color television receiver - Page de test

If an isolation transformer is not used, these units may be safely serviced only if the AC power plug is inserted so that the chassis is connected to the ground side ...
4MB taille 12 téléchargements 334 vues
COLOR TELEVISION RECEIVER Chassis : Model:

COLOR TELEVISION RECEIVER

S51A CF533CN3X/XEF CF593CN3X/XEF CF683CN3X/XEF CF5944N3X/XEF

CONTENTS 1. Precautions 2. Specifications and IC Data 3. Disassembly and Reassembly 4. Alignment and Adjustment 5. Troubleshooting 6. Exploded View and Parts List 7. Electrical Parts List 8. Block Diagram 9. PCB Layout Diagram 10. Wiring Diagram 11. Schematic Diagrams

Precautions

1. Precautions Follow these safety, servicing and ESD precautions to prevent damage and protect against potential hazards such as electrical shock and X-rays.

1-1 Safety Precautions 1. Be sure that all of the built-in protective devices are replaced. Restore any missing protective shields. 2. When reinstalling the chassis and its assemblies, be sure to restore all protective devices, including: nonmetallic control knobs and compartment covers. 3. Make sure that there are no cabinet openings through which peopleÑparticularly childrenÑmight insert fingers and contact dangerous voltages. Such openings include the spacing between the picture tube and the cabinet mask, excessively wide cabinet ventilation slots, and improperly fitted back covers. If the measured resistance is less than 1.0 megohm or greater than 5.2 megohms, an abnormality exists that must be corrected before the unit is returned to the customer. 4. Leakage Current Hot Check (Figure 1-1): Warning: Do not use an isolation transformer during this test. Use a leakagecurrent tester or a metering system that complies with American National Standards Institute (ANIS C101.1, Leakage Current for Appliances), and Underwriters Laboratories (UL Publication UL1410, 59.7). 5. With the unit completely reassembled, plug the AC line cord directly into the power outlet. With the unitÕs AC switch first in the ON position and then OFF, measure the current between a known earth ground (metal water pipe, conduit, etc.) and all exposed metal parts, including: antennas, handle brackets, metal cabinets, screwheads and control shafts. The current measured should not exceed 0.5 milliamp. Reverse the powerplug prongs in the AC outlet and repeat the test.

Samsung Electronics

LEAKAGE CURRENT TESTER

DEVICE UNDER TEST

(READING SHOULD NOT BE ABOVE 0.5mA)

TEST ALL EXPOSED METAL SURFACES 2-WIRE CORD ALSO TEST WITH PLUG REVERSED (USING AC ADAPTER PLUG AS REQUIRED)

EARTH GROUND

Fig. 1-1 AC Leakage Test 6. Antenna Cold Check: With the unitÕs AC plug disconnected from the AC source, connect an electrical jumper across the two AC prongs. Connect one lead of the ohmmeter to an AC prong. Connect the other lead to the coaxial connector. 7. X-ray Limits: The picture tube is especially designed to prohibit X-ray emissions. To ensure continued X-ray protection, replace the picture tube only with one that is the same type as the original. Carefully reinstall the picture tube shields and mounting hardware; these also provide X-ray protection. 8. High Voltage Limits: High voltage must be measured each time servicing is done on the B+, horizontal deflection or high voltage circuits. Correct operation of the X-ray protection circuits must be reconfirmed whenever they are serviced. (X-ray protection circuits also may be called Òhorizontal disableÓ or Òhold-downÓ.) Heed the high voltage limits. These include the XÐray Protection Specifications Label, and the Product Safety and X-ray Warning Note on the service data schematic.

1-1

Precautions

1-1 Safety Precautions (Continued) 9. High voltage is maintained within specified limits by close-tolerance, safety-related components and adjustments. If the high voltage exceeds the specified limits, check each of the special components. 10. Design Alteration Warning: Never alter or add to the mechanical or electrical design of this unit. Example: Do not add auxiliary audio or video connectors. Such alterations might create a safety hazard. Also, any design changes or additions will void the manufacturerÕs warranty. 11. Hot Chassis Warning: Some TV receiver chassis are electrically connected directly to one conductor of the AC power cord. If an isolation transformer is not used, these units may be safely serviced only if the AC power plug is inserted so that the chassis is connected to the ground side of the AC source. To confirm that the AC power plug is inserted correctly, do the following: Using an AC voltmeter, measure the voltage between the chassis and a known earth ground. If the reading is greater than 1.0V, remove the AC power plug, reverse its polarity and reinsert. Re-measure the voltage between the chassis and ground. 12. Some TV chassis are designed to operate with 85 volts AC between chassis and ground, regardless of the AC plug polarity. These units can be safely serviced only if an isolation transformer inserted between the receiver and the power source. 13. Some TV chassis have a secondary ground system in addition to the main chassis ground. This secondary ground system is not isolated from the AC power line. The two ground systems are electrically separated by insulating material that must not be defeated or altered.

15. Observe the original lead dress, especially near the following areas: Antenna wiring, sharp edges, and especially the AC and high voltage power supplies. Always inspect for pinched, out-of-place, or frayed wiring. Do not change the spacing between components and the printed circuit board. Check the AC power cord for damage. Make sure that leads and components do not touch thermally hot parts. 16. Picture Tube Implosion Warning: The picture tube in this receiver employs Òintegral implosionÓ protection. To ensure continued implosion protection, make sure that the replacement picture tube is the same as the original. 17. Do not remove, install or handle the picture tube without first putting on shatterproof goggles equipped with side shields. Never handle the picture tube by its neck. Some Òin-lineÓ picture tubes are equipped with a permanently attached deflection yoke; do not try to remove such Òpermanently attachedÓ yokes from the picture tube. 18. Product Safety Notice: Some electrical and mechanical parts have special safety-related characteristics which might not be obvious from visual inspection. These safety features and the protection they give might be lost if the replacement component differs from the originalÑeven if the replacement is rated for higher voltage, wattage, etc. Components that are critical for safety are indicated in the circuit diagram by shading, ( ) or ( ! ). Use replacement components that have the same ratings, especially for flame resistance and dielectric strength specifications. A replacement part that does not have the same safety characteristics as the original might create shock, fire or other hazards.

14. Components, parts and wiring that appear to have overheated or that are otherwise damaged should be replaced with parts that meet the original specifications. Always determine the cause of damage or overheating, and correct any potential hazards.

1-2

Samsung Electronics

Precautions

1-2 Servicing Precautions Warning1: First read the “Safety Precautions” section of this manual. If some unforeseen circumstance creates a conflict between the servicing and safety precautions, always follow the safety precautions. Warning2: An electrolytic capacitor installed with the wrong polarity might explode. 1. Servicing precautions are printed on the cabinet. Follow them. 2. Always unplug the unitÕs AC power cord from the AC power source before attempting to: (a) Remove or reinstall any component or assembly, (b) Disconnect an electrical plug or connector, (c) Connect a test component in parallel with an electrolytic capacitor. 3. Some components are raised above the printed circuit board for safety. An insulation tube or tape is sometimes used. The internal wiring is sometimes clamped to prevent contact with thermally hot components. Reinstall all such elements to their original position. 4. After servicing, always check that the screws, components and wiring have been correctly reinstalled. Make sure that the portion around the serviced part has not been damaged.

Samsung Electronics

5. Check the insulation between the blades of the AC plug and accessible conductive parts (examples: metal panels, input terminals and earphone jacks). 6. Insulation Checking Procedure: Disconnect the power cord from the AC source and turn the power switch ON. Connect an insulation resistance meter (500V) to the blades of the AC plug. The insulation resistance between each blade of the AC plug and accessible conductive parts (see above) should be greater than 1 megohm. 7. Never defeat any of the B+ voltage interlocks. Do not apply AC power to the unit (or any of its assemblies) unless all solid-state heat sinks are correctly installed. 8. Always connect a test instrumentÕs ground lead to the instrument chassis ground before connecting the positive lead; always remove the instrumentÕs ground lead last.

1-3

Precautions

1-3 Precautions for Electrostatically Sensitive Devices (ESDs) 1. Some semiconductor (Òsolid stateÓ) devices are easily damaged by static electricity. Such components are called Electrostatically Sensitive Devices (ESDs); examples include integrated circuits and some field-effect transistors. The following techniques will reduce the occurrence of component damage caused by static electricity. 2. Immediately before handling any semicon ductor components or assemblies, drain the electrostatic charge from your body by touching a known earth ground. Alternatively, wear a discharging wrist-strap device. (Be sure to remove it prior to applying powerÑ this is an electric shock precaution.) 3. After removing an ESD-equipped assembly, place it on a conductive surface such as aluminum foil to prevent accumulation of electrostatic charge. 4. Do not use freon-propelled chemicals. These can generate electrical charges that damage ESDs.

1-4

5. Use only a grounded-tip soldering iron when soldering or unsoldering ESDs. 6. Use only an anti-static solder removal device. Many solder removal devices are not rated as Òanti-staticÓ; these can accumulate sufficient electrical charge to damage ESDs. 7. Do not remove a replacement ESD from its protective package until you are ready to install it. Most replacement ESDs are packaged with leads that are electrically shorted together by conductive foam, aluminum foil or other conductive materials. 8. Immediately before removing the protective material from the leads of a replacement ESD, touch the protective material to the chassis or circuit assembly into which the device will be installed. 9. Minimize body motions when handling unpackaged replacement ESDs. Motions such as brushing clothes together, or lifting a foot from a carpeted floor can generate enough static electricity to damage an ESD.

Samsung Electronics

Specifications and IC Data

2. Specifications and IC Data 2-1 Specifications T e le v is io n S y s te m :

C han n e ls :

MO D E L

SYSTEM

S YS T E M

CI

P AL -I (U H F )

CII

P AL -I (V H F /U H F )

CX

P AL -B /G ,S E C AM-B/G

CK

P AL -B /G ,D /K,S E C AM-B /G ,D /K

CB

P AL -B /G

CF

SECAM-L/L' , PAL/SECAM-B/G

PAL/SE CAM -B/G,I

PAL/SE CAM -D/K

SECAM-K1, PAL-D

VHF

2-12

1-13

2-9

UHF

21-69

21-69

13-57

PAL/SECAM -B/G

PAL/SECAM -D/K,K1

P AL-I

SECAM-L

SECAM-L'

P icture IF Carrier

38.90

38.90

38.90

38.90

34.50

Sound IF Carrier

33.40

32.40

32.90

34.40

41.00

Color Sub Carrier

34.47

34.47

34.47

34.47

38.93

BAND

In ter m e diate-F r equ en c ies (MH z ): SYSTEM BAND

P ic tu r e T ub e: 21 Inch

A51EER131X31

25 Inch

A59EAK071X01 (Normal) A59EAK552X21 (Invar) A66EAK071X01 (Normal) A66EAK552X21 (Invar)

28 Inch 30 Inch

Quick start, in-line-gun, Black stripe, 90¡ degree deflection

A70QBZ791X

P o w er R e qu ir e m en ts: AC 230 V, 50Hz or AC 220 ~ 240 V, 50Hz An tenn a In p u t Im ped an c e : V H F ,U H F : T ele s c op ic dip o le ante nn a (75 W u nb alanc ed ty pe ) Sp ea k er Im p ed anc e : 8 W , 1 0W + 10 W or 16 W , 5W + 5W (533C only)

Samsung Electronics

2-1

Specifications and IC Data

2-2 IC Line Up LOC NO

NO

Specification

Description

HIC 101

1

P AP 103T

IF P R E-AMP

IC 201

2

TDA8844

PAL/SEC AM/NTSC /SE CAM-L

TDA8843

P AL /NTSC

IC 301

3

LA7845

VE R TIC AL DEF LE CTION AMP

IC 501

4

TDA6108

R GB DR IVE AMP

IC 601

5

TDA7297

SOUND AMP(10W/C H)

TDA7266S

SOUND AMP (5W/C H)

IC 701

6

TDA9859

AUDIO PR OC ESSOR

IC 801

7

KA3S1265R

SMP S IC (12A)

IC 802

8

PC 123Y

P HOTO C OUP LE R

IC 803

9

78R 05

SWITC HING R EGULATOR

IC 804

10

KA7630

SWITC HING R EGULATOR (5,8V)

IC 901

11

SPM171EE

MICOM

IC 902

12

24W16

EE P ROM

IC E01

13

4558

EW DRIVE AMP

IC N01

14

TDA9814T

IC N02

15

TDA9874H

NICAM DE MODULATOR

IC A01

16

L A7567N

SIF DETEC TOR

IC A02

17

TDA9873H

A2 DEMODULATOR

A2 STE R EO MODUL E

ICM01

18

LA7566

SIF & FM DE TE C TOR

MONO

IC S01

19

TEA5114

VIDE O SWITCH

RGB -S/W

2-2

SIF DETEC TOR (SECAM-L)

R emarks

16K

NIC AM MODUL E

Samsung Electronics

Specifications and IC Data

2-3 Semiconductor Base Diagrams ELECTROLYTICCONDENSER

IC

DIODE

TDA884X(Pin 56) SPM171EX(Pin 52) 24W16(Pin 8) TDA9859(Pin 32)

TRANSISTOR

TRANSISTOR

2SD1651 2SD1650 KSD5072 KSD5071 KSD1711

B

C

E

SAW-FILTER

IC

G1962 K2950M K9253M G3956M

UPC574J or KA33V

KSA815-Y KSA539-Y

1

E B C

IC

TRANSISTOR

TRANSISTOR

KA7630 KSR1012 KSR1010 KSR2010

KA7812

IN

G

OUT

E C B

Fig. 2-1 Semiconductor Base Diagrams

Samsung Electronics

2-3

MEMO

2-4

Samsung Electronics

Disassembly and reassembly

3. Disassembly and Reassembly 3-1 Back Cover Removal

1. After removing the 7 screws, pull the cabinet backwards.

Samsung Electronics

3-1

Disassembly and reassembly

3-2 Main Board Removal 3

1 2

11 4 13

8

5 7

12 6 9 10

1. Separate the TBC-wire 2P connector from GT501,GT502. 2. Separate the CRT Assembly from the CRT socket. 3. Remove the Anode Cap from the CRT. 4. Separate the D-Coil Connector from CN802. 5. Separate the AC cord from CN801. 6. Separate the DC connector from CN401. 7. Separate the CN501B 8P CRT connector from CN501. 8. Separate the CNA05 5P A/V side connector from CN602. 9. Separate the CNA01 8P CRT connector from CN701. 10. Separate the Focus Screen Wire from the FBT clamper. 11. Separate the TBC wire 2P, speaker wires from the wire clamper. 12. Separate the CN701, CN602 connector from the wire clamper. 13. Separate the AC cord from the wire clamper. 14. Remove the main board by pulling it with both hands.

