IN

VT2

TU AUDIO MONO

HT1

MA-405 (2/7) (SEE PAGE 4-9)

LX40/LX50

RFCH

C705 XX

S701

D

C796 10µ 16V C709 100u 16V

C797 0.033u 25V B

C702 0.01u B

C710 0.01u B C712 100u 16V

3CH

+30V

R712 0

2.2uH L703

RD33ES-T1B3 D702

4CH

2.2uH L704

+30V

B+

C706 0.01u B

C704 50V 4.7u

R724 470k 1/10W JL711

R723 560 1/4W

16

E

MA-405 (7/7) (SEE PAGE 4-19) SW_5V

C794 0.22u B

B+ AN_GND

AN_GND

F

TV/VTR

TS1

PLL CLOCK

TS2

R701

1k

R709

1k

1/4W

JL701

A1

JL702

A2

JL703

A3

JL704

A4

JL705

A5

470p C798

G

13

PLL DATA

TS3

PLL ENABLE

TS4

R710

1k

R711

1k

MA-405 (3/7) (SEE PAHE 4-11)

Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

C707 2200p B

470p C799

470p C800 TU AFT

H

TS5

SIGNAL PATH

8

JL713

MA-405 (2/7) (SEE PAHE 4-9)

RF AUDIO OUT

HT3

VIDEO SIGNAL

R702 3300 1/10W

CHROMA

Y

Y/CHROMA

AUDIO SIGNAL

REC

I

PB

14 MA-405 (4/7) (SEE PAGE 4-13)

SIF AN GND

AN_GND

J

TUNER 4-15

4-16

MA-405(5/7)

SLV-LX40/LX50/LX60S/LX70S MA-405 (DISPLAY CONTROL) SCHEMATIC DIAGRAM – Ref. No: MA-405 board; 1000 series – • See page 4-5 for printed wiring board.

1

2

3

4

5

6

7

8

9

10

11

12

13

14

MA-405 BOARD(6/7) DISPLAY CONTROL (FRONT BLOCK)

A

XX MARK:NO MOUNT

AN_GND AN_GND

AN_GND

7

HM5

L2(R)

MA-405 (2/7) (SEE PAGE 4-9)

AU_GND

AU_GND

AU_GND L2(L)

HM4

L2_VIDEO

L2_V

B

CN401 9P

FJ-32 BOARD CN801 (SEE PAGE 4-24)

C

JL464

9

L2_VIDEO AN_GND

8

L2(L)

7

AU_GND

6

L2((R)

5

AU_GND

4

EJECT

3

POWER

2

D_GND

1

R440 12k

JL465

R409 1500

R410 2200

R412 12k

R411 2700

R413 15k

JL467 JL402 JL469 JS401 0.60mm

JL466

ADJ

JL438

JL439

JL440

JL441

S404

S406

JL468 JL427

JL461

JS403 0.60mm

JL463

S412

S408

GND

JL462

R415 1500

D

R416 1500

R417 2200

ESU

CH+

REW

REC

R441 33k

R418 2700

R407 33 JL443

JL444

JL445

S411

S410

S413

STOP

JL447

JL446

S405

S409

PLAY

FF

PAUSE

CH-

JL460

S429

SEARCH ND420 1

E

F-

S CLK0 MS4 FLD CS MS7 D 5V MS10

4.9 4.9 2.0-3.1 D_GND C422 47u 16V

L420 22uH

G10 LED1 S18 LED2 S17 LED3

IC404

LED4

VEE S16

DISPLAY CONTROL

OSC

S15 DOUT

IC404 UPD16315GB-3BS

DIN

S14 S13

CLK S12 STB S11 KEY1 S10 KEY2

FS16 FS15 -13.3

FS14

R-8.6/P-6.2

FS16

-6.3

FS15

-4.0-0.6

FS14

-13.1--10.8

FS13

-13.1--10.8

FS12

-13.1--10.8

FS11

-10.8--3.9

FS10

FS13 FS12 FS11 FS10 FS9 FS8 FS7 FS6

JS420 XX

FS5 S9

S8

S7

S6

S5

S4

S3

S2

FS4 S1

VSS

C423 0.01u B

H

VDD

KKP - MS12

FS3 FS2

12 13 14 15 16 17 18 19 20 21 22

I

KKP -

2

KKP +

1

JL478

D420 RD5.6ES-T1B2

B-

B-

-13V

17 MA-405 (7/7) (SEE PAGE 4-19)

J

F+

C425 10u 16V

FD_GND

R427 1500

C426 XX

C424 0.1u F

AN_GND

AN_GND C427 0.1u B

DISPLAY CONTROL MA-405(6/7)

4-17

4-18

4 5 6 8 30 29

-3.9--1.6 FS9

FS8 -10.8--6.5

FS7 -10.8--6.5

FS5

JL477

FS6 -10.8--6.5

-8.5--3.9

-1.7--0.6

-13.1

-10.8

B+

JL410

FS4

3

JL409

FS3

SEARCH

JL408

-6.2--1.7

4

FS2

DI-80 BOARD CN901 (SEE PAGE 4-25E)

5

FS1

D_GND TIMER SET

4.9

FS1 CN402 5P

7 FG6

9

G9

G8

G7

G6

G5

FG5

27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10

-11.1

-11.0

-11.0

-11.0 G4

G3

G2

G1

FG4

23 24 25 26 27 28 29 30 31 32 33

6

1.8 7

S OUT0 MS6

2 5

JS453 0

R425 82k

4

3

R445 1k

R422 1k R423 1k R424 1k

KKP + MS11

0

8

MA-405 (3/7) (SEE PAHE 4-11)

1

SLR-342DCT31 D421

9

C406 100u 10V

FUNC KEY2 MS3

11

VDD

VSS

1

R402 47k 1/4W

FUNC KEY1 MS2

-11.0

4.9 OUT

2

44 43 42 41 40 39 38 37 36 35 34

C405 0.01u B

REMOCON MS1

G

FG3

11 10

L421 XX

3

R401 100

GND

VCC

F

FG2

JL401

JS402 0.60mm

-11.0

FG1 REMOTE CONTROL RECEIVER

C421 XX

G1 G2 G3 G4 G5 G6 N.C N.C P16 P15 P14 P13 P12 P11 P10 P9 P8 P7 P6 P5 P4 P3 P2 P1

F+ F+

FLUORESCENT TUBE INDICATOR

FG6

FG4

FG5

FG3

B+

FG2

FG1

IC403

F-

2

IC403 SFH5110-40

SLV-LX40/LX50/LX60S/LX70S MA-405 (POWER SUPPLY) SCHEMATIC DIAGRAM – Ref. No: MA-405 board; 1000 series – • See page 4-5 for printed wiring board.

1

2

3

4

5

6

7

8

9

10

11

12

13

14

MA-405 BOARD(7/7) POWER SUPPLY (PS BLOCK) XX MARK:NO MOUNT NO MARK:REC/PB MODE

B

L660 68uH

JL618 13.5 SW_5V

JS606

ET601

C601 0.1u

AC IN 110,120,220V 50/60Hz

R600 XX

C605 120u 200V

C602 470p 250V

R602 150k 1/4W

8

11

7

14

6

VDR601 XX R605 1500 1/4W

C606 820p

R604 12k

12

4

15

3

16

3

4

5

6

R650 0.60mm

ET600 TERMINAL GROUND

D623 C608 2200p 800V PP

MTZJ-T-77-18B

C610 1200p 10V

C615 820u 25V

C624 47u 50V

R641 10 1/4W

JS614 XX

XX

AK04V0

C632 XX

JS630 XX

C627 0.01u B C626 47u 50V

JS631 XX D666 1SS119-25TD D661 1SS119-25TD

0.60mm R642

D624 D1NL20U-TA2

R647 68k

R651 39k

R607 8200 1/4W

G

L606 1uH C636 470u 16V

C630 0.01u B

R648 2200 PH600 PC123FY2 4 1

R616 R618 47 1/4W 220 1/4W

R615 2200 C612 1u 50V

2

C613 0.12u PET R617 1k 1/4W

H

2

3

4.7

GND 3

JS617

MTR_GND2 JL617

C616 470u 25V JL620

2.4

C629 470u 10V

R669 3300

R613 120 1/4W

P CONT M12

PS2

P CONT SW 12

MA-405 (3/7) (SEE PAGE 4-11)

D_GND

C665 22u 16V

AN_GND D_6V

JL613

C662 22u 50V

0.60mm JS628

OSD_VCC C664 47u 25V

SW_12V

JS625 XX

C666 47u 16V

0.01u B

R678 220 1/4W

JS605

C660 47u 16V

JL612

R679 220 1/4W

Q673 10.2 2SC3311A-RTA +B SWITCH

AU_GND HF_GND

JS604 0

6.5

R680 1k 1/4W

0.60mm

JL611 JL625

5.8

R643 XX

JL614

-13V F+ F-

5.9

17 MA-405 (6/7) (SEE PAGE 4-17)

D_GND

5.1

Q662 2SD2394-EF 5V REG

MA-405 (2/7) (SEE PAGE 4-9)

JS603 0

R676 1k 1/4W

5.8

AN_GND

AU_GND

PS662 1.6A C669

5

SW_5V AN_GND

5.9 R612 2k ±0.5%

10

SW_5V PS1

SW_12V C611 470u 16V

JS608 0.60mm

L603 1uH C631 0.01u L604 B 1uH

MTR_GND MTR_12V

4

AN_GND 5.8 5.2

Q674 2SD1664-T100-R OSD VCC REG

C672 0.1u F

1

IC601 HA17431PA-TZ

IC601

2

MTR_GND2 MTR_GND

JL615

C607 560p

3

JL604

JS616 0

D660 RD5.1ES-T1B2

RD6.2ES-T1B2 D625

JL619

C628

R606 9100

7

L602 22uH L601 22uH

D601 D1NL20U-TA2

2

1

D609 31DQ06-FC5

D605 XX

D602 XX

1

JS601 XX

IC POWER MODULE

F

17

JS602 XX

IC600 MA8910

D612 AU02A-V0

D613

R649 47

IC600

D608 D2S4MF

13

5

R640 10 1/4W C617 XX

10

R603 330k 1/4W

EXCEPT LX50:CL,CS/ LX70S:CL.CS.

C604 470p 250V

D611 AU02A-V0

CONT

CONVERTER TRANSFORMER

R601 3.3M 1/2W D607 RD5.6ES-T1B2

CP601 XX

T600

D603 XX

MA-405 (1/7) (SEE PAGE 4-7)

SW_5V

4.9

VDR600

C603 470p 250V

R668 XX

LF600 R611 1M 1/2W

3

AN_GND

IC660 PQ12RD08

C625 XX

13V

3

12V REG D600 DF06M-6031

12V

NEUTRAL

JL602

D

D_GND JS618 0.60mm

IC660

C600 0.1u 250V

FH601

13.5

1

F600 2A 125V

11.7

LIVE

FH600

C621 22u 16V

R619 XX

MA-405 (4/7) (SEE PAGE 4-13)

SW_5V

R623 3300

0.7

RD16F-T8B1 D614

JL601

HF_GND

R614 1500 ±0.5%

2P

D604 XX

CN600

0

15

SW_12V

TERMINAL GROUND

R622 390 1W

Q601 2SD601A-QRS-TX PWR CONT SW

EXCEPT LX50:CL,CS/ LX70S:CL.CS.