3-2

Samsung Electronics

Disassembly and reassembly

3-3 Speaker Removal 1. Remove the speaker by pressing the tension rib.

1. Separate the speaker wires from D-coil (located on the bottom to the right side). 7

Samsung Electronics

2. Remove the screws.

3-3

Disassembly and reassembly

3-4 CRT Removal

1. Remove the 4 nuts that mount the CRT to the front cabinet. Pull the CRT backwards. 2. Caution: Because of the high vacuum and large surface area of the picture tube, be careful while handling it: (1) Always lift the picture tube by grasping it firmly around the faceplate, (2) Never lift the tube by its neck. (3) Do not scratch the picture tube or apply excessive pressure. Fractures of the glass may cause an implosion.

3-4

Samsung Electronics

Alignment and Adjustments

4. Alignment and Adjustments 4-1 Preadjustment 4-1-1 Factory Mode

4-1-3 When CRT Is Replaced

1. Do not attempt these adjustments in the Video Mode.

1. Make the following adjustments AFTER setting up after setting up purity and convergence :

2. The Factory Mode adjustments are necessary when either the EEPROM (IC902) or the CRT is replaced.

White Balance Sub-Brightness, Sub-Contrast Vertical Center Vertical Size Horizontal Size Fail Safe (This adjustment must be the last step).

3. Do not tamper with the ÒAdjustmentÓ screen of the Factory Mode menu. This screen is intended only for factory use.

4-1-2 When EEPROM (IC902) Is Replaced 1. When IC902 is replaced all adjustment data revert to initial values. It is necessary to re-program this data. 2. After IC902 is replaced, warm up the TV for 10 seconds.

4-2 Factory/Service Mode 4. Selection sequences for the PAL system:

4-2-1 Procedure for the “Adjustment” Mode DOWN or UP key: 1. This mode uses the standard remote control. The Service Mode is activated by entering the following remote-control sequence :

AGC↔VCO↔SBT↔SCT↔SCR↔SC↔RG↔ BG↔CDL↔STT↔LCO↔VOL↔PSL↔PVS↔ PVA↔PHS↔PEW↔PEP↔PEC↔PET↔VSC↔ TSC↔SA↔QEW↔PCT↔PTT↔PHM↔PVP↔ PHP↔NSR↔PDL↔AGC.

(1) STAND-BY® DISPLAY® MENU® MUTE ®POWER ON. 2. The ÒSERVICE (FACTORY)Ó message will be displayed. The Service Mode has three components: Adjustment, Option and Reset. 3. Access the Adjustment Mode by pressing the ÒVOLUMEÓ keys ( Up or Down). The adjustment parameters are listed in the accompanying table, and selected by pressing the CHANNEL keys (▲ ,▼).

Samsung Electronics

5. The VOLUME keys increase or decrease the adjustment values (stored in the non-volatile memory) when Adjustment Mode is cancelled. 6. Cancel the Adjustment Mode by re-pressing the ÒHIDDENÓ or ÒPower OFF/ONÓ keys. 7.

After adjustments are completed, re-start the TV set.

4-1

Alignment and Adjustments

4-2-2 Main Adjustment Parameters OSD

FUNCTION

RANGE

AGC

AUTO GAIN CONTROL

0 - 63

VCO

VOLTAGE CONTROLLED OSCILLATOR

0 - 127

SBT

SUB BRIGHTNESS

0 - 23

SCT

SUB CONTRAST

0 - 23

SCR

SUB COLOUR

0 - 23

SC

S-CORRECTION

0 - 63

RG

RED DRIVE GAIN

0 - 63

BG

BLUE DRIVE GAIN

0 - 63

CDL

CATHODE DRIVE LEVEL

0-7

STT

SUB TINT ( FOR NTSC )

0-7

LCO

SECAM-L VOLTAGE CONTROLLED OSCILLATOR

0-1

VOL

VOLUME INITIAL LEVEL

0 - 63

PSL

PAL VERTICAL SLOPE

0 - 63

PVS

PAL VERTICAL SHIFT

0 - 63

PVA

PAL VERTICAL AMPLITUDE

0 - 63

PHS

PAL HORIZONTAL SHIFT

0 - 63

PEW

PAL E-W WIDTH

0 - 63

PEP

PAL E-W PALABOLA

0 - 63

PEC

PAL E-W CORNER

0 - 63

PET

PAL E-W TRAPEZIUM

0 - 63

VSC

VERTICAL SCROLL

0 - 63

TSC

TELETEXT SUB CONTRAST

0 - 63

SA

SEPARATION ADJUSTMENT (STEREO)

0 - 15

QEW

Q(12.8:9) MODEL E-W WIDTH

0-7

PCT

PIP CONTRAST

0 - 15

PTT

PIP TINT

0 - 63

PHM

PIP HORIZONTAL MOVE

0 - 15

PVP

PIP VERTICAL POSITION

0 - 63

PHP

PIP HORIZONTAL POSITION

0 - 63

NSR

NTSC SUB COLOUR

0 - 23

PDL

PAL DELAYTIME

0 - 15

4-2

Samsung Electronics

Alignment and Adjustments

FACTORY MODE VALUE OSD

INITIAL

2 (CH)

OSD

INITIAL

OSD

INITIAL

LCO

1 (FIXED)

TSC

20(FIXED)

AGC

10

VOL

25

SA

7

VCO

80(FIXED)

PSL

31(FIXED)

QEW

5

SBT

7

PVS

31

PCT

7(FIXED)

SCT

16

PVA

31

PTT

31(FIXED)

SCR

5(FIXED)

PHS

40

PHM

8(FIXED)

SC

11(FIXED)

PEW

38

PVP

31(FIXED)

RG

31

PEP

22

PHP

31(FIXED)

BG

31

PEC

22

NSR

3 (FIXED)

CDL

5

PET

30

PDL

0 (FIXED)

STT

10(FIXED)

VSC

31(FIXED)

4-2-3 AGING Mode (Reference Only) This pattern is used for pre-heating the CRT during manufacturing--it is accessed in the factory by twice pressing the ÒFACTORY Ò key. Even if the TV power is cut off, the Aging Mode is not cancelled, The AGING mode is cancelled by repressing the ÒHIDDENÓ or any key on the front pannel.

Samsung Electronics

4-3

Alignment and Adjustments

4-2-4 Option Byte Table Option Byte 1.ZOOM MODE : NORMAL/ZOOM/16:9 2.AUDIO MODE : NICAM STEREO 3.ONE CHIP : TDA8844 4.LED OPTION : NORMAL 5.LANGUAGE : WEST ENG/GER/FRA/DUT/SPA/ITA/SWE 6.SYSTEM: CX 7.ATS OPTION : ON 8.FIELD POL : FIELD POS OPTION

ZOOM MODE

AUDIO MODE

ONECHIP LED OPTION

LANGUAGE

SYSTEM

ATS OPTION FIELD POL

4-4

OSD

NOTE

PLU/NOR/ZOOM/16:9

12.8 : 9 CRT USED(30",22")

NORMAL/ZOOM/16:9

NORMAL CRT USED

NORMAL/ZOOM PLUS/NORMAL

12.8 : 9 CRT USED(26")

NICAM STEREO

NICAM MODULE USED

STEREO

A2 MODULE USED

LINE STEREO

MONO MODULE USED (LINE STEREO MODEL )

MONO

MONO MODULE USED (MONO MODEL )

TDA8844

CRT(MORE THAN 22-INCH)USED

TDA8842

CRT(MORE THAN 21-INCH)USED

NORMAL

DEFAULT

POLAND

POLAND MODEL ONLY

WEST ENG/GER/FRA/DUT/SPA/ ITA/SWE

WEST EUROPE MARKET ENGLISH/GERMANY/FRANCE/ NETHERLANDS/SPAIN/ITALY/SWEDEN

EAST ENG/CZE/CRO/RUM/HUN/ POL

EAST EUROPE MARKET ENGLISH/CZECH/CROATIA/ROMANIA/ HUNGARY/POLAND

CF

SECAM-L/L', PAL/SECAM-B/G

CI

PAL - I ( UHF BAND ONLY)

CK

PAL/SECAM - B/G,D/K

CX

PAL/SECAM -B/G

CB

PAL -B/G

ON

ATM FUNCTION USED

OFF

ATM FUNCTION NOT USED

FIELD POS

PHILIPS CRT USED

FIELD NEG

OTHER CRT USED

Samsung Electronics

Alignment and Adjustments

Alignment and Adjustments

4-2-5 RESET The Reset Mode is used during factory inspection. Function Reset: 1. 2. 3.

Channels Language Station name

Add/Erase Last condition Clear

4-3 Other Adjustments 4-3-1 General 1. Usually, a color TV needs only slight touchup adjustment upon installation. Check the basic characteristics such as height, horizontal and vertical sync and focus. 2. The picture should have good black and white details. There should be no objectionable color shading; if color shading is present, perform the purity and convergence adjustments described below. 3. Use the specified test equipment or its equivalent. 4. Correct impedance matching is essential. 5. Avoid overload. Excessive signal from a sweep generator might overload the front-end of the TV. When inserting signal markers, do not allow the marker generator to distort test results.

4-3-2 Automatic Degaussing A degaussing coil is mounted around the picture tube, so that external degaussing after moving the TV should be unnecessary. But the receiver must be properly degaussed upon installation. The degaussing coil operates for about 1 second after the power is switched ON. If the set has been moved or turned in a different direction, disconnect its AC power for at least 30 minutes. If the chassis or parts of the cabinet become magnetized, poor color purity will result. If this happens, use an external degaussing coil. Slowly move the degaussing coil around the faceplate of the picture tube and the sides and front of the receiver. Slowly withdraw the coil to a distance of about 6 feet before removing power.

6. Connect the TV only to an AC power source with voltage and frequency as specified on the backcover nameplate. 7. Do not attempt to connect or disconnect any wires while the TV is turned on. Make sure that the power cord is disconnected before replacing any parts. 8. To protect against shock hazard, use an isolation transformer.

Samsung Electronics

4-5

Alignment and Adjustments

Alignment and Adjustments

4-3-3 High Voltage Check

4-3-6 Purity Adjustment

CAUTION: There is no high voltage adjustment on this chassis. The B+ power supply must be set to +155 volts (Full color bar input and normal picture level).

1. Warm up the receiver for at least 20 minutes.

1. Connect a digital voltmeter to the second anode of the picture tube.

2. Plug in the CRT deflection yoke and tighten the clamp screw. 3. Plug the convergence yoke into the CRT and set in as shown in Fig. 4-2.

2. Turn on the TV. Set the Brightness and Contrast controls to minimum (zero beam current).

4. Input a black and white signal.

3. The high voltage should not exceed 33KV.

5. Fully demagnetize the receiver by applying an external degaussing coil.

4. Adjust the Brightness and contrast controls to both extremes. Ensure that the high voltage does not exceed 33KV under any conditions.

6. Turn the CONTRAST and BRIGHTNESS controls to maximum.

4-3-4 FOCUS Adjustment

7. Loosen the clamp screw holding the yoke. Slide the yoke backward or forward to provide vertical green belt. (Fig. 4-3).

1. Input a black and white signal. 2. Adjust the tuning control for the clearest picture. 3. Adjust the FOCUS control for well defined scanning lines in the center area of the screen.

4-3-5 Screen Adjustment 1. Connect CRT socket pin GK, BK, RK to an oscilloscope probe.

8. Tighten the convergence yoke. 9. Slowly move the deflection yoke forward, and adjust for the best overall green screen. 10. Temporarily tighten the deflection yoke. 11. Produce blue and red rasters by adjusting the low-light controls. Check for good purity in each field. 12. Tighten the deflection yoke.

2. Input a gray scale pattern. (Use a pattern generator, PM5518) 3. Use the Picture mode for the STANDARD picture. 4. Adjust the Screen VR (on the FBT) so that the _ voltage on the oscilloscope becomes 140+2.5V (See Fig. 4-1).

140 +_ 2.5V

GND Fig. 4-1 4-6

Samsung Electronics

Alignment and Adjustments

Alignment and Adjustments

4 Pole Magnet 2 Pole Magnet

6 Pole Magnet

2 POLE PURITY

Clamper Screw

YOKE CLAMP SCREW 6 POLE CONVERGENCE 4 POLE CONVERGENCE

Fig. 4-2 Convergence Magnet Assembly

Vertical Green Belt

31m/m

Fig. 4-3 Center Convergence Adjustment

4-3-7 White Balance Adjustment (a) Set up

1

1. Warm up the TV for at least 30 minutes in the White Pattern. 2. Input a Toshiba pattern. (b) High-Light Adjustment

2

Set SCT to 40 ± 5 fL in the Factory Service Mode with using CA100. (See Fig. 4-4 ①) (c) Low-Light Adjustment

Fig. 4-4

Samsung Electronics

Set SBT to 1.5 ± 0.2 fL in the Factory Service Mode with using CA100. (See Fig. 4-4 ➁)

4-7

Alignment and Adjustments

Alignment and Adjustments

4-3-8 Center Convergence Adjustment 1. Warm up the receiver for at least 20 minutes. 2. Adjust the two tabs of the 4 pole magnets to change the angle between them. Superimpose the red and blue vertical lines in the center area of the screen. 3. Adjust the Brightness and Contrast controls for a well defined picture. 4. Adjust the two-tab pairs of the 4 pole magnets, and change the angle between them. Superimpose the red and the blue vertical lines in the center area of the screen.

BLUE

5. Turn the both tabs at the same time, keeping the angle constant, and superimpose the red and blue horizontal line in the center of the screen. 6. Adjust the two-tab pairs of the 6-pole magnets to superimpose the red and blue line onto the green. (Changing the angle affects the vertical lines, and rotating both magnets affects the horizontal lines.) 7. Repeat adjustments 2~6, if necessary. 8. Since the 4-pole magnets and 6-pole magnets interact, the dot movement is complex (Fig. 4-5).

RED/BLUE

RED

BLUE

RED/BLUE

RED

GREEN

GREEN

6-Pole Magnet Movement

4-Pole Magnet Movement

Fig. 4-5 Center Convergence Adjustment

4-3-9 RF AGC Adjustment 1. Tune to the strongest local station. 2. Enter the Factory Service Mode to make adjustments. 3. Adjust the AGC control untill noise(snow) disappears from the screen.

4-8

Samsung Electronics

Alignment and Adjustments

Alignment and Adjustments

4-3-10 Geometry Adjustment 1. Input a lion head pattern. 2. Adjus t PVS s o that the pic ture is vertically centered. 3. Adjus t with PVA s o that the top and bottom margins of the pic ture are 4. 4. Adjus t PHS s o that the pic ture is horizontally centered. 5. Adjus t with PEW s o that the left and right margins of the picture are 5. 4

5

5 4

6. Input a crosshatch pattern. 7. Adjus t PEP, PEC , PET for vertical linearity.

Samsung Electronics

4-9

Troubleshooting

5. Troubleshooting 5-1 No Video (Raster On, No Sound)

Measure the Voltage of each of, 8 pins of TU101

No

Check/Replace TU101, HC101

No

Check/Replace IC901,IC201,IC902 ,IC701, Audio Module

Yes

Check IC901 Pins 39, 40 Yes

See "No Video" (Sound OK)

Samsung Electronics

See "No Sound" (Video OK)

5-1

Troubleshooting

5-2 No Power

Check the 130V, 12.7V B+ Lines

No

Check/Replace IC801, D802

Yes

Check IC804 Pin 9 (5V)

No

Check/Replace IC804(KA7630),DZ905,DZ804

No

Check/Replace IC901

No

Check/Replace IC901(m-com)

No

Check/Replace IC201, Q402, Q403

No

Check/Replace DZ805, IC802

Yes

Check IC901 Pin 8 (4V).

Yes

Check IC901 Pin 18 ; Stand-by : 0V Normal : 5V

Yes

Check IC201, Pin 40 (H-out)

Yes

Check Q402, Q403

5-2

Samsung Electronics

Troubleshooting

5-3 No Video (Sound OK)

Check IC201 Pin 12,37 (8V)

No

Check/Replace IC804 KA7630

No

Check/Replace IC201

Yes

Check IC201 Pin 6 (CVBS) 2Vp-p Yes

Check IC201 Pins 19, 20, 21 (R/G/B-OUT)

No

Yes

Check IC202 pin 27 (Y-IN)

No

Check/Replace IC201,D205,DZ204

No

Check/Replace IC501

Yes

Check IC501, on the CRT PCB

Yes

Check/Replace R505 (HEATER 6.3Vrms) CRT, V999

Samsung Electronics

5-3

Troubleshooting

5-4 No Sound (Video OK)

CHECK IC701 Pin 3,5

No

CHECK/REPLACE Sound Module (MD701)

No

CHECK/REPLACE IC701, C712, C719

No

CHECK/REPLACE IC601, R601, R602

Yes

CHECK IC701 Pin 15,18

Yes

CHECK IC601 Pin 1 2 14 15 Sound output Yes CHECK/REPLACE A/V Front Assembly.

5-5 Power OFF/ON (Repeatedly) CHECK Q403 COLLECTOR H-PULSE

NO

SEE " NO-POWER"

YES

CHE CK IC901 PIN26(H-SYNC )

NO

CHE CK/REPLACE IC901,Q907,C913 DZ402

YES

CHE CK IC301 PIN7(V-BLANK)

YES

CHE CK/REPLACE Q301,Q302,D304

NO

CHECK PIN6(+16.5V) PIN1(-14V)

NO

CHE CK/REPLACE R409,R413,D407,D410 DZ302,DZ303

YES CHECK/RE PLACE IC301,IC201

5-4

Samsung Electronics

Troubleshooting

5-6 SMPS (Power Supply) Does Not Function (1) W he n F 802 is op en : C he ck/Replace F 8 02 , IC 80 1 , D 80 2. (2) W he n F 802 is okay, but SMP S doe s n ot fu nction: C he ck/Replace D Z80 1 , D Z8 08 , IC 80 2 , D Z8 05 . (3) O the rs: S ee "5. Tro ublesh ooting"

Samsung Electronics

5-5

Exploded View & Parts List

6. Exploded View & Parts List 6-1 CF5944N3X/XEF

No

Code No

Description ; Specification

1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 1-8 1-9 1-10 1-11 1-12 1-13 1-14 1-15

HA91-100012 HA64-300037 HA64-300027 AA63-50294A AA63-50295A AA64-70117B HA64-10614A AA61-60005K HA95-900009 AA60-10002A AA61-40053A 3001-000150 6002-000514 AA61-10068A AA95-40012A HA64-10613A HA64-40395A HA64-40394A

ASSY-CABINET,FRONT;5944 CABINET-FRONT;-,5944,P94.908,HIPS,BLK CABINET-FRONT;-,5944,-,HIPS,HB,BLK,-,GRILLE-WOOFER,L;DP,5944,AA63-50289A,-,-,-,GRILLE-WOOFER,R;DP,5944,AA63-50293A,-,-,-,BADGE-BRAND;AL,SS,SILVER,L65,R2000,-,KNOB-POWER,M;-,ABS,HB,BLK,-,5944 SPRING-CS;-,SUS304,0.6,OD12.2,H13,N4,-,ASSY-PCB,A/V FRONT;SCT12A/12B SCREW-TAPPING;RH,+,M4,L12,ZPC(YEL),-,OD14 STOPPER-PCB;ALL MODEL,HIPS HB,WHT,HB,-,SPEAKER;20W,8ohm,91dB,130Hz SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK),SWRCH18 BRACKET-PCB;-,M2160,SPTE,T0.3,-,-,ASSY-SOUND;-,-,S51A,SECAM-L,NICAM,CF ALL, KNOB-CONTROL;-,ABS,HB,BLK,-,5944 INDICATOR-LED;-,ACRYL,HB,-,CLR,-,5944 WINDOW-REMOCON;-,ABS,HB,-,LG-41338,-,5944

1 1 1 1 1 1 1 1 1 2 1 2 8 1 1 1 1 1

2 2-1 2-2 2-3 2-4

AA03-10026Y AA65-30017A AA60-10050Q AA27-20004G 3704-001105

CRT-COLOR;-,A59EEQ111X91,+400MG,25,110D CLAMP-D,COIL;NYLON-66,V0,NTR,DADH300,25 20 SCREW-ASSY;WC,HH,+,M5,L26.5,SWRCH18A,ZPC( COIL-DEGAUSSING;-,25,16.9ohm,35T,L2600,E SOCKET-CRT;11P,20PI,26.5PI,NI,-

1 4 4 1 1

3 3-1 3-2

HA64-300022 6002-000514 AA96-00175A

CABINET-BACK;5944,HIPS,V2,BLK,-,-, SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK),SWRCH18 ASSY-POWER,CORD;-,CP2/NO(4.0),H/C450,KKJ1004A,

1 5 1

Samsung Electronics

Q’ty

Remark

6-1

Electrical Parts List

7. Electrical Parts List

7-1 CF533CN3X/XEF (CF5944N3X AND CF533CN3X Dissimilar Parts) Loc. No.

Code No.

Description ; Specification

Remark

Loc. No.

ASSY-PCB,MAIN

! !

!

! ! !

HA94-100424 ASSY-PCB,MAIN;CF533C-5344N3X/XEF,S51A,SE

C406 C415 C427 CN802 D805 IC201 IC801 L401 L402 L403 Q403 R237 R304 R305 R308 R404 R415 R417 R423 R810 R811 R815 RP803 T401 T444 T801

2306-000350 C-FILM,MPPF;270nF,5%,400V,BK,26x18.5x10, 2306-000253 C-FILM,MPPF;7.2nF,5%,1.6KV,TP,28.5x18.5x 2201-000406 C-CERAMIC,DISC;270pF,10%,2KV,Y5P,TP,8x6, AA27-20003Z COIL-DEGAUSSING;-,21,13.5ohm,25T,L2380, 0402-000231 DIODE-RECTIFIER;FMG-G26S,600V,4A,TO-220F 1204-001440 IC-VIDEO SYSTEM;TDA8842,DIP,56P,300MIL,P 1203-001494 IC-PWM CONTROLLER;3S0680RF,TO3PF-5L,5,21 AA27-40003GCOIL-HORIZ,WIDTH;-,90/260UH,SB-5SOS6*20, AA27-30001B COIL-LINEARITY;-,195UH,QIC1010,PI0.4,4.5 2001-001037 R-CARBON(S);0.39OHM,5%,1/2W,AA,TP,2.4X6. 0502-001115 TR-POWER;KSC5386,NPN,50W,TO-3PF,ST,82001-000812 R-CARBON;5.6KOHM,5%,1/8W,AA,TP,1.8X3.2M 2003-002070 R-METAL OXIDE;1ohm,5%,2W,AF,TP,3.9x10mm 2003-002009 R-METALOXIDE(S);390ohm,5%,2W,AF,TP,3.9x 2003-000998 R-METAL OXIDE;300ohm,5%,2W,AF,TP,3.9x10m 2003-000540 R-METALOXIDE(S);1KOHM,5%,2W,AF,TP,4X12M 2008-000266 R-FUSIBLE(S);1OHM,5%,2W,AF,TP,3.9X10MM 2004-001407 R-METAL(S);82.5KOHM,1%,1/2W,AA,TP,2.4*6. 2003-000540 R-METALOXIDE(S);1KOHM,5%,2W,AF,TP,4X12M 2003-000782 R-METALOXIDE(S);7.5Kohm,5%,2W,AA,TP,4x1 2003-000462 R-METALOXIDE(S);10Kohm,5%,2W,AA,TP,4x12 2004-004089 R-METAL;123KOHM,1%,1/2W,AA,TP,2.5X6.5M 1404-001048 THERMISTOR-PTC;7OHM,30%,200/220V,270V,19 AA26-50001B HORIZ.DRIVE;-,7.1MH,102UH,10-20UH,YL081, AA26-30005Y TRANS-FLYBACK;-,FSV-20B0001A,20,125V AA26-20007WTRANS-SWITCHING;-,90~260V,130/15.5/12/8V

Description ; Specification

Remark

ASSY-CABINET OPTION ; CF533CN3X

BUYER : SEF *

Code No.

*

HA91-100018 ASSY-CABINET,FRONT;533C HA64-300050 CABINET-FRONT;-,533C,P94.908,HIPS,HB,BLK HA64-300033 CABINET-FRONT;-,533C,-,HIPS,HB,BLK,-,HA64-31242ACABINET-BACK;-,533C,-,HIPS,V2,BLK,-,HA60-020002 SCREW-TAPPING;DP,RH,+,2,M4,L15,ZPC(BLK), AA65-30107ACLAMP-D,COIL;NYLON 66,V2,NTR,-,20~22 AA61-60003T SPRING-CS;-,SUS304,0.5,OD7,H13.5,N5,-,-, HA64-100004 KNOB-POWER;-,ABS,HB,BLK,-,533 AA64-40500B WINDOW-REMOCON;-,533C,-,PC,VO,VIOLET,AA64-40238AINDICATOR-LED;-,62.7202,-,ACRYL,-,-,AA64-70123B BADGE-BRAND;AL,R2000,SILVER,L=50,SAMSUNG HA64-100003 KNOB-CONTROL;-,ABS,HB,BLK,-,533C

ASSY-SPEAKER 3001-000280 SPEAKER;5W,16OHM,90DB,150HZ AA39-20504B LEAD CONNECTOR-ASSY;-,SMH025-04,REC,4P,3

ASSY-POWER,CORD !

AA39-10001GPOWER-CORD;-,KKP-419C,KLCE-2F,2.286M,HOU AA61-20284AHOLDER;-,P-CORD,PP,VO,BLK,KE-002

ASSY-CRT ! !

AA03-10031E CRT-COLOR;-,A51EER131X,+400mG,21,90deg, AA27-50005GDEFLECTION-YOKE;-,DST-21944(2),21/A51EE AA63-60028ASPACER-DY;NEOPRENE,-,BLK,V0 AA27-00002AMAGNET-CONVERGENCE;-,JH291-SC-OB,29.1MM

Samsung Electronics

7-1

Electrical Parts List

7-2 CF593CN3X/XEF (CF5944N3X AND CF593CN3X Dissimilar Parts) Loc. No.

Code No.

Description ; Specification

Remark

Loc. No.