MA-405 (5/7) (SEE PAGE 4-15)

AN_GND

12.8

C661 0.01u B

C

E

Q600 2SB1398-Q(TA).S0 MTR 12V REG

R621 10k 1/4W

C671 22u 50V

16

+30V

13.5

JS609

A

REG

I Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

J

POWER SUPPLY 4-19

4-20

MA-405(7/7)

SLV-LX40/LX50/LX60S/LX70S

MA-405 BOARD (1/7) (R/P BLOCK)

MA-405 BOARD (2/7)

MA-405 BOARD (3/7)

(VA BLOCK)

(SS BLOCK)

7 IC201 2 REC

1 IC260 4 REC/PB

qf IC201 yj REC/PB

qj IC160 el

4fsc (OUT) REC/PB

wd IC160 i;T REEL

4.8Vp-p

V

3.6Vp-p

2 IC260 5 REC/PB

H

8 IC201 7 REC

0.1µsec/div 0.1V/div

3.5Vp-p

H

3 IC260 7 PB

0.1µsec/div 50mV/div

360mVp-p

H

0.5Vp-p

5.0Vp-p

OSC OUT REC/PB

25.3MHz

69.9kHz

4.6Vp-p

ql IC160 t; OSC V IN REC wg IC160 il

DRUM FG REC/PB

50Vp-p 2.2Vp-p

H

ql IC160 t; OSC V IN PB

4.2Vp-p

H

qa IC201 wl REC

SP

4.4Vp-p

1078Hz

0.6Vp-p

V

wf IC160 ij CAP FG

360Hz

wh IC160 o;

4.5Vp-p

DRUM PG REC/PB

4.6Vp-p

30Hz

170mVp-p

5 IC260 0 REC

14.31818MHz

qk IC160 rg

qh T380 6 REC

0 IC201 wk REC/PB

4 IC260 9 REC

3.579545MHz R 460mVp-p

qg IC201 1 PB

9 IC201 wd PB

0.6Vp-p

V

380mVp-p

1.6sec (TAPE TOP)

H

w; IC160 ts

2.3Vp-p

OSD V OUT REC

wj IC160 og CTL+IN

REC

2.2Vp-p 5.0Vp-p 30Hz

H

380mVp-p

6 IC260 qj REC

H

2.1Vp-p

H

AMP OUT w; IC160 ts OSD V OUT PB wk IC160 oj CTL PB

qa IC201 wl PB

4.0Vp-p

0.1µsec/div 1V/div

3.8Vp-p

2.3Vp-p

H

qs

RF SW P IC201 ok REC/PB

2.3Vp-p

H

wa

C VIDEO IN IC160 th REC/PB

30Hz

wl IC160 eh

32kHz (OUT) REC/PB

2.0Vp-p 30Hz

1.6Vp-p 32.768kHz

H

qd IC201 ej REC

H

4-21

3.0Vp-p

ws IC160 ul S REEL

1.0Vp-p

4.8Vp-p 0.9sec (TAPE TOP)

4-22

FJ-32 (LINE 2 IN) PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM — Ref. No. FJ-32 Board: 1,000 Series — There are few cases that the part printed on this diagram isn’t mounted in this model.

FJ-32 BOARD

1

2

3

4

5

6

7

FJ-32 BOARD LINE 2 IN

A

•REF.NO.: 1,000 SERIESR801 0

LX40/LX50

CN801 9P JL801

L2_VIDEO

9

JS801 XX

JL802

8

L2(L)

7

AU_GND

6

L2(R)

5

AU_GND

4

EJECT

3

POWER

2

D GND

1

C803 0.001u

R802 0

JL803 JL804

C805 0.001u

LX60S/LX70S

JL805 C806 0.001u

D803 MA8051-TX

B

MA-405 (6/7) CN401 (SEE PAGE 4-18)

AN_GND

D801 HZM6.8ZWA1TL

D804 HZM6.8ZWA1TL

D802 HZM6.8ZWA1TL R803 75

8 7 6

5 4 3

1

2

C R805 1500 V

R806 33

L

R

CNJ801

JL810 S803

D

S802

JL806 JL807 JL808

POWER

EJECT

E

SIGNAL PATH

F (POWER, EJECT SWITCH)

(

MA-405 VIDEO, AUDIO, SERVO/SYSTEM CONTROL, TUNER, POWER SUPPLY

VIDEO SIGNAL

)

CHROMA

Y

Y/CHROMA

AUDIO SIGNAL

REC PB

G

FJ-32 (LINE 2 IN)

H

DI-80 (DIAL TIMER)

LINE 2 IN 4-23

FJ-32

DI-80 (DIAL TIMER) PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM — Ref. No. DI-80 Board:1,000 Series — There are few cases that the part printed on this diagram isn’t mounted in this model.

DI-80 BOARD

1

2

3

4

5

6

7

DI-80 BOARD DIAL TIMER

A

•REF.NO.: 1,000 SERIES-

B S901

CN901 5P D_GND TIMER SET

MA-405 BOARD(6/7) CN403 (SEE PAGE 4-17)

SEARCH

C

KKP KKP +

JL901

5

JL902

4 3 2 1

D (POWER, EJECT SWITCH)

(

MA-405 VIDEO, AUDIO, SERVO/SYSTEM CONTROL, TUNER, POWER SUPPLY

)

E

F

FJ-32 (LINE 2 IN)

DI-80 (DIAL TIMER)

G

DIAL TIMER DI-80

4-24E 4-24

D

JL903

E

JL904

A

JL905

B

COM

DIAL TIMER (PUSH/TURN)

SLV-LX40/LX50/LX60S/LX70S SECTION 5 INTERFACE, IC PIN FUNCTION DESCRIPTION 5-1. SYSTEM CONTROL — MECHANISM BLOCK INTERFACE (MA-405 BOARD IC160) CASSETTE CASSETTE TAPE TAPE STOP LOARDING UNLOARDING THREADING UNTEREADING

FF

REW

PB

REC

*5

*5

*5

*5

*5

—

H

H

H

H

H

—

—

L

L

L

H

H

—

—

—

H

H

H

L

L

—

—

—

—

H

L

L

L

L

L

*1

*1

*1

*1

*1

*1

*1

*1

*1

I

H/L

H/L

H/L

H/L

H/L

H/L

*2

*2

*2

*2

MA-405 Board IC160 ul

I

H/L

H/L

H/L

*2

*2

H/L

*2

*2

*2

*2

END LED

MA-405 Board IC160 w;

O

L

*3

*3

*3

*3

*3

*3

*3

*3

*3

T SENS

MA-405 Board IC160 7

I

*3

*3

*3

*4

*4

*4

*4

*4

*4

*4

S SENS

MA-405 Board IC160 6

I

*3

*3

*3

*4

*4

*4

*4

*4

*4

*4

Signal

Pin No.

I/O

EJECTED

CAM

MA-405 Board IC160 ed

O

*5

H

L

H

L

MODE 1

MA-405 Board IC160 wl

I

—

—

—

—

MODE 2

MA-405 Board IC160 wk

I

—

—

—

MODE 3

MA-405 Board IC160 wj

I

—

—

MODE 4

MA-405 Board IC160 wh

I

—

REC PRF

MA-405 Board IC160 e;

I

T REEL

MA-405 Board IC160 8

S REEL

*1 *2 *3 *4 *5

“L” When erasing protection tab is bent. “H” when not bent. Pulse of period in proportion to reel rotating speed. Approx. 2 msec period “H” pluse when tape top or end is detected. Normally “L”. 2 msec period “H” puise when tape top or end is detected. Hi-Z

5-2. SYSTEM CONTROL — SERVO PERIPHERAL CIRCUIT INTERFACE (MA-405 BOARD IC160) Signal

CTL IN+ DRUM PG DRUM FG CAP FG CAP RVS CAP ERR DRUM ERR *1. *2. *3. *4. *5. *6. *7.

Pin No. MA-405 Board IC160 og MA-405 Board IC160 o; MA-405 Board IC160 il MA-405 Board IC160 ij MA-405 Board IC160 ef MA-405 Board IC160 uh MA-405 Board IC160 uj

TAPE

TAPE

*7

*7

*3

*3

*4

*4

I

H/L

O

I/O

STOP

FF

O

*7

*7

I

*3

I

REW THREADING UNTEREADING

PB

REC

*7

*7

*1

*3

*3

*3

*3

*4

*4

*4

*4

*4

*2

*2

*5

*5

*2

*2

H/L

L

H

L

H

L

L

O

L

*6

*6

*6

*6

*6

*6

O

*6

*6

*6

*6

*6

*6

*6

30Hz pulse. Pulse of period in propotion to tape speed. 30Hz “H” pluse. 720 Hz pulse. Unstable period pulse. DC voltage 1 – 5V. Hi-Z (2.5V)

5-1

5-3. SYSTEM CONTROL — SYSTEM CONTROL PERIPHERAL CIRCUIT INTERFACE (MA-405 BOARD IC160) Signal RESET I2C DATA 1 I2C CLOCK 1 I2C DATA VIDEO I2C CLOCK VIDEO (ARC) S OUT 1 (ARC) CLK 1

Pin No. MA-405 Board IC160 ef MA-405 Board IC160 es MA-405 Board IC160 ea MA-405 Board IC160 us MA-405 Board IC160 ua MA-405 Board IC160 rs MA-405 Board IC160 ra

I/O I

I/O level Normally “H”, “L” when service interruption detected or restored.

I/O

Serial communication data to EEPROM I2C161.

O

Serial communication clock to EEPROM I2C161.

I/O

Serial communication data to video and audio microprocessor.

O

Serial communication clock to video and audio microprocessor.

I/O

Serial communication data to ARC microprocessor.

O

Serial communication clock to ARC microprocessor.

5-4. SYSTEM CONTROL AND RF MODULATOR — INPUT SELECTION BLOCK INTERFACE (MA405 BOARD IC160) Signal ANT SEL

Pin No. MA-405 Board IC160 wa

I/O O

I/O level “H” when RF modulator through.

5-5. SYSTEM CONTROL — VIDEO/RP BLOCK INTERFACE (MA-405 BOARD IC160) Signal RF SWP QVD C SYNC

Pin No. MA-405 Board IC160 qk MA-405 Board IC160 qd MA-405 Board IC160 tk

I/O

STOP/FF /REW

TAPE LOADING

TAPE UNLOADING

PB

REC

REC/ PAUSE

O

*1

*1

*1

*1

*1

*1

O

L

L

L

*2

L

L

I

*3

*3

*3

*3

*3

*3

*1. Synchronized with drum rocation, 30Hz 50% duty pulse. *2. Normal “L”, “H” when video signal is not rgenerated. *3. Composite sync signal (positive).