ASSY-PCB,MAIN HA94-100434 ASSY-PCB,MAIN;CF593CN3X/XEF,S51A,SEB,01

ASSY-PCB,CONTROL *

HA95-900014 ASSY-PCB,CONTROL;3C,S51A

CGT02 CN11A CR01

AA39-20041B LEAD-CONNECTOR,ASSY;-,YFH800-02,S,2P,300 AA39-20005ALEAD-CONNECTOR,ASSY;-,YBNH025-03,67096-0 2401-001495 C-AL;47uF,20%,16V,GP,TP,5x11,|

Description ; Specification

Remark

HA64-300021 CABINET-BACK;593C/623C,HIPS,V2,BLK,-,-, AA61-70052ARAIL-PCB;-,CX-703C,ABS,V0,BLK,-,AA61-30001ACATCH-DOOR;-,-,-,KIFUCO LA701 AA61-60005ASPRING-CS;-,SUS304,0.6,OD10.7,H10,N4,-,HA64-10663AKNOB-CONTROL;-,CX-703C,-,ABS,HB,BLK HA64-10662AKNOB-POWER,M;-,CX-703C,-,ABS,HB,BLK HA64-40421AINDICATOR-LED;-,CX703C,-,ACRYL,HB,CLR,HA64-40422AWINDOW-REMOCON;-,CX703C,-,PC,V0,BLK,HA64-50221ADOOR-CONTROL;-,CX-703C,-,HIPS,HB,BLK,-,-

BUYER : SEF *

Code No.

ASSY-CABINET OPTION ; CF593CN3X *

HA91-100011 ASSY-CABINET,FRONT;593C/623C HA64-300056 CABINET-FRONT;-,593C/623C,P94.908,HIPS,H HA64-300026 CABINET-FRONT;-,593C/623C,-,HIPS,HB,BLK,

7-3 CF683CN3X/XEF (CF5944N3X AND CF683CN3X Dissimilar Parts) Loc. No.

Code No.

Description ; Specification

Remark

ASSY-PCB,MAIN BUYER : SEF * C406 C414 C427 CN802 L402 R305 R505 ! T444

HA94-100444 ASSY-PCB,MAIN;CF683CN3X/XEF,S51A,PHIL,01

Loc. No.

Code No.

Description ; Specification

Remark

HA64-40421AINDICATOR-LED;-,CX703C,-,ACRYL,HB,CLR,HA64-40422AWINDOW-REMOCON;-,CX703C,-,PC,V0,BLK,HA64-50221ADOOR-CONTROL;-,CX-703C,-,HIPS,HB,BLK,-,HA64-10663AKNOB-CONTROL;-,CX-703C,-,ABS,HB,BLK

2306-000204 C-FILM,MPPF;430nF,5%,400V,TP,26x20.5x12. 2306-000354 C-FILM,MPPF;7.2nF,5%,1.6KV,BK,31x18.5x12 2201-000406 C-CERAMIC,DISC;270pF,10%,2KV,Y5P,TP,8x6, AA27-20004K COIL-DEGAUSSING;-,29,19.0ohm,45T,3000mm AA27-30003GCOIL-LINERITY;-,44uH,DR14x15,PI0.2x10,18 2003-000998 R-METAL OXIDE;300ohm,5%,2W,AF,TP,3.9x10m 2008-000266 R-FUSIBLE(S);1OHM,5%,2W,AF,TP,3.9X10MM AA26-30005V TRANS-FLYBACK;-,FUH-29A004,29,155V

ASSY-PCB,CONTROL *

HA95-900014 ASSY-PCB,CONTROL;3C,S51A

CGT02 CN11A CR01

AA39-20041B LEAD-CONNECTOR,ASSY;-,YFH800-02,S,2P,300 AA39-20005ALEAD-CONNECTOR,ASSY;-,YBNH025-03,67096-0 2401-001495 C-AL;47uF,20%,16V,GP,TP,5x11,|

ASSY-CRT AA39-20519ALEAD CONNECTOR-ASSY;-,YFH806-06,-,6(4)P, AA03-00018ACRT-COLOR;-,A66EHJ43X31,+380MG,-,110DEG,

!

ASSY-CABINET OPTION CF683CN3X *

7-2

HA91-100015 ASSY-CABINET,FRONT;703C/683C HA64-300059 CABINET-FRONT;-,703C/683C,P94.908,HIPS,H HA64-300030 CABINET-FRONT;-,683C/703C,-,HIPS,HB,BLK, 2401-000647 C-AL;2.2uF,20%,50V,BP,TP,5x11|5 3001-000114 SPEAKER;10W,8OHM,90DB,2KHZ HA64-300025 CABINET-BACK;683C/703C,HIPS,V2,BLK,-,-, AA61-70052ARAIL-PCB;-,CX-703C,ABS,V0,BLK,-,AA61-30001ACATCH-DOOR;-,-,-,KIFUCO LA701 AA61-60005ASPRING-CS;-,SUS304,0.6,OD10.7,H10,N4,-,HA64-10662AKNOB-POWER,M;-,CX-703C,-,ABS,HB,BLK

Samsung Electronics

Electrical Parts List

7-4 CF5944N3X/XEF Parts List Loc. No.

Code No.

Description ; Specification

Remark

ASSY-PCB,MAIN BUYER : SEF *

HA94-100422 ASSY-PCB,MAIN;CF5944N3X/XEF,S51A,SEB,01

C102 C103 C104 C105 C106 C107 C109 C207 C210 C211 C213 C214 C215 C216 C217 C218 C219 C220 C221 C222 C223 C224 C225 C226 C226 C227 C228 C229 C230 C231 C232 C233 C234 C235 C236 C237 C238 C239 C240 C241 C242 C243 C244 C245 C301 C302 C303 C304 C305 C306 C307 C308 C309 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416

2401-002594 2202-002037 2202-002037 2202-002037 2401-001082 2401-002619 2202-000796 2401-001026 2306-000122 2401-002619 2301-000224 2401-000660 2305-000412 2401-001840 2305-000665 2305-000411 2401-002144 2401-000302 2305-000289 2305-000412 2202-002037 2202-002037 2202-002037 2401-000480 2401-000939 2201-000986 2201-000273 2301-000356 2301-000192 2202-000183 2202-000796 2309-000138 2305-000289 2202-000849 2202-002037 2305-000665 2301-000383 2301-000445 2401-001840 2401-000603 2202-000806 2401-000603 2301-000224 2305-000665 2301-000254 2401-000360 2201-000259 2305-000285 2305-000149 2301-000224 2401-000360 2401-000480 2401-001840 2401-000901 2201-000291 2401-002268 2306-000188 2201-000984 2305-000382 2201-000551 2401-001397 2305-000178 2201-000599 2401-000962 2306-000237 2306-000178 2303-001026

Samsung Electronics

C-AL;220uF,20%,16V,GP,TP,8x11.5,5 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-AL;330nF,20%,50V,GP,TP,5x11,5 C-AL;47uF,20%,25V,GP,TP,5x11,5 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,C-AL;3.3uF,20%,50V,GP,TP,5x11mm,5mm C-FILM,MPPF;100nF,5%,50V,TP,7.3x4.0x5.0mm, C-AL;47uF,20%,25V,GP,TP,5x11,5 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm,5m C-AL;2.2uF,20%,50V,GP,TP,5x11,5 C-FILM,MPEF;470nF,5%,63V,TP,-,5mm C-AL;100uF,20%,16V,GP,TP,6.3x11,5 C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, C-FILM,MPEF;470nF,5%,50V,TP,7.3x4.8x5.5mm, C-AL;47uF,20%,16V,GP,TP,5x11,5 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm C-FILM,MPEF;470nF,5%,63V,TP,-,5mm C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-AL;10uF,20%,50V,GP,TP,5x11,5 C-AL;22uF,20%,25V,GP,TP,5x11,5 C-CERAMIC,DISC;12pF,5%,50V,NPO,TP,5x3mm,2.5mm C-CERAMIC,DISC;18pF,5%,50V,CH,TP,5x3mm,5 C-FILM,PEF;47nF,5%,50V,TP,7.5x4.0x6.5,5mm C-FILM,PEF;1nF,5%,50V,TP,5.3x10mm,5mm C-CERAMIC,MLC-AXIAL;2.2nF,20%,16V,Y5R,TP,3.5x19,C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,C-FILM,PE-PPF;100nF,5%,50V,TP,20x16x8.5,7.5m C-FILM,MPEF;220nF,5%,63V,TP,-,5mm C-CERAMIC,MLC-AXIAL;18pF,5%,50V,CH,TP,3.5x1.9,C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, C-FILM,PEF;10nF,5%,50V,TP,6x7x3.2mm,5mm C-FILM,PEF;4.7nF,5%,50V,TP,5.5x7x3mm,5mm C-AL;100uF,20%,16V,GP,TP,6.3x11,5 C-AL;1uF,20%,50V,GP,TP,5x11,5 C-CERAMIC,MLC-AXIAL;220PF,10%,50V,Y5P,TP,3.5*19,C-AL;1uF,20%,50V,GP,TP,5x11,5 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm,5m C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, C-FILM,PEF;39nF,5%,50V,TP,7.5x3.5x6.5mm,5 C-AL;100uF,20%,50V,GP,TP,8x11.5,5 C-CERAMIC,DISC;180pF,10%,500V,Y5P,TP,6x4,5 C-FILM,MPEF;220nF,5%,100V,TP,20x18x11.5,15 C-FILM,MPEF;100nF,5%,100V,TP,12x12.5x6.5,5 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm,5m C-AL;100uF,20%,50V,GP,TP,8x11.5,5 C-AL;10uF,20%,50V,GP,TP,5x11,5 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 C-AL;22uF,20%,160V,GP,TP,10x20,5 C-CERAMIC,DISC;1nF,10%,500V,Y5P,TP,8.5x5MM,5 C-AL;2.2uF,20%,250V,LZ,TP,8X11,5 C-FILM,MPPF;330nF,5%,400V,TP,26x19.5x11,20 C-CERAMIC,DISC;680pF,10%,2KV,Y5P,TP,11x6,7.5m C-FILM,MPEF;4.7NF,5%,400V,TP,-,5MM C-CERAMIC,DISC;470pF,10%,1KV,Y5P,TP,8x5,5 C-AL;470uF,20%,25V,GP,10x16mm,5mm,T C-FILM,MPEF;10nF,5%,100V,TP,-,5mm C-CERAMIC,DISC;560pF,10%,500V,Y5P,TP,7x4,5 C-AL;22uF,20%,50V,GP,TP,5x11,5 C-FILM,MPPF;6.3nF,5%,1.6KV,TP,28.5x18x11.5 C-FILM,MPPF;3.9nF,5%,1.6KV,BK,31x15x8.5,20 C-FILM,PPF;33nF,10%,400V,TP,20x15x8,7.5

Loc. No.

C417 C418 C419 C421 C422 C423 C424 C425 C427 C504 C506 C510 C520 C530 C601 C602 C603 C604 C605 C606 C607 C701 C702 C703 C704 C705 C707 C709 C710 C711 C712 C713 C714 C715 C716 C717 C718 C719 C720 C721 C722 C723 C725 C727 C730 C731 C732 C733 C801 C802 C804 C805 C806 C807 C808 C809 C811 C812 C814 C815 C816 C817 C818 C819 C820 C821 C822 C823 C824 C825 C826 C827 C828

Code No.

2306-001017 2201-000556 2401-001397 2401-002619 2306-000122 2201-000556 2401-001527 2305-000154 2201-000984 2202-000862 2301-000213 2401-000430 2401-001232 2201-002063 2401-001914 2301-000204 2401-001333 2301-000192 2401-001914 2301-000204 2401-001998 2202-002037 2401-002144 2202-000243 2202-002037 2305-000289 2401-000302 2306-000122 2401-000302 2401-002235 2401-000480 2301-000247 2301-000289 2401-001991 2401-001991 2301-000289 2301-000247 2401-000480 2401-002235 2301-000175 2305-000289 2301-000175 2305-000289 2305-000289 2202-000231 2202-000231 2202-000231 2202-000231 2306-000321 2306-000321 2201-000332 2201-000332 2401-001140 2303-000163 2401-002292 2301-000224 2301-000310 2201-000446 2201-000683 2401-003026 2401-000293 2201-000599 2401-000722 2201-000599 2401-000722 2301-000192 2201-000599 2401-001840 2305-000289 2306-000122 2401-001840 2401-002235 2401-000493