5-6. SYSTEM CONTROL — AUDIO BLOCK INTERFACE (MA-405 BOARD IC160) Signal A MUTE AF REC P

Pin No. MA-405 Board IC160 yd MA-405 Board IC160 ws

I/O

STOP/FF /REW

TAPE LOADING

TAPE UNLOADING

PB

REC

REC/ PAUSE

O

L

L

L

L

L

L

O

L

L

L

L

H

L

5-2

5-7. SERVO/SYSTEM CONTROL MICROPROCESSOR PIN FUNCTIONS (MA-405 BOARD IC160) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

Pin Name DEST MPX MODE TU AFT FUNC KEY2

I/O I I I I

Destination control input STEREO/MONO/SAP DETECTION Tuner analog AFT input Key input

Function

FUNC KEY1 S SENS T SENS V RF ENV AF ANV CBC ON KKP+ KKP– QVD REMOCON C ROT HA SWP ENV SW RF SWP AF SWP END LED ANT SEL AF REC P FE ON CAP RVS SUR ON MODE4 MODE3 MODE2 MODE1 REC PRF I2C CLK EEP I2C DATA EEP CAM RESET 32kHz (in) 32kHz (out) Vcc 4fsc (in) 4fsc (out) Vss ARC CLK ARC DATA CLK SEL OSC IN OSC OUT NUB LPF SP OSD GND OSD V IN

I I I I I O I I O I O O I O O O O O — O — I I I I I I/O I/O O I I O I I O — O O I I O — I/O O — I

Key input Tape end sensor input Tape top sensor input Video playback signal envelope input Hi-Fi audio playback signal envelope input Cable box control signal output ETR pulese signal input ETR pulese signal input Quasi VD pulese output Remote sires signal input Head AZ signal output SP/EP changed head signal SP/EP head output lebel ditaction signal VIDEO RF switching pulse output. AF switching pulse output. END sensor LED output TV/VTR RF modulator control output Hi-Fi record control pulse output. NC Capstan reverse control NC Mechanism section CAM encoder input (data4) Mechanism section CAM encoder input (data3) Mechanism section CAM encoder input (data2) Mechanism section CAM encoder input (data1) Erasing protection tab, cassette IN detection input HC CLOCK line (EEPROM) HC DATA line (EEPROM) Cam motor control signal output System reset input Sub clock 32MHz Sub clock 32MHz 5V Main clock input Main clock output Ground Realityregenarator (ARC) control clock signal Realityregenarator (ARC) control data signal CLOCK seleal “L” Sub clock, “H” main and sub clock. OSD clock input OSD clock output Ground fsc filter “L” output when SP mode. Ground OSD Video signal input.

5-3

Pin No. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100

Pin Name WHITE LEVEL OSD V OUT OSD Vcc HLF V HOLD C VIDEO IN NUA C SYNC PLL CLK PLL DATA PLL ENABLE TA MUTE A MUTE P CONT M12 P CONT SW12 FLD CS V-SET CS S OUT0

I/O I O — I/O I/O I — I O O O O O O O O O O

Function White level signal input OSD Video signal output SW 5V (OSD block) External low-pass filter for slicer/AFC is connected to this terminal External capacitor for slicer is connected to this terminal Control video signal input (osd, tuner, sorvo) D Ground NC Tuner PLL clock output Tuner PLL data output Tuner enable output NC AUDIO mute output Motor 12V control output SW 12V control output FLD drive chip select signal output V-set micon chip select signal output Serial communication signal (FLD, V-SET)

S IN 0 S CLK 0 I2C CLK I2C DATA CBC SIRCS OUT CLK OUT NICOLE CAP ERR DRUM ERR P FAIL S REEL T REEL DMS+ DMS– MAIN/SAP F MONO STEREO SAP CAP FG AMP Vss DRUM FG DRUM PG AMP Vref OUT AMP Vref IN RC CHECK CTL–IN CTL+IN AMP C CTL AMP OUT AMP Vcc A Vcc V-SET RESET

I O I/O I/O O — O O O I I I I I O O I I I — I I O I I I/O I/O I O — — O

NC Serial communication signal (FLD, V-SET) IIC clock signal (VIDEO, HiFi) IIC data signal (VIDEO, HiFi) Cable mouse sircs signal output NC NC Capstan error D/A output Drum error D/A output Power fail detection input Supply reel sensor input Take up reel sensor input

Ground Ground Capstan FG signal input Ground Drum FG input. Drum PG input. Analog AMP reference Vcc output Analog AMP reference Vcc input Check input Control signal IN/OUT Control signal IN/OUT Control signal AC conect Control signal AMP output D-5V D-5V NC

5-4E 5-4

SLV-LX40/LX50/LX60S/LX70S SECTION 6 ADJUSTMENTS 6-1

MECHANICAL ADJUSTMENTS

For the mechanical adjustments, please refer to the “VHS MECHANICAL ADJUSTMENT MANUAL (S MECHANISM)” (9-921-647-11).

6-2. ELECTRICAL ADJUSTMENTS See the adjusting part location diagram from on page 6-6 for the adjustment.

2-1.

2-1-3. Set-up of Adjustment In this adjustment, NTSC pattern generator is connected with LINE input terminal. When check to tuner, connected AERIAL terminal. Check that the synchronizing signal of the Y signal has an amplitude of approximately 0.7 V and that the burst signal has an amplitude of approximately 0.3 V and its waveform is flat. And check that the level ratio of burst signal to “red” signal is 0.30 : 0.66. The video signal (color bar) used for electrical aligning this unit is shown in Fig. 6-2-2. NTSC model

White (100%)

PREPARATION BEFORE ADJUSTMENT

2-1-1. Equipment Required The measuring instruments used for this alignment include: 1) Monitor TV 2) Oscilloscope, dual-trace, bandwidth of 30 MHz or more, with delay mode (A probe 10:1 should be used unless otherwise specified.) 3) Frequency counter 4) NTSC Pattern generator 5) Remote commander 6) Digital voltmeter 7) Audio generator 8) Audio level meter 9) Audio attenuator 10) Alignment tapes KRV-51N2 (NTSC) Part No. : 8-192-605-32

About 0.7 V

Red Horizontal sync signal

VIDEO LINE IN Pattern generator

Video output (75Ω)

VCR

Burst signal (It must be flat.)

Fig. 6-2-2 Color Bar Signals of Pattern Generator 2-1-4. Alignment Tape • Contents of KRV-51N2 Mode

2-1-2. Equipment Connection Unless otherwise specified, connect and adjust the measuring instruments as shown in the following diagram.

About 0.3 V

About 0.3 V

1 2 3 4

Monitor TV

VIDEO LINE OUT

Fig. 6-2-1

6-1

SP LP

Period

Video signal

Audio signal Normal Hi-Fi

7 minutes 3 minutes 7 minutes 3 minutes

Color bar Monoscope Color bar Monoscope

400Hz (L/R)

400Hz

2-1-5. Input/Output Levels and Impedance Video input: LINE IN Input signal: 1 Vp-p, 75 ohms, unbalanced, sync negative Video output: LINE OUT Output signal: 1 Vp-p, 75 ohms, unbalanced, sync negative Audio input: LINE IN Input level: –7.5 dBs (0 dBs= 0.775 Vrms) Input impedance: more than 47 kilohms Audio output:LINE OUT Standard level: –7.5 dBs at load impedance 47 kilohms Output impedance: less than 10 kilohms

2-2.

POWER SUPPLY CHECK

2-2-1. Output Voltage Check (MA-405 Board) Mode STANDBY +30 V Check Measurement point

2-1-6. Adjustment Sequence The adjustments should be performed in the following sequence. Power Supply Check

Servo/Video System Adjustments

Audio System Adjustments

C671 3

Specified value –11 V Check

31.0 to 39.0 V

Measurement point Specified value

Anode of D420 –12.5 to – 9.5 V

D+6 V Check Measurement point

Collector of Q674

Specified value

5.56 to 6.25 V

Mode Measuring Instrument

E-E Digital voltmeter

SW+12 V Check Measurement point

IC660 pin 2

Specified value SW+5 V Check

11.7 to 12.3 V

Measurement point Specified value

Emitter of Q662 4.8 to 5.4 V

MTR12 V Check Measurement point

Collector of Q600

Specified value F Check

12.5 to 14.5 V

Measurement point Specified value

ND420 e; to 1 2.0 to 5.0V

[Check Method] 1) Each of these supply voltages must meet its specified value.

6-2

2-3.

SERVO SYSTEM CHECK

2-3-1.

RF Switching Position Adjustment (MA-405 Board) [Adjustment Purpose] To adjust the link of the A-ch and B-ch of the tape playback outputs. To make the unit compatible with other tapes and units. If this specification is not satisfied, the link will appear on the screen and the screen will be disrupted, etc.

2-4.

AUDIO SYSTEM ADJUSTMENT

• Adjust both L ch and R ch. [Connecting Instruments] Audio line OUTPUT L/R

Audio line INPUT L/R Audio oscillator

Mode

600 Ω

Playback

Signal Measurement point

Alignment tape: SP color bar portion CH1: CN270 pin 2 (PB RF) CH2: CN270 pin 3 (RF SWP)

Measuring instrument Adjusting element

Oscilloscope Remote Commander CH+/–

Specified value

A=minimize

[Adjustment Method] 1) Playback the alignment tape. 2) Short JS401 to Ground. 3) Check that “A P” is indicated on FL display. 4) Adjust so that part A becomes minimized at CH +/–. 5) Write data in EEPROM by pressing PAUSE button. Monoral model: 6) The display “A P” disappears and then the Adjustment mode terminates. Hi-Fi model: 6) The display changes to “A H” and the mode goes to the HiFi switching position Adjustment.(2-4-2.)

Audio level meter or distortion meter 47 kΩ

Attenuator VTR

Fig. 6-2-4 2-4-1.

Hi-Fi Audio System Adjustment (Hi-Fi model only) • Perform the adjustment setting the switch on the following positions. • AUDIO MONITOR STEREO [Adjustment Method] 1. ACE head adjustment.....Refer to the VHS mechanical adjustment manual (S MECHANISM)(9-921-647-11). 2. E-E output level check 3. “Recording Bias Adjustment”

A

CH1 PB RF CH2 RF SWP

Fig. 6-2-3

6-3

2-4-2.

HiFi Switching Position Adjustment (MA-405 Board) [Adjustment Purpose] To adjust the link of the A-ch and B-ch of the tape playback outputs. To make the unit compatible with other tapes and units. If this specification is not satisfied, the link will appear on the screen and the screen will be disrupted, etc. Mode

Playback

Signal Measurement point

Alignment tape: SP color bar portion CH1: Pin 1 of CN270 (HF ADJ) CH2: Pin 3 of CN270 (RF SWP)

Measuring instrument Adjusting element

Oscilloscope Remote Commander CH +/–

Specified value

B=minimize

[Adjustment Method] 1) Check that “A H” is indicated on FL display. 2) Adjust so that part B becomes minimized at CH +/–. 3) Write data EEPROM by pressing PAUSE button. 4) Check that “A H” indicator turns off. 5) If “A H” indicator is still on, restart RF switching position Adjustment from the beginning. B

CH1 HFADJ CH2 RF SWP

2-4-5. Audio Noise Check [Adjustment purpose] Confirm that the noise level is within the specification. Mode REC and PB (SP mode) Signal Measurement point

No signal input Audio output terminal

Measuring instrument Specified value

Audio level meter Less than –67,5dBs (HIFI) Less than –45.5dBs (MONO)

[Confirmation method] 1) Audio line input L and R channels are shorted to the ground. 2) Record the tape. 3) Playback a recorded portion of the tape. 4) Confirm that the output level is less than –67.5dBs for HIFI and –45.5dBs for MONO. 2-4-6. ACE Head Adjustment Refer to the VHS mechanical adjustment manual MECHANISM) (9-921-647-11).

(S

2-4-7. E-E Output Level Check [Adjustment purpose] Confirm that the output level adjust the reference input is within the specification. Mode Signal

E-E 400 Hz, –7.5 dBs

Measurement point Measuring instrument

CNJ562 L/R Audio level meter

Specified value

–7.5 ± 2 dBs

[Check Method] 1) Input signal of 400 Hz and –7.5 dBs to the CNJ562 L/R. 2) Check that the audio output level is –7.5 ± 2 dBs.

Fig. 6-2-5 2-4-3. Normal Audio System Adjustment • Make adjustment in the SP mode unless otherwise specified. Use a normal VHS cassette for an adjustment tape. • Set AUDIO MONITOR to normal. 2-4-4. Audio Level and Distortion Check [Adjustment purpose] Confirm that the audio level and distortion is within the specification. Mode Signal

REC and PB (SP mode) 400 Hz, –7.5 dBs

Measurement point Measuring instrument

Audio output terminal Audio level meter and distortion meter

Specified value

PB level PB level Distortion Distortion

2-4-8. Frequency Response Check [Adjustment purpose] Confirm that the frequency characteristic is within the specification. Mode Signal

REC and PB (SP mode) 400 Hz, –17.5 dBs 7 kHz, –17.5 dBs

Measurement point Measuring instrument

CNJ562 L/R Audio level meter

Specified value

0 ± 3 dB

Note: Tape path adjustment must have been completed.

: –7.5±2dBs (HIFI) : –7.5±3dBs (MONO) : less than 1% (HIFI) : less than 4% (MONO)

[Confirmation Method] 1) Supply a signal of 400 Hz, –7.5 dBs to both L and R channels of Audio Line Input. 2) Record the tape. 3) Playback a recorded portion of the tape. 4) Confirm that the playback output level of audio level meter is within of range –7.5±2dBs for HIFI and –7.5±3dBs for MONO. 5) Confirm that the output of distortion meter is less than 1% for HIFI and 4% for MONO.

6-4

[Confirmation Method] 1) Supply a signal of 400 Hz, –17.5 dBs to CNJ562 L/R. 2) Connect the audio level meter to CNJ562 L/R. 3) Adjust the attenuator so that the audio level meter will indicate –17.5 dBs. 4) Make recording in the SP mode. 5) Set an audio line input signal to 7 kHz and make recording. 6) Playback a recorded portion, and measure output levels at 400 Hz and 7 kHz. 7) Confirm that the 7 kHz playback output level within a range of the 400 Hz playback output level 0 ± 3 dB.

2-5.

ADJUSTING PARTS LOCATION DIAGRAM

MA-405 BOARD (CONDUCTOR SIDE)

CNJ562

CN270 4

VIDEO/AUDIO LINE IN/OUT

1

RF/HF SWP

C671

+

B

E

Q600 MTR12 V

+30 V

+12V

B

4

E

1

Q662 +6V SW5V

-11V D420

IC660

ND420

30

6-5E 6-5

JS401 ADJ 1

SLV-LX40/LX50/LX60S/LX70S SECTION 7 REPAIR PARTS LIST 7-1. EXPLODED VIEWS NOTE: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.

•

The mechanical parts with no reference number in the exploded views are not supplied.

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

7-1-1. FRONT PANEL AND UPPER CASE SECTION

10

11 12

11

8 4 9

7 2

3

13

5 6 1

Ref. No.

Part No.

Description

1 1 1 1 2

X-3951-118-1 X-3951-120-1 X-3951-119-1 X-3951-121-1 3-951-089-01

PANEL ASSY, FRONT (LX40) PANEL ASSY, FRONT (LX50) PANEL ASSY, FRONT (LX60S) PANEL ASSY, FRONT (LX70S) SPRING (GE), FL (LX40/LX50)

2 3 4 * 5 6

3-951-089-01 3-058-039-11 4-921-277-41 A-6794-813-A 1-757-552-12

SPRING (GE), FL (LX60S/LX70S) DOOR,CASSETTE SCREW(B2.6 × 8), TAPPING, BIND DI-080 MOUNT CABLE, FLAT FDM-010

* 7 * 7 8

A-6794-814-A FJ-032 MOUNT (LX60S/LX70S) A-6794-815-A FJ-032 MOUNT (LX40/LX50) 1-757-556-11 CABLE, FLAT FFJ-004

Remarks

Ref. No.

Part No.

!9

1-777-852-12 CORD, POWER (LX40/LX50:MX,PA,PC,VZ/ LX60S/LX70S:MX,PA,PC,VZ) 1-782-000-33 CORD, POWER (LX50:CL,CS/LX70S:CL,CS) 3-053-307-61 CASE, UPPER 3-710-901-01 SCREW, TAPPING 1-476-436-11 COMMANDER, STANDARD (RMT-V293A) (LX40/LX50)

!9 10 11 12

12 13

7-1

Description

Remarks

1-476-437-11 COMMANDER, STANDARD (RMT-V294A) (LX60S/LX70S) 3-943-995-51 EMBLEM (NO.5), SONY

7-1-2. CHASSIS SECTION

54

55

#1 #1

#1

54 54

54

54

53 56 52

51 54

not supplied

not supplied

not supplied

Ref. No. 51 52 53 * 53 * 53

Part No.

Description

3-959-383-01 BASE (R), MD 3-987-076-11 PANEL, REAR A-6713-826-A MA-405 COMPLETE PC BOARD (LX50:CL,CS) A-6713-827-A MA-405 COMPLETE PC BOARD (LX60S/LX70S:MX,PA,PC,VZ) A-6713-828-A MA-405 COMPLETE PC BOARD (LX70S:CL,CS)

Remarks

Ref. No.

Part No.

* 53 54 55 56

A-6713-829-A MA-405 COMPLETE PC BOARD (LX40/LX50:MX,PA,PC,VZ) 3-970-608-21 SUMITITE (B3), +BV 1-791-857-11 CABLE, FLAT (FMD-21) X-3950-107-1 PANEL ASSY, REAR

#1

7-685-648-79 SCREW + BVTP 3 x 12 TYPE2 IT-3

7-2

Description

Remarks

7-1-3. MECHANISM DECK SECTION-1

707

#2

708

712 711 709

706 723

704 710 705

702

713

720

722

725

703 701

724 701

721

714 716

719

715

717

718

Ref. No.

Part No.

Description

Remarks

701 702 703 704 705

3-977-509-01 3-977-507-01 3-977-508-01 1-500-144-11 3-977-495-01

WASHER, THRUST TABLE, REEL (S) (GRAY) TABLE, REEL (T) (BLACK) HEAD, FE SHAFT, TG2

706 707 708 709 710

3-977-494-01 A-6759-619-B 3-977-535-01 3-977-536-01 3-977-443-01

HOLDER, FEH FL COMPLETE ASSY BOARD, COMPLETE PLATE, LUMINOUS (END SENSOR) PLATE, LUMINOUS (TOP SENSOR) WASHER, STOPPER

711 712 713

A-6759-863-B PRESS BLOCK ASSY, PINCH 3-958-455-01 SPRING (PINCH), TENSION 3-977-447-01 GEAR, ELEVATOR

7-3

Ref. No.

Part No.

Description

714 715 716 717 718

3-977-514-01 3-977-441-03 3-977-445-02 3-977-465-01 3-977-446-01

OPENER, LID (SL) GEAR, PINCH PRESSING GEAR, TG8 ARM DRIVING SPRING, EXTENSION (RVS BRAKE) ARM ASSY, RVS BRAKE (SL)

719 720 721 722 723

3-977-446-01 X-3947-590-1 A-6759-620-A 3-974-556-11 3-979-508-01

GEAR, TG8 ARM TG8 ASSY HEAD BLOCK ASSY, ACE + HEXA TT 2.6 x 9 (TAPER) SCREW + HEXA TP SW 3 x 8

724 725 #2

3-059-958-01 SPRING, TG8 3-051-300-03 LOCK ACE SCREW 7-685-646-79 SCREW + BVTP 3 x 8 TYPE2 IT-3

Remarks

7-1-4. MECHANISM DECK SECTION-2

767 770 768 769

761 758

#2

764

762 763

759

760

762 757

763

#3

766

756

765

755 754

752

753

751

Ref. No.

Part No.

Description

751 752 753 754 755

X-3947-581-4 3-977-462-01 X-3947-573-1 X-3947-580-5 3-977-513-02

BRAKE ASSY,MAIN(T) SPRING,EXTENTION. (MAIN BRAKE) ARM ASSY, PENDULUM BRAKE ASSY, MAIN(S) LEVER, REC PROOF

756 757 758 759 760

3-976-767-01 3-977-487-01 X-3947-587-1 X-3947-589-1 3-977-488-01

SPRING, TENS. (REC. PROOF) BOSS, TG1 FULCRUM TG1 ASSY BAND ASSY, TG1 SPRING (POWER TENSION)

761

A-6750-324-A SHUTTLE (S) BLOCK ASSY

Remarks

Ref. No.

Part No.

Description

762 763 764 765 766

X-3944-378-1 3-965-178-01 3-062-687-01 A-6750-328-G 3-977-501-01

ROLLER ASSY, GUIDE SPRING BASE, DRUM SHUTTLE (T) BLOCK ASSY PLATE, LUMINOUS

767 768 769 770 770

A-6746-074-G X-3947-255-1 3-975-724-07 8-839-047-53 8-839-049-53

ROLLER BLOCK ASSY, HC ROLLER ASSY, HC ARM, HC DRUM ASSY, DZH-0A0A/Z-RP DRUM ASSY, DZH-0A2A/Z-RP

#2 #3

7-685-646-79 SCREW + BCTP 3 x 8 TYPE IT-3 7-682-647-09 SCREW + P3 x 6

7-4

Remarks

(LX60S/LX70S) (LX40/LX50)

7-1-5. MECHANISM DECK SECTION-3 816 815 817

M902

803

818 803 814 #2

812

813 828

811

829

810 808 809

819 820

827

821

826

807 805

822

804

806

823 824

832 831 830

M903

803

801

825

802 833 #4

Ref. No.

Part No.

Description

801 802 803 804 805

3-977-437-01 X-3947-584-1 3-977-443-01 3-977-438-01 3-977-506-01

RETAINER,CAM MOTOR ASSY, REEL DIRECT WASHER, STOPPER WORM - WHEEL ARM, LIMITTER SELECTION

806 807 808 809 810

3-977-444-01 3-977-515-01 3-977-517-01 3-977-519-01 3-977-518-02

811 812 813 814 815

3-977-516-01 3-977-877-01 3-977-504-01 X-3947-585-1 3-977-510-01

816 817 818

3-056-824-01 WASHER, STOPPER 3-977-439-01 GEAR, CAM 3-977-442-03 SLIDER

Remarks

Part No.