Description ; Specification

Remark

C-FILM,MPPF;680NF,5%,400V,TP,26X14.5X24MM, C-CERAMIC,DISC;470pF,10%,500V,Y5P,TP,7x4,5 C-AL;470uF,20%,25V,GP,10x16mm,5mm,T C-AL;47uF,20%,25V,GP,TP,5x11,5 C-FILM,MPPF;100nF,5%,50V,TP,7.3x4.0x5.0mm, C-CERAMIC,DISC;470pF,10%,500V,Y5P,TP,7x4,5 C-AL;47uF,20%,250V,HR,TP,13x25mm,5m C-FILM,MPEF;100nF,5%,400V,TP,21.5x6.5x11.5 C-CERAMIC,DISC;680pF,10%,2KV,Y5P,TP,11x6,7.5m C-CERAMIC,MLC-AXIAL;390pF,10%,50V,Y5P,TP,3.5x1.9,C-FILM,PEF;220nF,5%,250V,TP,21.5x11,7.5 C-AL;10UF,20%,250V,GP,TP,10X16MM,5M C-AL;4.7uF,20%,250V,GP,TP,10x12.5,5 C-CERAMIC,DISC;10nF,+80-20%,3KV,Y5V,TP,16x5,7 C-AL;1uF,20%,50V,BP,TP,5x11,5 C-FILM,PEF;2.7nF,5%,50V,TP,7.4x3.9x13mm,5 C-AL;470nF,20%,50V,GP,TP,5x11,5 C-FILM,PEF;1nF,5%,50V,TP,5.3x10mm,5mm C-AL;1uF,20%,50V,BP,TP,5x11,5 C-FILM,PEF;2.7nF,5%,50V,TP,7.4x3.9x13mm,5 C-AL;1000UF,20%,25V,GP,TP,10X20,5MM C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-AL;47uF,20%,16V,GP,TP,5x11,5 C-CERAMIC,MLC-AXIAL;33PF,5%,50V,SL,3.5X19,-,TP C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. C-FILM,MPEF;220nF,5%,63V,TP,-,5mm C-AL;100uF,20%,25V,GP,TP,6.3x11,5 C-FILM,MPPF;100nF,5%,50V,TP,7.3x4.0x5.0mm, C-AL;100uF,20%,25V,GP,TP,6.3x11,5 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM C-AL;10uF,20%,50V,GP,TP,5x11,5 C-FILM,PEF;33nF,5%,50V,TP,8.1x4.5x13mm,5m C-FILM,PEF;5.6nF,5%,50V,TP,7x6x3,5 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 C-FILM,PEF;5.6nF,5%,50V,TP,7x6x3,5 C-FILM,PEF;33nF,5%,50V,TP,8.1x4.5x13mm,5m C-AL;10uF,20%,50V,GP,TP,5x11,5 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM C-FILM,PEF;15nF,5%,50V,TP,7.1x3.5x13mm,5m C-FILM,MPEF;220nF,5%,63V,TP,-,5mm C-FILM,PEF;15nF,5%,50V,TP,7.1x3.5x13mm,5m C-FILM,MPEF;220nF,5%,63V,TP,-,5mm C-FILM,MPEF;220nF,5%,63V,TP,-,5mm C-CERAMIC,MLC-AXIAL;330pF,10%,50V,Y5P,TP,3.5x19,C-CERAMIC,MLC-AXIAL;330pF,10%,50V,Y5P,TP,3.5x19,C-CERAMIC,MLC-AXIAL;330pF,10%,50V,Y5P,TP,3.5x19,C-CERAMIC,MLC-AXIAL;330pF,10%,50V,Y5P,TP,3.5x19,C-FILM,MPPF;470nF,5%,275V,TP,-,22.5mm C-FILM,MPPF;470nF,5%,275V,TP,-,22.5mm C-CERAMIC,DISC;2.2nF,20%,250VAC,Y5U,TP,11x7,7 C-CERAMIC,DISC;2.2nF,20%,250VAC,Y5U,TP,11x7,7 C-AL;330uF,20%,400V,GP,BK,35x45,10 C-FILM,PPF;2.2nF,5%,800V,TP,15x13x8.5,7.5 C-AL;47uF,20%,25V,WT,TP,8X11,5 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm,5m C-FILM,PEF;68nF,5%,50V,TP,8.0X8.5X4.0X5,5 C-CERAMIC,DISC;3.3nF,20%,400V,Y5U,TP,18x8,10m C-CERAMIC,DISC;850pF,10%,1KV,Y5P,TP,10x5,5 C-AL;330uF,20%,200V,GP,ST,22x35,10 C-AL;100uF,+30-10%,200V,HR,TP,16x25 C-CERAMIC,DISC;560pF,10%,500V,Y5P,TP,7x4,5 C-AL;2200uF,20%,25V,WT,TP,16x25,7.5 C-CERAMIC,DISC;560pF,10%,500V,Y5P,TP,7x4,5 C-AL;2200uF,20%,25V,WT,TP,16x25,7.5 C-FILM,PEF;1nF,5%,50V,TP,5.3x10mm,5mm C-CERAMIC,DISC;560pF,10%,500V,Y5P,TP,7x4,5 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm C-FILM,MPPF;100nF,5%,50V,TP,7.3x4.0x5.0mm, C-AL;100uF,20%,16V,GP,TP,6.3x11,5 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM C-AL;10uF,20%,50V,LZ,TP,5x11mm,5mm

7-3

Electrical Parts List

Loc. No.

C829 C830 C831 C832 C833 C834 C835 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C913 C914 C916 C917 C919 C920 C921 C922 C923 C924 C925 C926 C927 C928 CE01 CE02 CE03 CN501 CN502 CN502 CN602 CN701 CN802 CN901 CN901A CT01 CT02 CT03 CT04 CT05 CT06 CT08 CT11 CW701 CW901 D201 D202 D203 D204 D207 D209 D210 D217 D301 D302 D303 D304 D401 D402 D403 D404 D406 D407 D410 D507 D508 D509 D520 D601

7-4

Code No.

Description ; Specification

Remark

2401-000302 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2305-000665 C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-002144 C-AL;47uF,20%,16V,GP,TP,5x11,5 2201-000370 C-CERAMIC,DISC;220pF,10%,50V,Y5P,TP,4.0X4.0,5 2401-000142 C-AL;1000uF,20%,16V,WT,TP,10x20,5 2201-000234 C-CERAMIC,DISC;150pF,5%,50V,CH,TP,9.5x3,5 2301-000108 C-FILM,PEF;1.5nF,5%,50V,TP,6.5x3.0x5.5mm, 2201-000119 C-CERAMIC,DISC;100nF,+80-20%,50V,Y5V,TP,8x3.5 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2305-000665 C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, 2305-000665 C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-000796 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,2202-000796 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,2301-000445 C-FILM,PEF;4.7nF,5%,50V,TP,5.5x7x3mm,5mm 2401-002144 C-AL;47uF,20%,16V,GP,TP,5x11,5 2201-000980 C-CERAMIC,DISC;30pF,5%,50V,CH,TP,5.0x3.0,5mm 2201-000980 C-CERAMIC,DISC;30pF,5%,50V,CH,TP,5.0x3.0,5mm 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2202-000796 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,2401-000302 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2001-000007 R-CARBON;3KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2401-002597 C-AL;220uF,20%,35V,GP,TP,10x12.5,5 2305-000665 C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, 2305-000470 C-FILM,MPEF;68nF,5%,100V,TP,-,5mm AA39-20604ALEAD CONNECTOR-ASSY;-,YBNH250-09,YBNH05/04,5/4P,5 3711-002643 CONNECTOR-HEADER;BOX,4P,1R,2.5mm,STRAIGHT,SN AA39-20604ALEAD CONNECTOR-ASSY;-,YBNH250-09,YBNH05/04,5/4P,5 3711-002644 CONNECTOR-HEADER;BOX,5P,1R,2.5MM,STRAIGHT,SN 3711-002647 CONNECTOR-HEADER;BOX,8P,1R,2.5mm,STRAIGHT,SN AA27-20004GCOIL-DEGAUSSING;-,25,16.9ohm,35T,L2600,E 3711-002642 CONNECTOR-HEADER;BOX,3P,1R,2.5MM,STRAIGHT,SN 3711-002643 CONNECTOR-HEADER;BOX,4P,1R,2.5mm,STRAIGHT,SN 2305-000665 C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, 2401-000242 C-AL;100UF,20%,10V,GP,TP,6X11,5MM 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-000164 C-CERAMIC,MLC-AXIAL;180PF,10%,50V,Y5P,3.5X19,-,TP 2401-002144 C-AL;47uF,20%,16V,GP,TP,5x11,5 2401-001914 C-AL;1uF,20%,50V,BP,TP,5x11,5 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2503-000161 C-NETWORK;331*8 2503-000156 C-NETWORK;100pFx4,20%,50V 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0402-000216 DIODE-RECTIFIER;ERC24-06,600V,1.0A,DO-204 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0402-000493 DIODE-RECTIFIER;1R5GU41,400V,1.5A,DO-15L,TP 0402-000132 DIODE-RECTIFIER;1N4004,400V,1A,DO-41,TP 0402-000132 DIODE-RECTIFIER;1N4004,400V,1A,DO-41,TP 0402-001012 DIODE-RECTIFIER;FMP-3FU,1500V,5A,TO-3PF 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,TP 0402-000216 DIODE-RECTIFIER;ERC24-06,600V,1.0A,DO-204 0402-000493 DIODE-RECTIFIER;1R5GU41,400V,1.5A,DO-15L,TP 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,TP 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,TP 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,TP 0402-000132 DIODE-RECTIFIER;1N4004,400V,1A,DO-41,TP 0403-000296 DIODE-ZENER;MTZ5.6B,5.6V,5.45-5.73V,500mW,

Loc. No.

!

! !

! ! ! ! ! ! ! ! ! ! ! ! !

D602 D801 D802 D803 D804 D805 D806 D807 D808 D809 D810 D813 D901 D906 D907 DE01 DT02 DT05 DV801 DV802 DZ201 DZ203 DZ204 DZ205 DZ302 DZ303 DZ304 DZ305 DZ306 DZ402 DZ403 DZ505 DZ601 DZ602 DZ603 DZ604 DZ701 DZ702 DZ703 DZ704 DZ705 DZ801 DZ802 DZ803 DZ804 DZ805 DZ807 DZ808 DZ901 DZ904 DZ905 DZ906 F801 F801A F801B F802 F803 GT404 GT804HC101 IC201 IC301 IC501 IC601 IC701 IC801 IC802 IC803 IC804 IC901 IC902 ICE01 J206 J961 JA701 L101 L102

Code No.

Description ; Specification

Remark

0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0402-000213 DIODE-RECTIFIER;ERB12-06,600V,1.0A,DO-41,TP 0402-001160 DIODE-BRIDGE;D5SB60,600V,2.8A,SIP-4,ST 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0402-001230 DIODE;FMG-G2CS 0402-000493 DIODE-RECTIFIER;1R5GU41,400V,1.5A,DO-15L,TP 0402-000233 DIODE-RECTIFIER;FML-G12S,200V,5A,-,0402-000132 DIODE-RECTIFIER;1N4004,400V,1A,DO-41,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0402-000493 DIODE-RECTIFIER;1R5GU41,400V,1.5A,DO-15L,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP 1405-000187 VARISTOR;750V,1250A,12.5x7mm,TP 1405-000187 VARISTOR;750V,1250A,12.5x7mm,TP 0403-000297 DIODE-ZENER;MTZ6.2B,6.2V,5.96-6.27V,500mW, 0403-000298 DIODE-ZENER;MTZ6.8C,6.8V,6.66-7.01V,500mW, 0403-000662 DIODE-ZENER;MTZ3.0B,3.0V,3.01-3.22V,500mW, 0403-000551 DIODE-ZENER;MTZ3.9B,3.9V,3.89-4.16V,500mW, 0403-000545 DIODE-ZENER;MTZ24B,24V,22.61-23.77V,500mW, 0403-000545 DIODE-ZENER;MTZ24B,24V,22.61-23.77V,500mW, 0403-000545 DIODE-ZENER;MTZ24B,24V,22.61-23.77V,500mW, 0403-000494 DIODE-ZENER;MTZ39,39V,35.36-37.2V,500mW,DO 0403-000700 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,TP 0403-000300 DIODE-ZENER;MTZ8.2B,8.2V,7.78-8.19V,500mW, 0403-000698 DIODE-ZENER;TZP12A,12V,11.4-12.6V,1W,DO-41 0403-000563 DIODE-ZENER;MTZ9.1B,9.1V,8.57-9.01V,500mW, 0403-000545 DIODE-ZENER;MTZ24B,24V,22.61-23.77V,500mW, 0403-000545 DIODE-ZENER;MTZ24B,24V,22.61-23.77V,500mW, 0403-000545 DIODE-ZENER;MTZ24B,24V,22.61-23.77V,500mW, 0403-000545 DIODE-ZENER;MTZ24B,24V,22.61-23.77V,500mW, 0403-000563 DIODE-ZENER;MTZ9.1B,9.1V,8.57-9.01V,500mW, 0403-000563 DIODE-ZENER;MTZ9.1B,9.1V,8.57-9.01V,500mW, 0403-000563 DIODE-ZENER;MTZ9.1B,9.1V,8.57-9.01V,500mW, 0403-000563 DIODE-ZENER;MTZ9.1B,9.1V,8.57-9.01V,500mW, 0403-000563 DIODE-ZENER;MTZ9.1B,9.1V,8.57-9.01V,500mW, 0403-000300 DIODE-ZENER;MTZ8.2B,8.2V,7.78-8.19V,500mW, 0403-000296 DIODE-ZENER;MTZ5.6B,5.6V,5.45-5.73V,500mW, 0403-000296 DIODE-ZENER;MTZ5.6B,5.6V,5.45-5.73V,500mW, 0403-000296 DIODE-ZENER;MTZ5.6B,5.6V,5.45-5.73V,500mW, 1203-001217 IC-POSI.ADJUST REG.;431,TO-92,3P,4.58MIL,PLASTIC,2 0403-000296 DIODE-ZENER;MTZ5.6B,5.6V,5.45-5.73V,500mW, 0403-000562 DIODE-ZENER;MTZ7.5B,7.5V,7.07-7.45V,500mW, 1203-000451 IC-VOLTAGE REGULATOR;33,TO-92,3P,-,PLASTIC,31/35V, 0403-000563 DIODE-ZENER;MTZ9.1B,9.1V,8.57-9.01V,500mW, 0403-000296 DIODE-ZENER;MTZ5.6B,5.6V,5.45-5.73V,500mW, 0403-000296 DIODE-ZENER;MTZ5.6B,5.6V,5.45-5.73V,500mW, 3601-000281 FUSE-FERRULE;250V,4A,TIME LAG,GLASS,5x20mm 3602-000114 FUSE-HOLDER;-,-,30MOHM 3602-000114 FUSE-HOLDER;-,-,30MOHM 3601-001086 FUSE-FERRULE;125V,5A,FA,GLASS,2.4x7.5mm 3601-001086 FUSE-FERRULE;125V,5A,FA,GLASS,2.4x7.5mm AA39-20010DLEAD-CONNECTOR,ASSY;-,YFH800-01,S,1P,400,1617#22 AA39-20010B LEAD-CONNECTOR,ASSY;-,YFH800-01,S,1P,500,1617#22 AA13-20004WIC-HYBRID;-,PAP103T,SIP,6P,PRE-AMP,TP 0904-001294 IC-BUS CONTROLLER;8844,-,DIP,56P,600MIL,3.58MHz, 1204-000517 IC-VERTIVAL DEF.;LA7845,SIP,7P,-,PLASTIC,40V,11 1201-001330 IC-VIDEO AMP;6108,ZSIP,9P,-,SINGLE,-,PLASTI 1201-001064 IC-POWER AMP;7297,ZIP,15P,-,DUAL,32DB,PLAST 1204-000473 IC-AUDIO PROCESSOR;TDA9859,DIP,32P,-,PLASTIC,-,-, 1203-001482 IC-PWM CONTROLLER;3S1265R,TO-3P,5P,210,PLASTIC,6 0604-001038 PHOTO-COUPLER;TR,130-260%,200MW,DIP-4,ST 1203-001006 IC-VOLTAGE REGULATOR;78R05,TO-220F,4P,-,PLASTIC,4. 1203-000644 IC-POSI.FIXED REG.;7630,SIP,10P,-,PLASTIC,5.1/8V, AA13-00047AIC-MCU;-,SPM-511EE(0029),8BIT,DIP,CF6 1103-001043 IC-EEPROM;24C16,2Kx8BIT,DIP,8P,300MIL,10 1201-000191 IC-OP AMP;4558,DIP,8P,300MIL,DUAL,20V/mV 3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 3722-000195 JACK-SCART;42P,-,SN,BLK,NO 2701-000326 INDUCTOR-AXIAL;560nH,10%,2.3x3.4mm 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM

Samsung Electronics

Electrical Parts List

Loc. No.