Description

819 820 821 822 823

3-977-455-01 3-977-456-03 X-3947-579-1 3-977-451-01 3-977-452-01

GEAR, LOADING(T) SPRING, TORSION (LOAD T) LEVER ASSY, LOADING(T) GEAR, LOADING(S) SPRING, TORSION (LOAD S)

GEAR, PINCH TRANSMISSION GUIDE, FL SLIDER PLATE, SLIDE, FL SPRING, TENS. (LIMIT, FL) PLATE, LIMITTER, FL

824 825 826 827 828

X-3947-578-1 X-3947-576-2 3-977-468-01 3-977-467-02 X-3947-583-1

LEVER ASSY, LOADING (S) CHASSIS ASSY, MECHANICAL SHAFT, CAPSTAN BRAKE SPRING, CAP BRAKE BRAKE ASSY, CAPSTAN

HOLDER, FL SLIDER PLATE, RETAINER GEAR, CLUTCH GEAR ASSY, PULLEY BELT, RUBBER

829 830 831 832 833

3-977-489-01 A-6759-616-A 1-766-723-21 3-977-436-01 3-989-917-01

ARM, TG1 DRIVING GEAR BLOCK ASSY, LOADING (S) CONNECTOR, BOARD TO BOAR 3P WORM SPACER (REC PROOF)

M902 M903

1-698-971-11 MOTOR, DC (CAPSTAN) X-3947-577-1 MOTOR ASSY, CAM (LOADING)

#2 #4

7-685-646-79 SCREW + BVTP 3 x 8 TYPE IT-3 7-685-133-19 SCREW + P2.6 x 6 TYPE2 NON-SLIT

7-5E 7-5

Ref. No.

Remarks

MA-405 Ref. No. 7-2.

Part No. Description ELECTRICAL PARTS LIST

NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS: uF: µF Ref. No.

Part No.

•

• •

Remarks

Ref. No.

Part No.

RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD...

Description

Remarks

Ref. No.

Part No.

Description

DI-80 Remarks

When indicating parts by reference number, please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.

Description

Remarks



A-6794-813-A D1-080 BOARD MOUNT *******************

CN901

FJ-32

R801 R802 R803 R805 R806

1-770-514-31 CONNECTOR, FFC/FPC 5P

1-216-295-00 1-216-295-00 1-216-022-00 1-216-053-00 1-216-013-00

SHORT SHORT RES-CHIP RES-CHIP RES-CHIP

0 0 (LX60S/LX70S) 75 5% 1/10W 1.5K 5% 1/10W 33 5% 1/10W

S901



1-418-156-11 ENCODER, ROTARY S802 S803

1-762-196-21 SWITCH, TACT 1-762-196-21 SWITCH, TACT

A-6794-814-A FJ-032 BOARD MOUNT (LX60S/LX70S) A-6794-815-A FJ-032 BOARD MOUNT (LX40/LX50) ****************** A-6713-829-A MA-405 N3 BOARD COMPLETE (LX40/LX50:PA,PC,MX,VZ) A-6712-826-A MA-405 N3A BOARD COMPLETE (LX50:CL,CS) A-6713-827-A MA-405 N5 BOARD COMPLETE (LX-60S/LX70S:PA,PC,MX,VZ) A-6713-828-A MA-405 N5A BOARD COMPLETE (LX70S:CL,CS) **************************

C803 C805 C806

1-163-009-11 CERAMIC CHIP 0.001µF 10% 1-163-009-11 CERAMIC CHIP 0.001µF 10% (LX60S/LX70S ONLY) 1-163-009-11 CERAMIC CHIP 0.001µF 10%

50V 50V 50V

CN801

3-065-135-01 HOLDER, FL 3-960-273-11 SPACER, TOP END 3-065-718-11 SINK, HEAT (LX50:CL,CS)

1-568-852-11 CONNECTOR, FFC/FPC 9P

C101 C102 C103 C104 C105

1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 1-128-057-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

0.001µF 0.001µF 0.001µF 0.001µF 330µF

10% 10% 10% 10% 20%

50V 50V 50V 50V 6.3V

C106 C107 C108 C109 C111

1-124-589-11 1-164-346-11 1-164-004-11 1-164-004-11 1-164-232-11

ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

47µF 1µF 0.1µF 0.1µF 0.01µF

20%

DIODE HZM6.8ZWA1TL DIODE HZM6.8ZWA1TL DIODE MA8051-TX DIODE HZM6.8ZWA1TL

10% 10% 10%

16V 16V 25V 25V 50V



C112 C113

0.01µF 0.1µF

10% 10%

50V 25V

C115 C116 C140

1-164-232-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP (LX60S/LX70S) 1-164-232-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP 1-124-584-00 ELECT

0.01µF 0.01µF 100µF

10% 10% 20%

50V 50V 10V

C141 C142

1-163-038-00 CERAMIC CHIP 1-163-037-11 CERAMIC CHIP

0.1µF 0.022µF 10%

25V 50V

CNJ801 1-785-622-11 JACK, PIN 2P (LX40/LX50) CNJ801 1-770-021-11 JACK, PIN 3P (LX60S/LX70S)

D801 D802 D803 D804

JR801

8-719-071-15 8-719-071-15 8-719-422-37 8-719-071-15

1-216-296-00 SHORT

0

JS801

1-216-295-00 SHORT

0 (LX40/LX50)

7-6

MA-405 Ref. No.

Part No.

Description

Remarks

C143 C144 C145

1-126-965-11 ELECT 1-126-965-11 ELECT 1-126-935-11 ELECT

22µF 22µF 470µF

20% 20% 20%

50V 50V 10V

C146 C160 C161 C162 C163

1-164-161-11 1-163-809-11 1-163-809-11 1-163-038-00 1-163-809-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.0022µF 0.047µF 0.047µF 0.1µF 0.047µF

10% 10% 10% 10%

50V 25V 25V 25V 25V

C164 C165 C166 C167 C168

1-163-102-00 1-163-102-00 1-163-231-11 1-163-233-11 1-124-584-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

24PF 24PF 15PF 18PF 100µF

5% 5% 5% 5% 20%

50V 50V 50V 50V 10V

C169 C170 C171 C172 C173

1-163-038-00 1-163-137-00 1-127-737-11 1-164-232-11 1-164-232-11

CERAMIC CHIP CERAMIC CHIP DOUBLE LAYER CERAMIC CHIP CERAMIC CHIP

0.1µF 680PF 0.33F 0.01µF 0.01µF

C176 C185 C187 C188 C190

1-164-004-11 1-109-982-11 1-164-346-11 1-109-982-11 1-124-589-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

0.1µF 1µF 1µF 1µF 47µF

C201 C202 C203

5% 10% 10% 10% 10%

25V 50V 5.5V 50V 50V

Ref. No.

Part No.

Description

Remarks

C237 C238

1-164-232-11 CERAMIC CHIP 1-124-589-11 ELECT

0.01µF 47µF

10% 20%

50V 16V

C239 C240 C241 C242 C243

1-164-232-11 1-124-589-11 1-164-232-11 1-164-232-11 1-162-306-11

CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC

0.01µF 47µF 0.01µF 0.01µF 0.01µF

10% 20% 10% 10% 20%

50V 16V 50V 50V 16V

C244 C245 C246 C247 C248

1-109-982-11 1-109-982-11 1-162-306-11 1-163-037-11 1-163-809-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CERAMIC CHIP CERAMIC CHIP

1µF 1µF 0.01µF 0.022µF 0.047µF

10% 10% 20% 10% 10%

10V 10V 16V 50V 25V

C249 C250 C251 C252 C253

1-109-982-11 1-163-809-11 1-164-004-11 1-162-306-11 1-163-241-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CERAMIC CHIP

1µF 0.047µF 0.1µF 0.01µF 39PF

10% 10% 10% 20% 5%

10V 25V 25V 16V 50V

C254

1µF

10%

10V

0.1µF

10%

25V

C267 C271 C272

1-109-982-11 CERAMIC CHIP (LX60S/LX70S) 1-164-004-11 CERAMIC CHIP (LX60S/LX70S) 1-164-004-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP

0.1µF 0.01µF 0.1µF

10% 10% 10%

25V 50V 25V

1-164-232-11 1-164-004-11 1-163-037-11 1-164-004-11 1-124-584-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

0.01µF 0.1µF 0.022µF 0.1µF 100µF

10% 10% 10% 10% 20%

50V 25V 50V 25V 10V

10% 20%

25V 10V 16V 10V 16V

0.047µF 10% 0.01µF 10% 0.001µF 5%

25V 50V 50V

C204 C205

1-163-809-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP 1-163-275-11 CERAMIC CHIP (LX40/LX50) 1-109-982-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP

1µF 0.01µF

10% 10%

10V 50V

C275 C276 C278 C279 C280

C206 C207 C208 C209 C210

1-164-004-11 1-163-241-11 1-164-232-11 1-124-589-11 1-164-004-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP

0.1µF 39PF 0.01µF 47µF 0.1µF

10% 5% 10% 20% 10%

25V 50V 50V 16V 25V

C281 C282 C283 C284 C285

1-164-232-11 1-164-232-11 1-164-232-11 1-164-489-11 1-162-306-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC

0.01µF 0.01µF 0.01µF 0.22µF 0.01µF

10% 10% 10% 10% 20%

50V 50V 50V 16V 16V

C211 C213 C214 C215 C216

1-163-239-11 1-163-131-00 1-163-257-11 1-163-227-11 1-126-160-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

33PF 390PF 180PF 10PF 1µF

5% 5% 5% 0.50PF 20%

50V 50V 50V 50V 50V

C286 C301 C302 C303 C304

1-163-251-11 1-164-004-11 1-164-232-11 1-164-004-11 1-104-664-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

100PF 0.1µF 0.01µF 0.1µF 47µF

5% 10% 10% 10% 20%

50V 25V 50V 25V 25V

C217 C220 C221 C222 C223

1-163-037-11 1-164-232-11 1-109-982-11 1-126-157-11 1-124-234-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT

0.022µF 0.01µF 1µF 10µF 22µF

10% 10% 10% 20% 20%

50V 50V 10V 16V 16V

C305 C306 C307 C308 C309

1-104-664-11 1-163-037-11 1-124-257-00 1-164-346-11 1-164-004-11

ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP

47µF 0.022µF 2.2µF 1µF 0.1µF

20% 10% 20% 10%

25V 50V 50V 16V 25V

C224 C225 C226 C227 C228

1-164-004-11 1-126-160-11 1-164-004-11 1-164-004-11 1-124-589-11

CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT

0.1µF 1µF 0.1µF 0.1µF 47µF

10% 20% 10% 10% 20%

25V 50V 25V 25V 16V

C310 C311 C312 C313 C314

1-126-964-11 1-124-257-00 1-126-964-11 1-126-964-11 1-126-964-11

ELECT ELECT ELECT ELECT ELECT

10µF 2.2µF 10µF 10µF 10µF

20% 20% 20% 20% 20%

50V 50V 50V 50V 50V

C229 C230 C231 C232 C233

1-164-004-11 1-163-038-00 1-124-589-11 1-109-982-11 1-126-157-11

CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT

0.1µF 0.1µF 47µF 1µF 10µF

10% 20% 10% 20%

25V 25V 16V 10V 16V

C315 C316 C317 C318 C319

1-126-964-11 1-109-979-81 1-164-004-11 1-126-162-11 1-164-004-11

ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP

10µF 3.3µF 0.1µF 3.3µF 0.1µF

20% 10% 10% 20% 10%

50V 50V 25V 50V 25V

C234 C235 C236

1-109-982-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP

1µF 0.1µF 0.01µF

10% 10% 10%

10V 25V 50V

C320 C321 C322

1-126-163-11 ELECT 1-164-004-11 CERAMIC CHIP 1-126-157-11 ELECT

4.7µF 0.1µF 10µF

20% 10% 20%

50V 25V 16V

7-7

C255

MA-405 Ref. No.

Part No.