Code No.

L103 L202 L205 L206 L207 L208 L303 L401 L402 L403 L404 L501 L601 L603 L701 L702 L703 L704 L705 L706 L707 L708 L709 L801 L802 L803 L804 L805 L806 L807 L808 L901 L903 L904 L905 L906 L907 LD901 LT02 Q201 Q202 Q204 Q207 Q209 Q210 Q301 Q302 ! Q401 ! Q402 ! Q403 Q701 Q702 Q801 Q901 Q902 Q903 Q904 Q905 Q907 Q908 QE01 QT01 QT02 R201 R202 R203 R204 R212 R214 R215 R218 R219 R220 R221 R222 R223 R224

2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000197 INDUCTOR-AXIAL;5.6UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000142 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM AA27-40003HCOIL-HORIZ,WIDTH;-,2MH,DR15X20,2UEW0.35,ST AA27-30001F COIL-LINEARITY;-,22uH,DR1011,PI0.45,25.5,-,20 3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G AA27-40003L COIL-HORIZ,WIDTH;-,1.0MH,DR14X20,2UEW0.45,ST 2901-000297 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G 3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM AA29-30001QFILTER-LINE;-,20MH,1.26A,-,BSF3050 3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G 3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G 2901-000299 FILTER-EMI ON BOARD;-,6A,UL/CSA,-,9x7.5,TP,2701-001032 INDUCTOR-AXIAL;100UH,10%,5X14MM 2901-000297 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G 3301-000287 CORE-FERRITE BEAD;AA,3.5x1x6mm,1500,2400G 2701-000189 INDUCTOR-AXIAL;470NH,10%,2.5X3.4MM 2701-000197 INDUCTOR-AXIAL;5.6UH,10%,2.5X3.4MM 2701-000211 INDUCTOR-AXIAL;68uH,10%,2.5x3.4mm 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM AA96-30001B ASSY-LED,GUIDE;-,AA61-50055A,DL-G5RGA,2901-000299 FILTER-EMI ON BOARD;-,6A,UL/CSA,-,9x7.5,TP,0501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000283 TR-SMALL SIGNAL;KSA539,PNP,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200502-000298 TR-POWER;KSD73,NPN,30W,TO-220,-,120-240 0502-001007 TR-POWER;KSC2073-H2,NPN,25W,TO-220,ST,6 0502-001136 TR-POWER;KSD5703,NPN,70W,TO-3PF,ST,80501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000369 TR-SMALL SIGNAL;KSC2331-Y,NPN,1W,TO-92L,-,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200504-000123 TR-DIGITAL;KSR1010,NPN,300mW,10K,TO-92,TP 0504-000123 TR-DIGITAL;KSR1010,NPN,300mW,10K,TO-92,TP 0504-000123 TR-DIGITAL;KSR1010,NPN,300mW,10K,TO-92,TP 0501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200501-000283 TR-SMALL SIGNAL;KSA539,PNP,400mW,TO-92,TP,1200501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,1200504-000125 TR-DIGITAL;KSR1012,NPN,300mW,47K,TO-92,TP 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000005 R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000793 R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000780 R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000515 R-CARBON;220OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000343 R-CARBON;130ohm,5%,1/8W,AA,TP,1.8x3.2mm 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2701-000142 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2001-000617 R-CARBON;3.9Mohm,5%,1/8W,AA,TP,1.8x3.2m 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM

Samsung Electronics

Description ; Specification

Remark

Loc. No.

R225 R226 R230 R233 R234 R235 R236 R237 R238 R241 R245 R246 R247 R248 R249 R250 R251 R252 R253 R255 R256 R257 R258 R259 R260 R261 R262 R301 R302 R303 R304 R305 R306 R307 R308 R309 R310 R311 R312 R313 R314 R315 R316 R317 R404 R405 R406 R407 R409 R410 R411 R412 R413 R414 R415 R417 R418 R419 R420 R421 R422 R424 R425 R426 R427 R428 R429 R430 R501 R502 R503 R505 R506 R507 R508 R509 R510

Code No.

2001-001026 2001-000793 2001-000331 2001-000780 2001-000780 2001-000780 2001-000832 2001-000605 2004-001993 2001-000429 2001-000739 2001-000273 2001-000281 2001-000793 2001-000429 2001-000938 2001-000281 2001-000563 2001-000591 2001-000008 2004-001234 2001-000563 2004-001914 2001-000281 2001-000290 2001-000331 2001-001015 2001-001049 2001-001049 2001-000016 2008-000254 2003-002069 2003-002069 2001-000290 2003-002069 2001-000290 2001-000387 2001-000660 2001-000786 2001-000449 2001-000281 2001-000290 2001-000660 2001-000449 2008-000254 2001-001138 2003-002008 2003-001025 2008-000264 2001-001114 2001-001199 2001-000020 2008-000251 2008-000278 2008-001011 2004-004086 2004-001967 2004-001390 2001-001114 2001-001043 2008-000254 2001-001043 2001-001043 2002-001012 2002-001012 2001-001043 2001-001043 2001-001043 2001-000429 2001-000429 2001-000429 2008-001076 2008-000299 2001-000490 2001-000490 2001-000490 2002-001009

Description ; Specification

Remark

R-CARBON;910ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;510OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;3.6KOHM,5%,1/8W,AA,TP,1.8X3.2M R-METAL;750KOHM,5%,1/8W,AA,TP,1.8X3.2M R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;4.7MOHM,5%,1/8W,AA,TP,1.8X3.2M R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X3.2M R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;68ohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;3.3KOHM,5%,1/8W,AA,TP,1.8X3.2M R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-METAL;75KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-METAL;39KOHM,2%,1/8W,AA,TP,1.8X3.5MM R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;9.1Kohm,5%,1/8W,AA,TP,1.8x3.2m R-CARBON(S);1.3Kohm,5%,1/2W,AA,TP,2.4x6.4m R-CARBON(S);1.3Kohm,5%,1/2W,AA,TP,2.4x6.4m R-CARBON(S);1OHM,5%,1/2W,AA,TP,2.4x6.4MM R-FUSIBLE(S);0.68ohm,5%,2W,AF,TP,3.9x10mm R-METAL OXIDE;470ohm,5%,2W,AF,TP,3.9x10mm R-METAL OXIDE;470ohm,5%,2W,AF,TP,3.9x10mm R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-METAL OXIDE;470ohm,5%,2W,AF,TP,3.9x10mm R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;16Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;33KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;33KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M R-FUSIBLE(S);0.68ohm,5%,2W,AF,TP,3.9x10mm R-CARBON(S);390ohm,5%,1/2W,AA,TP,2.4x6.4mm R-METAL OXIDE(S);18Kohm,5%,2W,AF,TP,3.9x10mm R-METAL OXIDE(S);15Kohm,5%,2W,AF,TP,3.9x10mm R-FUSIBLE(S);1OHM,5%,1W,AF,TP,3.9X10MM R-CARBON(S);270ohm,5%,1/2W,AA,TP,2.4x6.4mm R-CARBON(S);91ohm,5%,1/2W,AA,TP,2.4x6.4mm R-CARBON(S);22ohm,5%,1/2W,AA,TP,2.4x6.4mm R-FUSIBLE(S);0.27ohm,10%,2W,AF,TP,3.9x10mm R-FUSIBLE(S);82ohm,5%,2W,AA,TP,3.9x10mm R-FUSIBLE(S);0.18ohm,10%,2W,AF,TP,3.9x10mm R-METAL;56Kohm,1%,1/2W,AA,TP,2.5x6.5mm R-METAL(S);68KOHM,1%,1/2W,AA,TP,6.5X2.5MM R-METAL(S);1KOHM,2%,1/2W,AA,TP,2.4X6.4MM R-CARBON(S);270ohm,5%,1/2W,AA,TP,2.4x6.4mm R-CARBON(S);0OHM,5%,1/2W,AA,TP,2.4X6.4MM R-FUSIBLE(S);0.68ohm,5%,2W,AF,TP,3.9x10mm R-CARBON(S);0OHM,5%,1/2W,AA,TP,2.4X6.4MM R-CARBON(S);0OHM,5%,1/2W,AA,TP,2.4X6.4MM R-COMPOSITION;8.2Mohm,10%,1/2W,AA,TP,3.7x9mm R-COMPOSITION;8.2Mohm,10%,1/2W,AA,TP,3.7x9mm R-CARBON(S);0OHM,5%,1/2W,AA,TP,2.4X6.4MM R-CARBON(S);0OHM,5%,1/2W,AA,TP,2.4X6.4MM R-CARBON(S);0OHM,5%,1/2W,AA,TP,2.4X6.4MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-FUSIBLE(S);1.8ohm,5%,2W,AF,TP,3.9x10mm R-FUSIBLE(S);47ohm,5%,2W,AF,TP,3.9x10mm R-CARBON;200OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;200OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;200OHM,5%,1/8W,AA,TP,1.8X3.2MM R-COMPOSITION;2.7Kohm,10%,1/2W,AA,TP,3.7X9.0

7-5

Electrical Parts List

Loc. No.

R517 R518 R519 R520 R601 R602 R603 R604 R605 R606 R607 R701 R702 R703 R704 R705 R706 R707 R708 R709 R712 R713 R714 R715 R716 R717 R718 R719 R720 R721 R722 R723 R724 R725 R726 R727 R728 R729 R730 R731 R732 R733 R734 R735 R736 R740 R741 R801 R802 R803 R804 R805 R806 R807 R808 R809 R810 R811 R813 R814 R815 R816 R817 R818 R819 R820 R821 R822 R824 R826 R828 R901 R902 R903 R904 R905 R906

7-6

Code No.

Description ; Specification

2002-001009 2002-001009 2002-001009 2001-001062 2008-001002 2008-001002 2001-000472 2001-000331 2001-000429 2001-000472 2001-000331 2001-000281 2001-000281 2001-000515 2001-000515 2001-000281 2001-000281 2001-000515 2001-000515 2001-000969 2001-000331 2001-000969 2001-000429 2001-000969 2001-000660 2001-000331 2001-000969 2001-000527 2001-000387 2001-000786 2001-000290 2001-000387 2001-000786 2001-000969 2001-000429 2001-000290 2001-000281 2001-000281 2001-000429 2001-000290 2001-000290 2001-000969 2001-000969 2001-000969 2001-000660 2701-000114 2701-000114 2002-001011 2003-000994 2003-000994 2001-001150 2001-001150 2003-000458 2001-001178 2002-001011 2002-001013 2003-000487 2003-000510 2001-000429 2001-000449 2004-004364 2004-001983 2001-001153 2001-000290 2001-000290 2008-000294 2008-000271 2001-000290 2001-001125 2001-001153 2001-000022 2001-000290 2001-000290 2001-000066 2004-000218 2004-000218 2004-000218

Remark

R-COMPOSITION;2.7Kohm,10%,1/2W,AA,TP,3.7X9.0 R-COMPOSITION;2.7Kohm,10%,1/2W,AA,TP,3.7X9.0 R-COMPOSITION;2.7Kohm,10%,1/2W,AA,TP,3.7X9.0 R-CARBON(S);10Mohm,5%,1/2W,AA,TP,2.4x6.4mm R-FUSIBLE(S);0.18ohm,5%,2W,AA,TP,3.9x10mm R-FUSIBLE(S);0.18ohm,5%,2W,AA,TP,3.9x10mm R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;220OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;220OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;220OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;220OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;33KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;22OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;16Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;16Kohm,5%,1/8W,AA,TP,1.8x3.2mm R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;33KOHM,5%,1/8W,AA,TP,1.8X3.2MM INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM R-COMPOSITION;3.3Mohm,10%,1/2W,AA,TP,3.7x9mm R-METAL OXIDE(S);33Kohm,5%,2W,AF,TP,3.9x10mm R-METAL OXIDE(S);33Kohm,5%,2W,AF,TP,3.9x10mm R-CARBON(S);470Kohm,5%,1/2W,AA,TP,2.4x6.4m R-CARBON(S);470Kohm,5%,1/2W,AA,TP,2.4x6.4m R-METAL OXIDE(S);100ohm,5%,2W,AF,TP,4x12mm R-CARBON(S);680ohm,5%,1/2W,AA,TP,2.4x6.4mm R-COMPOSITION;3.3Mohm,10%,1/2W,AA,TP,3.7x9mm R-COMPOSITION;4.7Mohm,10%,1/2W,AA,TP,3.7x9mm R-METAL OXIDE(S);12Kohm,5%,2W,AA,TP,4x12mm R-METAL OXIDE(S);15Kohm,5%,2W,AA,TP,4x12mm R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M R-METAL(S);152Kohm,1%,1/2W,AA,TP,2.4x6.4m R-METAL;2.49KOHM,1%,1/2W,AA,TP,2.4X6.4 R-CARBON(S);47OHM,5%,1/2W,AA,TP,2.4X6.4MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-FUSIBLE(S);33ohm,5%,2W,AF,TP,3.9x10mm R-FUSIBLE(S);3.3OHM,5%,2W,AA,TP,3.9X10MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON(S);300Kohm,5%,1/2W,AA,TP,2.4x6.4m R-CARBON(S);47OHM,5%,1/2W,AA,TP,2.4X6.4MM R-CARBON(S);33ohm,5%,1/2W,AA,TP,2.4x6.4mm R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM R-CARBON(S);10Kohm,5%,1/2W,AA,TP,2.4x6.4mm R-METAL;10KOHM,1%,1/8W,AA,TP,1.8X3.2MM R-METAL;10KOHM,1%,1/8W,AA,TP,1.8X3.2MM R-METAL;10KOHM,1%,1/8W,AA,TP,1.8X3.2MM

Loc. No.

! ! ! ! !

R908 R909 R910 R911 R912 R913 R914 R918 R919 R920 R921 R922 R923 R924 R925 R926 R927 R928 R929 R930 R932 R933 R934 R935 R936 R937 R941 R942 R943 R945 R948 R951 R953 R954 R955 RE01 RE02 RE03 RE04 RE05 RE06 RE07 RE08 RE09 RE10 RL801 RM901 RP802 RP803 RT01 RT02 RT03 RT04 RT05 RT06 RT07 RT17 RT18 RT19 RT20 RT22 RT23 RT24 RW901 SF101 SW801 SW901 SW902 SW903 SW904 SW905 T401 T444 T801 TU101 V999 X202

Code No.

Description ; Specification

Remark

2001-000241 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2004-001126 R-METAL;6.2KOHM,1%,1/8W,AA,TP,1.8X3.2M 2001-000924 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000214 R-CARBON;1.1KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000241 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000273 R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000924 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000924 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2001-000628 R-CARBON;300OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000780 R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000780 R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-001062 R-CARBON(S);10Mohm,5%,1/2W,AA,TP,2.4x6.4mm 0403-000551 DIODE-ZENER;MTZ3.9B,3.9V,3.89-4.16V,500mW, 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000793 R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2004-001390 R-METAL(S);1KOHM,2%,1/2W,AA,TP,2.4X6.4MM 2004-001914 R-METAL;39KOHM,2%,1/8W,AA,TP,1.8X3.5MM 2001-000066 R-CARBON(S);10Kohm,5%,1/2W,AA,TP,2.4x6.4mm 2001-001142 R-CARBON(S);3Kohm,5%,1/2W,AA,TP,2.4x6.4mm 2001-000052 R-CARBON(S);3.3Kohm,5%,1/2W,AA,TP,2.4x6.4m 2004-001390 R-METAL(S);1KOHM,2%,1/2W,AA,TP,2.4X6.4MM 2003-002069 R-METAL OXIDE;470ohm,5%,2W,AF,TP,3.9x10mm 2001-001120 R-CARBON(S);3.3ohm,5%,1/2W,AA,TP,2.4x6.4mm 2001-001125 R-CARBON(S);300Kohm,5%,1/2W,AA,TP,2.4x6.4m 2001-001125 R-CARBON(S);300Kohm,5%,1/2W,AA,TP,2.4x6.4m 3501-001040 RELAY-POWER;12VDC,500mW,10A,1FormA,15mS,5m AA59-60001UMODULE-REMOCON;-,ORC-50VF/SR-12V,38KHz,940nm, 1404-001045 THERMISTOR-NTC;4.7OHM,15%,2900K,35.0MW,T 1404-001087 THERMISTOR-PTC;7ohm,30%,220V,270V,19A,-,ST 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000780 R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000539 R-CARBON;24KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2202-000825 C-CERAMIC,MLC-AXIAL;680pF,10%,50V,Y5P,TP,3.5x19,2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000232 R-CARBON;1.3KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000628 R-CARBON;300OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000628 R-CARBON;300OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000628 R-CARBON;300OHM,5%,1/8W,AA,TP,1.8X3.2MM 2011-000157 R-NETWORK;10K,5%,1/8W,A,SIP,6P,TP 2904-000302 FILTER-SAW AV;38.90MHz,-,ST,13.9dB,PAL-B/G,3403-000179 SWITCH-PUSH;250V,5A,DPST,-,JPW-2104B 3404-000244 SWITCH-TACT;12V,50mA,100-160gf,8.4x22.6mm, 3404-000244 SWITCH-TACT;12V,50mA,100-160gf,8.4x22.6mm, 3404-000244 SWITCH-TACT;12V,50mA,100-160gf,8.4x22.6mm, 3404-000244 SWITCH-TACT;12V,50mA,100-160gf,8.4x22.6mm, 3404-000244 SWITCH-TACT;12V,50mA,100-160gf,8.4x22.6mm, AA26-50001R TRANS-HORIZ DRIVE;-,80MH,580UH,4UH,G11A EI19,ST AA26-30005UTRANS-FLYBACK;-,FUH-29A003,29,155V AA26-20007X TRANS-SWITCHING;-,90~260,155/15.5/12/8V,VDE,SE AA40-10006B TUNER-V/S;TECC0949VG28A(S),PAL-B/G,TR,18 3704-001105 SOCKET-CRT;11P,20PI,26.5PI,NI,2801-003726 CRYSTAL-UNIT;4.433619MHz,20ppm,28-AAM,20pF,

Samsung Electronics

Electrical Parts List

Loc. No.

X203 XT01 Z208

Code No.

Description ; Specification

Remark

2801-000226 CRYSTAL-UNIT;3.579545MHz,20ppm,28-AAM,15pF, 2801-003433 CRYSTAL-UNIT;12MHz,30ppm,28-AAA,30pF,30ohm, 2903-000181 FILTER-CERAMIC;TR,5.5MHz,-,-,-,TP,TPS5.5MB-TF

ASSY-PCB,A/V FRONT *

HA95-900009 ASSY-PCB,A/V FRONT;SCT12A/12B

CA02 CA03 CA04 CA05 CA06 CA07 CN01A CN05A CN06A JE01 JR01 LA02 LA03 LA04 LA05 RA01 RA02

2202-000121 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP,1.9x3.5,2202-000121 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP,1.9x3.5,2202-000720 C-CERAMIC,MLC-AXIAL;8.2NF,20%,16V,Y5R,3.5X19,-,TP 2202-000720 C-CERAMIC,MLC-AXIAL;8.2NF,20%,16V,Y5R,3.5X19,-,TP 2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 AA39-20068E LEAD-CONNECTOR,ASSY;-,YBNH025-08,67096-0 AA39-20069ALEAD-CONNECTOR,ASSY;-,YBNH025-05,67096-0 AA39-20499B LEAD CONNECTOR-ASSY;-,YBNH025-04,SMP025-04,4P,200 3722-000143 JACK-PHONE;1P(VER),3.4mm,AG,BLK,NO 3722-001031 JACK-RCA;3P,3.6MM,#18,AU 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000180 INDUCTOR-AXIAL;33UH,5%,2.5X3.4MM 2701-000180 INDUCTOR-AXIAL;33UH,5%,2.5X3.4MM 2001-000028 R-CARBON(S);100ohm,5%,1/2W,AA,TP,2.4x6.4mm 2001-000028 R-CARBON(S);100ohm,5%,1/2W,AA,TP,2.4x6.4mm

ASSY-R/G/B,SWITCHING *

HA95-90009S ASSY-R/G/B,SWITCHING;-,-,S51A,PHILIPS MICOM ALL,-,

CNS01 CNS02 CNS03 CS01 CS02 CS03 CS04 CS05 CS06 CS07 CS08 DS01 H001 ICS01 RS01 RS04 RS06 RS07 RS08 RS09 RS10 RS11 RS12 RS13 RS14 RS15 RS16 RS17 RS18

3711-002702 CONNECTOR-HEADER;NOWALL,4P,1R,2.5mm,ANGLE,SN 3711-002703 CONNECTOR-HEADER;NOWALL,5P,1R,2.5mm,ANGLE,SN AA39-20052F LEAD CONNECTOR-ASSY;-,YBNH025-04,YSH025-04,4P,200 2401-002619 C-AL;47uF,20%,25V,GP,TP,5x11,5 2305-000665 C-FILM,MPEF;100NF,5%,63V,TP,7.5X4.0X5.0MM, 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 2202-002037 C-CERAMIC,MLC-AXIAL;100nF,80-20%,50V,Y5V,TP,2.2x3. 0401-000005 DIODE-SWITCHING;1N4148,75V,300MA,DO-35,TP AA61-10068ABRACKET-PCB;-,M2160,SPTE,T0.3,-,-,1001-000223 IC-VIDEO SWITCH;TEA5114A,-,DIP,16P,334MIL,SING 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000003 R-CARBON;330OHM,5%,1/8W,AA,TP,1.8X3.2MM

ASSY-SOUND *

AA95-40012AASSY-SOUND;-,-,S51A,SECAM-L,NICAM,CF ALL,

CN01 CN02 CN03 CN04 CN05 CN06 CN07 CN08 CN09 CN10 CN11

2203-000260 2203-000260 2203-000891 2203-002392 2401-000620 2401-000030 2203-000192 2203-001002 2203-000192 2203-000260 2401-000620

Samsung Electronics

C-CERAMIC,CHIP;10NF,10%,50V,X7R,TP,2012 C-CERAMIC,CHIP;10NF,10%,50V,X7R,TP,2012 C-CERAMIC,CHIP;4.7NF,10%,50V,X7R,TP,2012 C-CERAMIC,CHIP;220nF,+80-20%,50V,Y5V,TP, C-AL;2.2uF,10%,50V,GP,TP,5x11,5 C-AL;22uF,20%,25V,GP,TP,5x11,5 C-CERAMIC,CHIP;100nF,+80-20%,50V,Y5V,TP, C-CERAMIC,CHIP;.047NF,5%,50V,NPO,TP,2012 C-CERAMIC,CHIP;100nF,+80-20%,50V,Y5V,TP, C-CERAMIC,CHIP;10NF,10%,50V,X7R,TP,2012 C-AL;2.2uF,10%,50V,GP,TP,5x11,5

Loc. No.

CN12 CN13 CN14 CN15 CN16 CN17 CN18 CN19 CN20 CN21 CN22 CN23 CN24 CN25 CN26 CN27 CN28 CN29 CN30 CN31 CN32 CN33 CN34 CN35 CN36 CN37 CN38 CN39 CNN01 CNN02 DN01 DN02 DN03 HN01 ICN01 ICN02 JN01 JN02 LN01 LN02 LN03 LN04 LN05 LN06 LN07 QN01 QN02 QN03 QN04 QN05 RN01 RN02 RN03 RN04 RN05 RN06 RN07 RN08 RN09 RN10 RN11 RN12 RN13 RN14 RN15 RN16 RN17 RN18 RN19 RN20 RN21 RN22 RN23 RN25 RN26 RN27 RN28

Code No.