Description

Remarks

C323 C324

1-126-163-11 ELECT 1-109-978-81 ELECT

4.7µF 10µF

20% 10%

50V 16V

C325 C326 C327 C328 C329

1-126-163-11 1-124-242-00 1-126-160-11 1-126-157-11 1-126-157-11

ELECT ELECT ELECT ELECT ELECT

4.7µF 33µF 1µF 10µF 10µF

20% 20% 20% 20% 20%

50V 25V 50V 16V 16V

C330 C331 C332 C333 C334

1-163-023-00 1-124-242-00 1-124-589-11 1-164-004-11 1-164-489-11

CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP

0.015µF 33µF 47µF 0.1µF 0.22µF

10% 20% 20% 10% 10%

50V 25V 16V 25V 16V

C336 C337 C338 C339 C340

1-164-004-11 1-164-232-11 1-164-232-11 1-164-004-11 1-163-023-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1µF 0.01µF 0.01µF 0.1µF 0.015µF

10% 10% 10% 10% 10%

25V 50V 50V 25V 50V

C341 C342 C343 C345 C350

1-126-157-11 1-126-157-11 1-164-489-11 1-164-232-11 1-126-160-11

ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT

10µF 10µF 0.22µF 0.01µF 1µF

20% 20% 10% 10% 20%

16V 16V 16V 50V 50V

C351 C352 C353

1-104-664-11 ELECT 1-163-038-00 CERAMIC CHIP 1-126-160-11 ELECT (LX40/LX50) 1-126-157-11 ELECT 1-126-160-11 ELECT (LX40/LX50)

47µF 0.1µF 1µF

20% 20%

25V 25V 50V

10µF 1µF

20% 20%

16V 50V

C356 C357 C358 C359 C360

1-124-242-00 1-126-163-11 1-126-160-11 1-163-009-11 1-163-014-00

ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP

33µF 4.7µF 1µF 0.001µF 0.0027µF

20% 20% 20% 10% 10%

25V 50V 50V 50V 50V

C362 C363 C364 C365 C366

1-124-589-11 1-126-163-11 1-126-157-11 1-164-232-11 1-126-160-11

ELECT ELECT ELECT CERAMIC CHIP ELECT

47µF 4.7µF 10µF 0.01µF 1µF

20% 20% 20% 10% 20%

16V 50V 16V 50V 50V

C368 C369

0.01µF 4.7µF

10% 20%

50V 50V

C371 C380 C381

1-164-232-11 CERAMIC CHIP 1-126-163-11 ELECT (LX40/LX50) 1-163-135-00 CERAMIC CHIP 1-137-374-11 MYLAR 1-164-232-11 CERAMIC CHIP

560PF 5% 0.047µF 5% 0.01µF 10%

50V 50V 50V

C382 C383 C405 C406 C422

1-164-232-11 1-124-589-11 1-164-232-11 1-124-584-00 1-124-589-11

CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT

0.01µF 47µF 0.01µF 100µF 47µF

10% 20% 10% 20% 20%

50V 16V 50V 10V 16V

C423 C424 C425 C427 C500

1-164-232-11 1-163-038-00 1-126-157-11 1-164-004-11 1-163-231-11

CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP

0.01µF 0.1µF 10µF 0.1µF 15PF

10% 20% 10% 5%

50V 25V 16V 25V 50V

C501 C502

1-163-231-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP

15PF 0.01µF

5% 10%

50V 50V

C354 C355

Ref. No.

Part No.

Description

Remarks

C503 C504 C505

1-163-017-00 CERAMIC CHIP 1-163-275-11 CERAMIC CHIP 1-162-199-31 CERAMIC

0.0047µF 10% 0.001µF 5% 10PF 5%

50V 50V 50V

C507 C508 C509 C510 C511

1-163-137-00 1-109-982-11 1-163-016-00 1-164-004-11 1-163-038-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

680PF 1µF 0.0039µF 0.1µF 0.1µF

5% 10% 10% 10%

50V 10V 50V 25V 25V

C512 C513 C514 C561 C562

1-124-584-00 1-163-009-11 1-163-009-11 1-164-232-11 1-104-664-11

ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

100µF 0.001µF 0.001µF 0.01µF 47µF

20% 10% 10% 10% 20%

10V 50V 50V 50V 25V

C563 C564 C570 C571 C572

1-126-935-11 1-164-004-11 1-164-232-11 1-109-982-11 1-126-163-11

ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

470µF 0.1µF 0.01µF 1µF 4.7µF

20% 10% 10% 10% 20%

10V 25V 50V 10V 50V

C573 C574 C575 C576 C577

1-110-501-11 1-126-157-11 1-164-232-11 1-124-584-00 1-164-232-11

CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP

0.33µF 10µF 0.01µF 100µF 0.01µF

10% 20% 10% 20% 10%

16V 16V 50V 10V 50V

C578 ! C600 ! C601 ! C602 ! C603

1-164-232-11 1-104-705-11 1-104-705-11 1-113-900-11 1-113-900-11

CERAMIC CHIP MYLAR MYLAR CERAMIC CERAMIC

0.01µF 0.1µF 0.1µF 470PF 470PF

10% 20% 20% 10% 10%

50V 250V 250V 250V 250V

! C604 ! C605

1-113-900-11 CERAMIC 470PF 1-127-932-41 ELECT 150µF (LX50:CL,CS/LX70S:CL,CS) 1-119-882-51 ELECT(BLOCK) 120µF (LX40/LX50:MX,PA,PC,VZ/ LX60S/LX70S:MX,PA,PC,VZ) 1-130-470-00 MYLAR 820PF 1-107-737-11 MYLAR 560PF

10% 20%

250V 400V

20%

200V

5% 5%

50V 50V

! C608 C610 C611 C612 C613

1-131-974-11 1-137-921-11 1-126-935-11 1-126-160-11 1-130-496-00

FILM ELECT ELECT ELECT MYLAR

2200PF 1500µF 470µF 1µF 0.12µF

5% 20% 20% 20% 5%

800V 10V 16V 50V 50V

C615 C616 C621 C624 C626

1-131-976-21 1-126-941-11 1-124-234-00 1-126-967-11 1-126-967-11

ELECT ELECT ELECT ELECT ELECT

820µF 470µF 22µF 47µF 47µF

20% 20% 20% 20% 20%

25V 25V 16V 50V 50V

C627 C629 C630 C631 C636

1-164-232-11 1-135-372-31 1-164-232-11 1-164-232-11 1-126-935-11

CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT

0.01µF 470µF 0.01µF 0.01µF 470µF

10% 20% 10% 10% 20%

50V 10V 50V 50V 16V

C660 C661 C662 C664 C665

1-124-589-11 1-164-232-11 1-126-965-11 1-104-664-11 1-124-234-00

ELECT CERAMIC CHIP ELECT ELECT ELECT

47µF 0.01µF 22µF 47µF 22µF

20% 10% 20% 20% 20%

16V 50V 50V 25V 16V

!C605

C606 C607

7-8

Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

MA-405 Ref. No.

Part No.

Description

C666 C669 C671 C672 C701

1-124-589-11 1-164-232-11 1-126-965-11 1-164-159-21 1-104-664-11

ELECT CERAMIC CHIP ELECT CERAMIC ELECT

47µF 0.01µF 22µF 0.1µF 47µF

20% 10% 20% 20%

16V 50V 50V 50V 25V

Remarks

C702 C704 C706 C707 C709

1-164-232-11 1-126-163-11 1-164-232-11 1-164-161-11 1-126-933-11

CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT

0.01µF 4.7µF 0.01µF 0.0022µF 100µF

10% 20% 10% 10% 20%

50V 50V 50V 50V 16V

C710 C712 C794 C798 C799

1-164-232-11 1-126-933-11 1-164-489-11 1-163-133-00 1-163-133-00

CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.01µF 100µF 0.22µF 470PF 470PF

10% 20% 10% 5% 5%

50V 16V 16V 50V 50V

C800

1-163-133-00 CERAMIC CHIP

470PF

5%

50V

Ref. No.

Part No.

Description

Remarks

D607 D608

8-719-109-89 DIODE RD5.6ES-T1B2 8-719-022-97 DIODE D2S4MF

D609 D611 D612 D613 D614

8-719-083-43 8-719-313-17 8-719-313-17 8-719-043-76 8-719-160-64

DIODE 31DQ06-FA7 DIODE AU02A-V0 DIODE AU02A-V0 DIODE AK04V0 DIODE RD16F-T8B1

D623 D624 D625 D660 D661

8-719-109-93 8-719-063-70 8-719-110-49 8-719-109-85 8-719-911-19

DIODE RD6.2ES-T1B2 DIODE D1NL20U-TA2 DIODE MTZJ-T-77-18B DIODE RD5.1ES-T1B2 DIODE 1SS119-25TD

D666 D702

8-719-911-19 DIODE 1SS119-25TD 8-719-150-92 DIODE RD33ES-T1B3



ET600 ET601

CN101 1-766-978-31 CN101 1-784-484-11 CN102 1-779-723-11 CN103 * 1-766-716-11 CN104 1-506-469-11

CONNECTOR, FFC/FPC 5P CONNECTOR, FFC/FPC 5P CONNECTOR, BOARD TO BOARD 9P CONNECTOR, BOARD TO BOARD 3P PIN, CONNECTOR 4P

CN260 1-766-984-41 CN260 1-784-490-11 CN260 1-691-038-31 CN260 1-784-485-11 CN270 * 1-560-892-00

CONNECTOR, FFC/FPC 11P (LX60S/LX70S) CONNECTOR, FFC/FPC 11P (LX60S/LX70S) HOUSING, CONNECTOR 6P (LX40/LX50) CONNECTOR, FFC/FPC 6P (LX40/LX50) PIN, CONNECTOR 4P

CN350 CN350 CN351 CN401 CN402

CONNECTOR, FFC/FPC 7P CONNECTOR, FFC/FPC 7P PIN, CONNECTOR 3P CONNECTOR, FFC/FPC 9P CONNECTOR, FFC/FPC 5P

1-766-980-71 1-784-486-11 1-506-468-11 1-784-488-11 1-766-978-31

1-537-771-21 TERMINAL BOARD, GROUND 1-537-771-21 TERMINAL BOARD, GROUND

! F600 ! F600

1-532-203-00 FUSE 50CS-CL (LX50:CL,CS/LX70S:CL,CS) 1-532-743-11 FUSE, GLASS CYLINDRICAL(DIA.5) (LX40/LX50:MX,PA,PC,VZ/ LX60S/LX70S:MX,PA,PC,VZ)

FH600 FH601

1-533-217-31 HOLDER, FUSE 1-533-217-31 HOLDER, FUSE



CN402 1-784-484-11 CONNECTOR, FFC/FPC 5P ! CN600 * 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P

IC101 IC160 IC161 IC162 IC201

8-759-645-07 6-800-024-01 8-759-672-79 8-759-248-87 8-759-826-70

IC LB1943N IC M37760M8H119GP IC M24C02-WMN6T(A) IC MM1256XF-BE IC LA71053M-MPB

IC260 IC301 IC301 IC350 IC403

8-759-564-36 8-759-696-38 8-759-696-39 8-759-499-30 8-749-015-48

IC LA70011 IC AN3668FBPEBV IC AN3668FBP-V IC BA7755AF-E2 IC RPM6940

IC404 IC570 ! IC600 ! IC601 IC660

8-759-643-83 8-759-566-07 8-749-018-38 8-759-420-19 8-759-438-18

IC UPD16315GB-3BS IC LA7277M-TLM IC MA8910 IC AN1431T-TA IC PQ12RD08

CNJ562 1-793-001-21 JACK, PIN (6P) (LX60S/LX70S) CNJ562 1-779-010-11 JACK, PIN 4P (LX40/LX50)

D103 D109 D161 D162 D301

8-719-048-26 8-719-200-82 8-719-200-82 8-719-200-82 8-719-911-19

DIODE GL528V1 DIODE MPG06D-6052PKG3 DIODE MPG06D-6052PKG3 DIODE MPG06D-6052PKG3 DIODE 1SS119-25TD

D302 D351 D352 D420 D421

8-719-911-19 8-719-911-19 8-719-911-19 8-719-109-89 8-719-056-06

DIODE 1SS119-25TD DIODE 1SS119-25TD (LX40/LX50) DIODE 1SS119-25TD (LX40/LX50) DIODE RD5.6ES-T1B2 DIODE SLR-342DCT31

D561 D600 D601

8-719-110-08 DIODE RD8.2ES-T1B 8-719-051-93 DIODE DF06M-6031 8-719-063-70 DIODE D1NL20U-TA2

Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

JR001 JR002 JR003 JR004 JR006

7-9

1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

MA-405 Ref. No.

Part No.

Description

JR007 JR008 JR009 JR010 JR011

1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

Remarks

Ref. No.

JR012 JR013 JR014 JR015 JR016

1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

JR017 JR018 JR101 JR102 JR103

1-216-295-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

L101 L161 L162 L163 L201

1-414-179-51 1-414-185-51 1-414-185-51 1-414-185-51 1-414-946-21

INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR

2.2µH 22µH 22µH 22µH 39µH

JR104 JR105 JR106 JR107 JR108

1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

L202 L203 L204 L205 L206

1-414-857-51 1-414-856-51 1-414-857-51 1-414-857-51 1-414-857-51

INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR

100µH 10µH 100µH 100µH 100µH

JR109 JR110 JR111 JR112 JR113

1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

L207 L270 L303 L380 L420

1-414-193-51 1-414-857-51 1-414-857-51 1-414-857-51 1-414-185-51

INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR

220µH 100µH 100µH 100µH 22µH

JR114 JR115 JR116 JR117 JR118

1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

L500 L501 L561 L570 L601

1-414-930-21 1-414-857-51 1-414-857-51 1-414-857-51 1-403-588-11

INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR

2.2µH 100µH 100µH 100µH 22µH

JR119 JR120 JR121 JR122 JR123

1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

L602 L603 L604 L606 L660

1-403-588-11 1-414-142-11 1-414-142-11 1-414-142-11 1-410-519-11

INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR

22µH 1µH 1µH 1µH 68µH

JR124 JR125 JR126 JR127 JR128

1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

L703 L704

1-414-179-51 INDUCTOR 1-414-179-51 INDUCTOR

2.2µH 2.2µH

JR129 JR130 JR131 JR132 JR133

1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

JR134 JR135 JR136 JR137 JR138

1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00

SHORT SHORT SHORT SHORT SHORT

0 0 0 0 0

JR139

1-216-296-00 SHORT

0

0 0 (LX40/LX50)

Remarks 0 (LX40/LX50) 0 (LX40/LX50) 0

JS521 JS603 JS604 JS616

1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00

0 (LX40/LX50) 0 0 0

SHORT SHORT SHORT SHORT



! LF600

1-416-929-11 FILTER, LINE

1-517-925-11 TUBE, FLUORESCENT INDICATOR

! PH101 ! PH102 ! PH600

1-216-295-00 SHORT 1-216-295-00 SHORT

Description

1-216-296-00 SHORT 1-216-295-00 SHORT 1-216-295-00 SHORT

ND420

JS304 JS323

Part No.

JS324 JS325 JS453

8-749-015-86 PHOTO INTERRUPTER GP3S120S 8-749-015-86 PHOTO INTERRUPTER GP3S120S 8-749-010-64 PHOTO COUPLER PC123FY2

! PS101 ! PS662

7-10

1-532-727-11 LINK, IC 0.25A/150V 1-533-710-11 FUSE (SMD) Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

MA-405 Ref. No.

Part No.

Description

Remarks

TRANSISTOR PT380F3 TRANSISTOR PT380F3 TRANSISTOR 2SC1815GR-TPE2 TRANSISTOR 2SC2712Y-TE85L TRANSISTOR 2SC2712Y-TE85L

Ref. No.

Part No.

Description

Remarks

R166 R167

1-216-073-00 RES-CHIP 1-249-431-11 CARBON

10K 15K

5% 5%

1/10W 1/4W

R168 R169 R170 R171 R172

1-216-073-00 1-216-073-00 1-247-843-11 1-216-089-00 1-216-073-00

RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP

10K 10K 3.3K 47K 10K

5% 5% 5% 5% 5%

1/10W 1/10W 1/4W 1/10W 1/10W

Q101 Q102 Q103 Q201 Q202

8-729-043-84 8-729-043-84 8-729-281-53 8-729-230-49 8-729-230-49

Q203 Q204 Q301 Q302 Q303

8-729-216-21 TRANSISTOR 2SA1162Y-TE85L 8-729-422-27 TRANSISTOR 2SD601A-QRS-TX (LX60S/LX70S) 8-729-216-21 TRANSISTOR 2SA1162Y-TE85L 8-729-230-49 TRANSISTOR 2SC2712Y-TE85L 8-729-230-49 TRANSISTOR 2SC2712Y-TE85L

R174 R175 R176 R177 R178

1-216-039-00 1-249-413-11 1-249-413-11 1-249-413-11 1-216-105-91

RES-CHIP CARBON CARBON CARBON RES-CHIP

390 470 470 470 220K

5% 5% 5% 5% 5%

1/10W 1/4W 1/4W 1/4W 1/10W

Q350 Q351 Q380 Q500 Q502

8-729-281-53 8-729-230-49 8-729-821-15 8-729-216-22 8-729-216-21

TRANSISTOR 2SC1815GR-TPE2 TRANSISTOR 2SC2712Y-TE85L (LX40/LX50) TRANSISTOR 2SD1620-TD TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SA1162Y-TE85L

R179 R180 R183 R185 R187

1-216-113-00 1-216-061-00 1-216-295-00 1-216-295-00 1-216-295-00

RES-CHIP RES-CHIP SHORT SHORT SHORT

470K 3.3K 0 0 0

5% 5%

1/10W 1/10W

Q561 Q600 Q601 Q662 Q673

8-729-216-22 8-729-047-92 8-729-422-27 8-729-019-01 8-729-119-78

TRANSISTOR 2SB709A-QRS-TX TRANSISTOR 2SB1398-Q(TA).S0 TRANSISTOR 2SD601A-QRS-TX TRANSISTOR 2SD2394-EF TRANSISTOR 2SC3311A-RTA

R188 R189 R191 R192 R193

1-216-069-00 1-216-061-00 1-249-417-11 1-249-417-11 1-216-295-00

RES-CHIP RES-CHIP CARBON CARBON SHORT

6.8K 3.3K 1K 1K 0

5% 5% 5% 5%

1/10W 1/10W 1/4W 1/4W

Q674

8-729-106-68 TRANSISTOR 2SD1664-T100-R

R194 R201 R202 R203 R204

1-216-073-00 1-216-037-00 1-216-047-91 1-216-037-00 1-216-071-00

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

10K 330 820 330 8.2K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R205 R208 R209 R210 R211

1-208-830-11 1-216-295-00 1-216-067-00 1-216-053-00 1-216-065-00

METAL CHIP SHORT RES-CHIP RES-CHIP RES-CHIP

100K 0 5.6K 1.5K 4.7K

0.5%

1/10W

5% 5% 5%

1/10W 1/10W 1/10W

R212 R213 R214 R215 R216

1-216-043-91 1-216-049-00 1-216-053-00 1-216-071-00 1-249-420-11

RES-CHIP RES-CHIP RES-CHIP RES-CHIP CARBON

560 1K 1.5K 8.2K 1.8K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/4W

R219 R220 R221 R223 R224

1-247-807-31 1-216-295-00 1-216-295-00 1-216-045-00 1-216-089-00

CARBON SHORT SHORT RES-CHIP RES-CHIP

100 0 0 680 47K

5%

1/4W

5% 5%

1/10W 1/10W

R225

680

5%

1/10W

R231 R267 R270 R271

1-216-045-00 RES-CHIP (LX60S/LX70S) 1-216-089-00 RES-CHIP 1-216-295-00 SHORT 1-216-041-00 RES-CHIP 1-216-041-00 RES-CHIP

47K 0 470 470

5%

1/10W

5% 5%

1/10W 1/10W

R272 R274 R276 R277 R278

1-208-788-11 1-216-061-00 1-216-069-00 1-216-081-00 1-216-081-00

METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

1.8K 3.3K 6.8K 22K 22K

0.5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R279 R301 R302 R303 R305

1-216-081-00 1-249-417-11 1-216-049-00 1-216-049-00 1-216-033-00

RES-CHIP CARBON RES-CHIP RES-CHIP RES-CHIP

22K 1K 1K 1K 220

5% 5% 5% 5% 5%

1/10W 1/4W 1/10W 1/10W 1/10W

R101 R102 R103 R104 R105

1-249-413-11 1-216-077-91 1-216-077-91 1-249-433-11 1-249-433-11

CARBON RES-CHIP RES-CHIP CARBON CARBON

470 15K 15K 22K 22K

5% 5% 5% 5% 5%

1/4W 1/10W 1/10W 1/4W 1/4W

R106 R107 R109 R110 R111

1-249-400-11 1-249-400-11 1-249-437-11 1-216-089-00 1-216-057-00

CARBON CARBON CARBON RES-CHIP RES-CHIP

39 39 47K 47K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/10W 1/10W

R112 R113 R114 R115 R116

1-216-065-00 1-216-073-00 1-216-073-00 1-216-089-00 1-216-089-00

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

4.7K 10K 10K 47K 47K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R117 R118 R119 R120 R121

1-216-041-00 1-216-089-00 1-216-077-91 1-249-417-11 1-249-413-11

RES-CHIP RES-CHIP RES-CHIP CARBON CARBON

470 47K 15K 1K 470

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/4W 1/4W

R142 R143 R159

1-216-051-00 RES-CHIP 1-216-065-00 RES-CHIP 1-216-097-11 RES-CHIP (LX60S/LX70S) 1-216-049-00 RES-CHIP (LX60S/LX70S) 1-216-073-00 RES-CHIP (LX60S/LX70S)

1.2K 4.7K 100K

5% 5% 5%

1/10W 1/10W 1/10W

1K

5%

1/10W

10K

5%

1/10W

1-249-419-11 CARBON (LX60S/LX70S) 1-216-089-00 RES-CHIP 1-216-089-00 RES-CHIP

1.5K

5%

1/4W

47K 47K

5% 5%

1/10W 1/10W

R160 R161

R162 R164 R165

7-11

MA-405 Ref. No.

Part No.