Description ; Specification

Remark

2203-000784 C-CERAMIC,CHIP;330pF,5%,50V,NPO,TP,2012, 2203-000784 C-CERAMIC,CHIP;330pF,5%,50V,NPO,TP,2012, 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5 2203-000925 C-CERAMIC,CHIP;470NF,+80-20%,50V,Y5V,TP, 2203-000925 C-CERAMIC,CHIP;470NF,+80-20%,50V,Y5V,TP, 2203-000925 C-CERAMIC,CHIP;470NF,+80-20%,50V,Y5V,TP, 2203-000802 C-CERAMIC,CHIP;33NF,10%,50V,X7R,TP,2012 2203-002442 C-CERAMIC,CHIP;330NF,+80-20%,25V,Y5V,TP, 2203-000389 C-CERAMIC,CHIP;15pF,5%,50V,NPO,TP,2012,2203-000818 C-CERAMIC,CHIP;.033NF,5%,50V,NPO,TP,2012 2203-000925 C-CERAMIC,CHIP;470NF,+80-20%,50V,Y5V,TP, 2203-000192 C-CERAMIC,CHIP;100nF,+80-20%,50V,Y5V,TP, 2401-000603 C-AL;1uF,20%,50V,GP,TP,5x11,5 2203-000925 C-CERAMIC,CHIP;470NF,+80-20%,50V,Y5V,TP, 2203-000925 C-CERAMIC,CHIP;470NF,+80-20%,50V,Y5V,TP, 2401-002144 C-AL;47uF,20%,16V,GP,TP,5x11,5 2203-000925 C-CERAMIC,CHIP;470NF,+80-20%,50V,Y5V,TP, 2401-000471 C-AL;10uF,20%,50V,BP,TP,5x11,5mm 2203-000260 C-CERAMIC,CHIP;10NF,10%,50V,X7R,TP,2012 2203-000260 C-CERAMIC,CHIP;10NF,10%,50V,X7R,TP,2012 2203-000701 C-CERAMIC,CHIP;2pF,0.25pF,50V,NPO,TP,201 2401-000242 C-AL;100uF,20%,10V,GP,TP,5x11,5 2401-000620 C-AL;2.2uF,10%,50V,GP,TP,5x11,5 2401-002144 C-AL;47uF,20%,16V,GP,TP,5x11,5 2203-000192 C-CERAMIC,CHIP;100nF,+80-20%,50V,Y5V,TP, 3711-002704 CONNECTOR-HEADER;NOWALL,6P,1R,2.5mm,ANGL 3711-002705 CONNECTOR-HEADER;NOWALL,7P,1R,2.5mm,ANGL 0401-000160 DIODE-SWITCHING;ISS314,30V,100mA,USC,TP 0401-000160 DIODE-SWITCHING;ISS314,30V,100mA,USC,TP 0405-000108 DIODE-VARACTOR;BB405B,28V,10nA,D AA61-10068ABRACKET-PCB;-,M2160,SPTE,T0.3,-,-,1209-000218 IC-PLL;TDA9814T,SOP,28P,-,PLASTIC,5.5 1209-001113 IC-ETC, LINEAR;TDA9874H,QFP,44P,-,PLASTI 2007-000029 R-CHIP;0OHM,5%,1/10W,DA,TP,2012 2007-000029 R-CHIP;0OHM,5%,1/10W,DA,TP,2012 2901-000297 FILTER-EMI ON BOARD;-,3A,-,-,3.5x5,TP,2901-000297 FILTER-EMI ON BOARD;-,3A,-,-,3.5x5,TP,2701-000168 INDUCTOR-AXIAL;3.3uH,5%,2.5x3.4mm 2901-000297 FILTER-EMI ON BOARD;-,3A,-,-,3.5x5,TP,2901-000297 FILTER-EMI ON BOARD;-,3A,-,-,3.5x5,TP,2701-000114 INDUCTOR-AXIAL;10uH,10%,2.5x3.4mm 2701-000202 INDUCTOR-AXIAL;560nH,10%,2.5x3.4mm 0501-000727 TR-SMALL SIGNAL;BC848C,NPN,310mW,SOT-23, 0501-000727 TR-SMALL SIGNAL;BC848C,NPN,310mW,SOT-23, 0501-000727 TR-SMALL SIGNAL;BC848C,NPN,310mW,SOT-23, 0501-000727 TR-SMALL SIGNAL;BC848C,NPN,310mW,SOT-23, 0501-000727 TR-SMALL SIGNAL;BC848C,NPN,310mW,SOT-23, 2007-000941 R-CHIP;47KOHM,5%,1/10W,DA,TP,2012 2007-001071 R-CHIP;6.8KOHM,5%,1/10W,DA,TP,2012 2007-000774 R-CHIP;33KOHM,5%,1/10W,DA,TP,2012 2007-001071 R-CHIP;6.8KOHM,5%,1/10W,DA,TP,2012 2007-000941 R-CHIP;47KOHM,5%,1/10W,DA,TP,2012 2007-001071 R-CHIP;6.8KOHM,5%,1/10W,DA,TP,2012 2007-000981 R-CHIP;5.6KOHM,5%,1/10W,DA,TP,2012 2007-000030 R-CHIP;560OHM,5%,1/10W,DA,TP,2012 2007-000766 R-CHIP;330OHM,5%,1/10W,DA,TP,2012 2007-000586 R-CHIP;22KOHM,5%,1/10W,DA,TP,2012 2007-000586 R-CHIP;22KOHM,5%,1/10W,DA,TP,2012 2007-000308 R-CHIP;10OHM,5%,1/10W,DA,TP,2012 2007-000308 R-CHIP;10OHM,5%,1/10W,DA,TP,2012 2007-000881 R-CHIP;4.7OHM,5%,1/10W,DA,TP,2012 2007-000830 R-CHIP;39KOHM,5%,1/10W,DA,TP,2012 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012 2007-000830 R-CHIP;39KOHM,5%,1/10W,DA,TP,2012 2007-001177 R-CHIP;8.2KOHM,5%,1/10W,DA,TP,2012 2007-000308 R-CHIP;10OHM,5%,1/10W,DA,TP,2012 2007-000308 R-CHIP;10OHM,5%,1/10W,DA,TP,2012 2007-000290 R-CHIP;100OHM,5%,1/10W,DA,TP,2012 2007-000290 R-CHIP;100OHM,5%,1/10W,DA,TP,2012 2007-000881 R-CHIP;4.7OHM,5%,1/10W,DA,TP,2012 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012 2007-000308 R-CHIP;10OHM,5%,1/10W,DA,TP,2012 2007-000941 R-CHIP;47KOHM,5%,1/10W,DA,TP,2012 2007-000774 R-CHIP;33KOHM,5%,1/10W,DA,TP,2012

7-7

Electrical Parts List

Loc. No.

RN29 RN30 SFN01 SFN02 TN01 XN01

Code No.

Description ; Specification

Remark

Loc. No.

Code No.

Description ; Specification

Remark

2007-000941 R-CHIP;47KOHM,5%,1/10W,DA,TP,2012 2007-000774 R-CHIP;33KOHM,5%,1/10W,DA,TP,2012 2904-000301 FILTER-SAW AV;38.90MHz,SIP5K,ST,14.5dB,P 2904-000259 FILTER-SAW AV;38.9MHz,SIP5P,ST,15dB,PALAA26-10004E TRANS-IF;-,7MG,VIF,-,7mm,8pF,116.7MHz,S 2801-003316 CRYSTAL-UNIT;24.576MHZ,30PPM,28-AAM,20PF

ASSY-CRT !

AA03-10026Y CRT-COLOR;-,A59EEQ111X91,+400MG,25,110D

ASSY-POWER,CORD ! P/CORD

AA96-00175AASSY-POWER,CORD;-,CP2/NO(4.0),H/C450,KKJ1004A,

ASSY-SPEAKER 3001-000150 SPEAKER;20W,8ohm,91dB,130Hz AA39-20452F LEAD CONNECTOR-ASSY;-,YFH800-01,CLIP,1P,600MM,1617 AA39-20502ALEAD CONNECTOR-ASSY;-,SMH025-04,REC,4P,300.700,100

REMOCON *

AA59-10117AREMOCON;DP,TM59,-,-,-,-,-,AA59-10116A,

ASSY-ACCESSORY HA68-00336ACARD-WARRANTY;-,A/P100(G),A5,-,-,WARRANTY,IN HA68-00332AMANUAL-USERS;S51A,GER,FRA,-,-,A/P100(G),AA63-30190ACOVER-JACK;-,5944,-,ELASTOMER,HB,BLK,-,HA68-00333ACARD;S51A,A/P100(G),A5,-,-,OSD,HA68-00033B MANUAL-USERS;S51A,ITA,-,B5,W/P100(G),-

7-8

Samsung Electronics

Block Diagram

8. Block Diagram 8-1 S51A

AUDIO-MODULE SIF SAW FILTER

TDA9814T SIF-DETECTOR

SPEAKER 8W 10W X 2

AUDIO-PROCESSOR TDA9874 NICAM DECODER

TDA7297

TDA9859

2CH AUDIO AMP CRT

TUNER TELE4-108A

SPM-171EE IC MCU (TTX)

FREE-AMP PAP103

RGB-AMP TDA6108

VIF SAW FILTER G3956M

H E A T E R

1 CHIP IF/VIDEO/CHROMA/DEFLECTION TDA8844

VERTICAL AMP LA7845

V

H HV

+16.5V / -14V

EEPROM X24C16 H-OUT TR FBT 16.5V FUH-29A003 180V 155V 5V KA7630 SMPS AC INPUT AC230V OR 220 ~ 240V

Samsung Electronics

STR KA3S1265R

8V

TRANS 15V

8-1

PCB Layout

9. PCB Layout 9-1 PCB Main Loc. No.

X

Y

DIODE

X

D101 D201 D202 D203 D204 D205 D206 D209 D210 D217 D301 D302 D303 D304 D401 D402 D403 D404 D405 D406 D407 D410 D507 D508 D509 D520 D601 D602 D603 D701 D801 D802 D803 D804 D805 D806 D807 D808 D809 D810 D812 D813 D901 D902 D903 D904 D905 D906 D907 DE01 DL201 DT01 DT02 DT03 DT04 DV801 DV802 DX01 DX02 DZ201 DZ202 DZ203 DZ204 DZ205 DZ206 DZ210 DZ302 DZ303 DZ304 DZ305 DZ306 DZ402 DZ403 DZ501 DZ502

78 171 168 166 163 155 125 112 127 30 105 124 105 97 114 128 70 89 106 37 20 10 312 312 312 268 214 223 223 172 246 255 230 228 173 168 156 269 187 183 160 167 231 188 188 188 199 229 227 94 155 260 242 201 223 264 251 19 60 142 106 155 158 125 121 109 107 99 102 94 118 90 75 309 316

236 131 131 131 139 226 167 164 148 238 131 104 84 121 67 126 109 28 148 109 76 86 223 220 216 225 205 200 198 210 31 60 37 31 22 39 63 92 122 132 70 100 138 143 140 138 161 124 124 108 206 120 116 161 128 7 7 8 7 197 218 120 229 148 170 148 121 108 131 133 135 91 165 190 190

Loc. No.

X

Y

DZ503 DZ505 DZ601 DZ602 DZ603 DZ604 DZ701 DZ702 DZ703 DZ704 DZ705 DZ801 DZ802 DZ803 DZ804 DZ805 DZ807 DZ808 DZ901 DZ904 DZ905 DZ906 DZX01

296 321 223 223 223 223 49 54 59 41 64 231 218 150 177 183 166 209 227 211 280 321 39 IC

190 190 213 215 223 220 148 148 148 141 148 33 26 122 120 12 120 19 165 145 108 82 13

HC101 IC201 IC301 IC501 IC601 IC701 IC801 IC802 IC803 IC804 IC901 IC902 IC903 ICE01

60 85 123 315 238 17 245 201 201 148 267 274 193 130

224 198 132 178 185 190 9 19 95 127 134 105 120 118

TRANSISTOR Q101 Q201 Q202 Q204 Q205 Q206 Q207 Q209 Q210 Q211 Q212 Q301 Q302 Q401 Q402 Q403 Q404 Q701 Q702 Q704 Q801 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 QE01 QT01 QT02 QX01

71 159 149 87 139 133 146 146 121 196 199 119 111 143 83 43 83 54 54 183 293 240 251 251 251 246 204 231 227 155 140 201 245 43

213 131 132 230 219 219 219 172 183 182 193 91 96 74 130 97 134 162 182 215 97 163 234 222 215 148 150 128 128 230 96 127 139 8

Y Samsung Electronics

9-1

Wiring Diagram

10. Wiring Diagram 10-1 S51A R ANODE L

CRT ASSY-PWB FRONT,A/V

DY

CN701A A S S Y -P W B M A IN

M I C O M

SW801

CN05A

CN501B FOCUS

SOCKET CRT

CN06A

SCR EE N S O U ND A MP CN602 P IP /T T X MO D U L E

S MP S T R ANS

T D A 8 8 4 4

CN501

CN401

FBT CN701

M O D U L E

A U D I O

T U N E R

CN502

Samsung Electronics

10-1

MEMO

10-2

Samsung Electronics

Schematic Diagrams

11. Schematic Diagrams 11-1 MAIN (Power 21”) 8

51

1

2

3

4

5

6

7

8

9

10

51

11

6

50

4

5 7

9

10

1 11

2 3

50

: Power Line : Signal Line

Samsung Electronics

11-1

Schematic Diagrams

11-2 MAIN (Power 25” - 30”) 8

51

1

2

3

4

5

6

7

8

9

10

11

12

6 50 4

5 7

1

12 10 9 11

2

3

50

51

: Power Line : Signal Line

11-2

Samsung Electronics

Schematic Diagrams

11-3 PWB MAIN (One-Chip)

: Power Line : Signal Line

13

14

15

16

17

18

19

20

21

22

23

24

13 26 27 29

30

25

24

28

23 32

31 22 18

21

17

16

20

15

14

19

32

Samsung Electronics

31

30

29

28

27

26

25

11-3

Schematic Diagrams

11-4 PWB MAIN (u-COM)

33

33

34

35

36

37

38

39

40

41

42

42 41

40

35

39

34

38 37 36

: Power Line : Signal Line

11-4

Samsung Electronics

11-5 PWB-MAIN (u-COM) 33

34

35

36

37

38

39

40

41

42

46

47 33

42

41

49

40

48

35

34

36

37 38

39 : Power Line : Signal Line

Samsung Electronics

: Power Line : Signal Line

11-5

Schematic Diagrams

11-6 PWB MAIN (A/V-SWITCHING) 46

46 47

47

48

49

49

48

: Power Line : Signal Line

11-6

Samsung Electronics

11-7 PWB-SOUND (Nicam / Dolby)

Samsung Electronics

11-7

Schematic Diagrams

11-8 PWB MAIN (Sound Module Mono)

11-8

Samsung Electronics

Schematic Diagrams

11-9 PWB MAIN (CRT-V/M) 43

43

44

44 45 43

45

44 45

OPTION

: Power Line : Signal Line

Samsung Electronics

11-9

Schematic Diagrams

11-10 PWB MAIN (SOUND MODULE A2-STEREO)

11-10

Samsung Electronics

Schematic Diagrams

11-11 PWB MAIN (SOUND MODULE L-NICAM)

Samsung Electronics

11-11

Schematic Diagrams

11-12 PWB MAIN (A/V FRONT / VIDEO SWITCH)

RGB - S/W MODULE

11-12

Samsung Electronics

ELECTRONICS

© Samsung Electronics Co., Ltd. JUL.1999 Printed in Korea 3S51A-4418