Description

R306 R308 R310 R311 R313

1-216-033-00 1-216-091-00 1-216-295-00 1-216-295-00 1-249-437-11

RES-CHIP RES-CHIP SHORT SHORT CARBON

220 56K 0 0 47K

5% 5%

1/10W 1/10W

R427 R440 R441

1-216-053-00 RES-CHIP 1-216-075-00 RES-CHIP 1-216-085-00 RES-CHIP

1.5K 12K 33K

5% 5% 5%

1/10W 1/10W 1/10W

5%

1/4W

RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP

47K 33K 47K 47K 3.3K

5% 5% 5% 5% 5%

1/10W 1/10W 1/4W 1/10W 1/10W

RES-CHIP RES-CHIP SHORT CARBON RES-CHIP

1K 1K 0 1K 1K

1/10W 1/10W

1-216-089-00 1-216-085-00 1-249-437-11 1-216-089-00 1-216-061-00

1-216-049-00 1-216-049-00 1-216-295-00 1-249-417-11 1-216-049-00

5% 5%

R314 R316 R318 R319 R321

R445 R500 R502 R503 R504

5% 5%

1/4W 1/10W

R323 R350 R351 R352

1-216-295-00 1-216-093-91 1-216-067-00 1-249-439-11

SHORT RES-CHIP RES-CHIP CARBON (LX40/LX50) 1-216-067-00 RES-CHIP (LX40/LX50)

0 68K 5.6K 68K

5% 5% 5%

1/10W 1/10W 1/4W

R505 R507 R508 R509 R512

1-216-045-00 1-216-041-00 1-216-053-00 1-216-121-11 1-216-295-00

RES-CHIP RES-CHIP RES-CHIP RES-CHIP SHORT

680 470 1.5K 1M 0

5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W

5.6K

5%

1/10W

2.2M 68K

5% 5%

1/10W 1/4W

1-249-413-11 1-216-037-00 1-249-407-11 1-249-408-11 1-216-021-00

CARBON RES-CHIP CARBON CARBON RES-CHIP

470 330 150 180 68

5% 5% 5% 5% 5%

1/4W 1/10W 1/4W 1/4W 1/10W

5.6K

5%

1/10W

R357 R358

1-216-129-00 RES-CHIP 1-249-439-11 CARBON (LX40/LX50) 1-216-067-00 RES-CHIP (LX40/LX50) 1-216-071-00 RES-CHIP 1-216-055-00 RES-CHIP

R513 R561 R562 R563 R564

8.2K 1.8K

5% 5%

1/10W 1/10W

R565 R570 R571 R572 R573

1-216-022-00 1-208-806-11 1-249-413-11 1-249-413-11 1-216-071-00

RES-CHIP METAL CHIP CARBON CARBON RES-CHIP

75 10K 470 470 8.2K

5% 0.5% 5% 5% 5%

1/10W 1/10W 1/4W 1/4W 1/10W

R359 R362 R363 R364 R365

1-216-065-00 1-216-051-00 1-216-079-00 1-216-035-00 1-216-109-00

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

4.7K 1.2K 18K 270 330K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R574 R575 R576 R577

1-216-049-00 1-249-425-11 1-216-097-11 1-216-097-11

R366 R367 R369 R370 R371

1-216-071-00 1-216-067-00 1-216-047-91 1-216-075-00 1-216-079-00

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

8.2K 5.6K 820 12K 18K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R372 R373

560 1K

5% 5%

1/10W 1/4W

R380 R381 R382

1-216-043-91 RES-CHIP 1-249-417-11 CARBON (LX40/LX50) 1-216-017-91 RES-CHIP 1-216-063-91 RES-CHIP 1-217-671-11 RES-CHIP

47 3.9K 1

5% 5% 5%

R383 R401 R402 R407 R409

1-216-031-00 1-216-025-11 1-249-437-11 1-216-013-00 1-216-053-00

RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP

180 100 47K 33 1.5K

R410 R411 R412 R413 R415

1-216-057-00 1-216-059-00 1-216-075-00 1-216-077-91 1-216-053-00

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

R416 R417 R418 R422 R423

1-216-053-00 1-216-057-00 1-216-059-00 1-249-417-11 1-249-417-11

R424 R425

R353

R354 R355 R356

Remarks

Ref. No.

Part No.

Description

Remarks

1K 4.7K 100K 100K

5% 5% 5% 5%

1/10W 1/4W 1/10W 1/10W

R601

RES-CHIP CARBON RES-CHIP RES-CHIP (LX60S/LX70S) 1-214-949-21 METAL

3.3M

1%

1/2W

R602 R603 R604 R605 R606

1-247-883-00 1-247-891-00 1-249-430-11 1-249-419-11 1-215-444-00

CARBON CARBON CARBON CARBON METAL

150K 330K 12K 1.5K 9.1K

5% 5% 5% 5% 1%

1/4W 1/4W 1/4W 1/4W 1/4W

1/10W 1/10W 1/10W

R607 ! R611 R612 R613 R614

1-249-428-11 1-260-364-11 1-208-789-11 1-249-406-11 1-216-655-11

CARBON CARBON METAL CHIP CARBON METAL CHIP

8.2K 1M 2K 120 1.5K

5% 5% 0.5% 5% 0.5%

1/4W 1/2W 1/10W 1/4W 1/10W

5% 5% 5% 5% 5%

1/10W 1/10W 1/4W 1/10W 1/10W

R615 R616 R617 R618 R621

1-216-057-00 1-249-401-11 1-249-417-11 1-249-409-11 1-249-429-11

RES-CHIP CARBON CARBON CARBON CARBON

2.2K 47 1K 220 10K

5% 5% 5% 5% 5%

1/10W 1/4W 1/4W 1/4W 1/4W

2.2K 2.7K 12K 15K 1.5K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R622 R623 ! R640 ! R641 R643

1-216-430-11 1-247-843-11 1-219-153-11 1-219-153-11 1-216-353-00

METAL OXIDE CARBON FUSIBLE FUSIBLE METAL OXIDE

390 3.3K 10 10 2.2

5% 5% 5% 5% 5%

1W 1/4W 1/4W 1/4W 1W

RES-CHIP RES-CHIP RES-CHIP CARBON CARBON

1.5K 2.2K 2.7K 1K 1K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/4W 1/4W

R647 R648 R649 R651 R669

1-215-465-00 1-216-057-00 1-216-017-91 1-215-459-00 1-216-061-00

METAL RES-CHIP RES-CHIP METAL RES-CHIP

68K 2.2K 47 39K 3.3K

1% 5% 5% 1% 5%

1/4W 1/10W 1/10W 1/4W 1/10W

1-249-417-11 CARBON 1-216-095-00 RES-CHIP

1K 82K

5% 5%

1/4W 1/10W

R676 R678 R679

1-249-417-11 CARBON 1-249-409-11 CARBON 1-249-409-11 CARBON

1K 220 220

5% 5% 5%

1/4W 1/4W 1/4W

7-12

Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

MA-405 Ref. No.

Part No.

Description

Remarks

R680 R701

1-249-417-11 CARBON 1-249-417-11 CARBON

1K 1K

5% 5%

1/4W 1/4W

R702 R703 R704 R709 R710

1-216-061-00 1-249-412-11 1-216-043-91 1-216-049-00 1-216-049-00

RES-CHIP CARBON RES-CHIP RES-CHIP RES-CHIP

3.3K 390 560 1K 1K

5% 5% 5% 5% 5%

1/10W 1/4W 1/10W 1/10W 1/10W

R711 R712 ! R723 R724

1-216-049-00 1-216-295-00 1-240-307-81 1-216-113-00

RES-CHIP SHORT FUSIBLE RES-CHIP

1K 0 560 470K

5%

1/10W

5% 5%

1/4W 1/10W

Ref. No.

1-762-108-11 1-771-155-11 1-762-196-21 1-762-196-21 1-762-196-21

SWITCH, PUSH (1 KEY) REC PROOF SWITCH, ROTARY MODE SWITCH, TACT CHANNEL/TRACKING+ SWITCH, TACT CHANNEL/TRACKINGSWITCH, TACT EASY SET-UP

S408 S409 S410 S411 S412

1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21

SWITCH, TACT (0 REW) SWITCH, TACT (P PAUSE) SWITCH, TACT (· PLAY) SWITCH, TACT (p STOP) SWITCH, TACT (r REC)

S413 S429 S701

1-762-196-21 SWITCH, TACT () FF) 1-762-196-21 SWITCH, TACT (SEARCH) 1-571-588-11 SWITCH, SLIDE RF UNIT (CH3˜CH4)

1-757-551-11 1-500-477-11 4-6759-621-A 1-698-971-11 X-3947-577-1

FLAT CABLE FAC-009 FLAT CABLE FE HEAD HEAD BLOCK ASSY, ACE MOTOR DC MOTOR ASSY, CAM

8-839-049-53 DRUM ASSY,DZH-0A2A/Z-RP (LX40/LX50) 8-839-047-53 DRUM ASSY, DZH-0A0A/Z-RP (LX60S/LX70S)

ACCESSORIES ***********

1-569-008-21 ADAPTOR, CONVERSION 2P (LX50:CL,CS/LX70S:CL,CS) 1-575-795-61 CORD, CONNECTION (LX50/LX60S/LX70S) 1-696-592-41 CORD, CONNECTION (NTSC) (LX40/LX60S/LX70S) 1-476-436-11 COMMANDER, STANDARD(RMT-V293A) (LX40/LX50) 1-476-437-11 COMMANDER, STANDARD(RMT-V294A) (LX60S/LX70S) 3-709-432-11 COVER, REMOTE CONTROL BATTERY 3-065-284-12 MANUAL, INSTRUCTION

1-431-097-11 TRANSFORMER, BIAS OSCILLATION 1-435-790-11 TRANSFORMER, CONVERTER

TU701

Remarks

1-777-852-12 CORD, POWER (LX40/LX50:MX,PA,PC,VZ/ LX60S/LX70S:MX,PA,PC,VZ) 1-777-854-22 CORD, POWER (LX50:CL,CS/LX70S:CL,CS) 1-757-552-12 FLAT CABLE FDM-010 1-757-556-11 FLAT CABLE FFJ-004 1-757-550-11 FLAT CABLE FMD-021

T380 ! T600

Description MISCELLANEOUS **************

S101 S102 S404 S405 S406

Part No.

1-693-532-21 TUNER (BTF-3MA413)

HARDWARE LIST **************

! VDR600 1-801-267-31 VARISTOR TNR10V431K660 (LX50:CL,CS/LX70S:CL,CS) ! VDR600 1-804-048-31 VARISTOR (240NS10D) (LX40/LX50:MX,PA,PC,VZ/ LX60S/LX70S:MX,PA,PC,VZ)

X160 X161 X201

1-767-857-11 VIBRATOR, CRYSTAL 1-579-463-11 VIBRATOR, CRYSTAL 1-577-380-11 VIBRATOR, CRYSTAL

Note : The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

14.3181MHz 32.768KHz 3.579545MHz

7-13E 7-13

#1 #2 #3 #4

3-710-901-01 3-970-608-21 3-974-556-11 3-979-508-01 4-921-277-41

SCREW, TAPPING SUMITITE (B3), +BV +HEXA TT2.6X9 (TAPER) SCREW +HEXA TP SW3X8 SCREW (B2.6X8), TAPPING, BIND

7-685-648-79 7-685-646-79 7-682-647-09 7-685-133-19

SCREW +BVTP SCREW +BVTP SCREW +P3X6 SCREW +P2.6X6

3X12 TYPE2 IT-3 3X8 TYPE2 IT-3 TYPE2 NON-SLIT